2022 Chevrolet Tahoe Powertrain (other) Problems

The transmission began slipping at 20, 25, 35, and 45 mph by the time we hit 80k miles. The vehicle was out of warranty. We were told it was unaffected by the recalls and not related to the issues affecting other drivers. It now has 167k miles and we have tried having the transmission flushed but it still slips and needs a new transmission. Chevy knows about these issues and refuses to replace their horrible product since they also sell the cure to the problem and make money off of it.

NHTSA ID

11756422

Incident

Aug 12, 2026

2022 Chevy Tahoe went into limp mode at 62,500 miles out of the blue and check engine light came on. At the certified Chevy dealership I was told it was the transmission control valve, Code P2732, which is a known widespread factory issue in these models. Upon further inspection, was told my transmission fluid was completely black and burned and it ruined the transmission and therefore it needs to be replaced. "Consequential Damage Policy: When a control valve body fails and stays "stuck on," it forces maximum line pressure through the system. Continuing to drive under these conditions quickly destroys the internal clutch packs, burns the fluid, and melts down the transmission." This is exactly what happened and my vehicle was never put on a recall list but clearly was a ticking time bomb.

NHTSA ID

11755417

Incident

Aug 4, 2026

Driving the vehicle down the highway at approximately 65 miles per hour, the check engine light came on and the engine went into limp mode, slowing immediately. Upon getting the vehicle to the left shoulder on a busy highway, the vehicle displayed "engine overheating", "battery low", and 0% oil life. A full oil and filter change had been done less than 1000 miles ago and upon checking the oil, it was at the correct level. The engine completely failed and is not being replaced at a Chevrolet dealership. I completed the recall N252494003 on March 5th, 2026 which comprised of an engine inspection, higher viscosity oil, a new oil cap, filter replacement, and owner's manual insert. The engine still failed and required replacement despite having this done.

NHTSA ID

11751156

Incident

Jun 30, 2026

My vehicle has suffered a Transmission Control Valve Failure (stuck open). This is the exact mechanical failure detailed in GM’s Nationwide Recall N24245441-02. It is deeply disheartening and illogical that my vehicle—which shares the exact year, make, model, and identical mechanical failure detailed in the safety bulletin—is excluded from the recall purely due to an arbitrary VIN filtering process

NHTSA ID

11737772

Incident

May 10, 2026

The contact owns a 2022 Chevrolet Tahoe. The contact stated that at approximately 55,000 miles, the vehicle experienced a torque converter failure, and the torque converter was replaced under the factory warranty. The contact stated that four months later, the failure reoccurred, and the dealer declined to cover the repair. Subsequently, the camshaft failed, leading to a recommendation for a complete engine replacement. The contact stated that old parts from the original engine were installed on the new engine without authorization. Two months after the engine replacement, the transmission valve body failed while the vehicle was 237th on a back-order list. Three months after a second transmission repair, the vehicle suffered another transmission failure. The contact was informed that the transmission was new but discovered but was being charged for the installation of old, faulty parts from the original engine onto the new powertrain. The vehicle was currently at the dealer, and the contact was without transportation. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 130,000.

NHTSA ID

11731482

Incident

Dec 1, 2024

Mileage

130,000 mi

Car got stuck between gears while driving on the road. The vehicle accelerated by itself almost causing me to crash. I immediately pulled over into a business and put the truck in park. The car stayed on. It turned on and off but would not shift gears. Would not go from park to reverse or drive. And unfortunately the “warranty” only cover 60k miles. Conveniently right before this well known issue goes out. The main issue was Pressure Control Solenoid C Stuck On. This issue is an issue many people are having and since it is a drivetrain issue this can affect many lives while on the road.

NHTSA ID

11730934

Incident

Apr 10, 2026

Had issues transitioning to reverse, drove vehicle to the dealership. While driving on a busy road vehicle went into limp mode and had to pull over. Vehicle needed to be towed to the dealership. Dealership was able to verify vehicle was unable to reverse. They also found P0700 and P0776 error codes. They also used service bulletin 22-NA-258. We had not noticed excessively harsh shifting prior to this event. Had to replace components in the valve body

NHTSA ID

11729815

Incident

Mar 13, 2026

I had the car in for a message (service transmission now will not be able to shift soon). They told me there was nothing wrong with my transmission it was a parking brake sensor issue. They ordered me a new sensor and never called to tell me it was in. I followed up and they said they had the part and I could come in whenever. They said it was not a safety issue and would be a quick fix. I had an appt today and to my surprise when I went to drive to the appt my car will not let me shift out of park with a new message (service transmission, unable to shift). I am now waiting for the car to be towed. This car has had nothing but issues including the back-up camera not working properly for 2 years. These are all serious safety concerns that Chevy/GM has not properly handled.

NHTSA ID

11728846

Incident

Apr 2, 2026

Driving at 75mph upgrade westbound out of Denver, Co. Engine failed, shut down at speed, had to emergency move to right shoulder through 3 lanes of traffic. The last 10 mph it locked wheels to a screeching halt. Towed to Foundation Chevrolet. Confirmed engine failed, needs replacement. Every service done on regular basis by same dealer. Had "recall" band aid performed a couple months ago, where they changed oil vicosity and did inspection.

NHTSA ID

11728830

Incident

Mar 31, 2026

My 2022 Chevrolet Tahoe has a recurring pattern of excessive oil consumption, smoke from the exhaust, repeated check engine light events, P0420 catalyst-efficiency faults, and repeated catalytic-converter-related repairs. At approximately 75,000 miles, the vehicle shut down on the freeway. At approximately 121,000 miles, the first catalytic converter failed. Chevrolet of Wesley Chapel documented P0420 and catalyst failure in November 2025, and GM service history reflects catalytic-converter replacements at 131,468 miles and approximately 141,082 miles. The vehicle also underwent major injector-related repair in early 2026. At 141,620 miles, Chevrolet of Wesley Chapel started an oil consumption test and stated in writing that oil consumption can lead to repeat failed converters and false oxygen sensor readings. Despite substantial repairs, the problem pattern continued. I am reporting this as a possible safety-related defect affecting engine operation, emissions-system failure, and drivability, and I am asking NHTSA to review whether this indicates a broader safety-related defect.

NHTSA ID

11725697

Incident

Mar 29, 2024

Unknown.

NHTSA ID

11710764

Incident

Dec 18, 2025

Vehicle continues to experience flashing air bag light and service self-restraint system warning. Brought in twice in 2025 for self-restraint system but dealer refuses to cover under warranty. On December 18, 2025, experienced complete power and electrical failure while in transit on a turning lane. The vehicle was unable to start, or open any windows, and the transmission would not shift back into park or neutral while obstructing traffic near an active railroad. Vehicle battery was replaced and was able to safely put vehicle into gear. Vehicle battery replacement allowed for normal driving; however, from that date on the transmission started shifting harder and jerkier. On December 31, 2025, vehicle was being driven on the freeway to then experience difficult shifting and reduced power. Subsequently, the drive indicator began flashing red and a service transmission indication appeared. There has been at least three instances, since vehicle purchased, where sudden loss of power and control of the vehicle in motion has occured.

NHTSA ID

11708007

Incident

Dec 31, 2025

Car went to limp mode, hard shifting very suddenly. Transmission system failed. No reverse. Computer codes p0700 p0777 p18A1 inspected at Chevy service center and needs valve body replacement. No warnings, lights, alerts, hard shifts previously.

NHTSA ID

11707313

Incident

Dec 17, 2025

driving on highway at 65MPH truck suddenly locks up (brakes or shifts into park) and does not release.vehicle swerves while coming to stop. Occurred 2 times sent to dealership and could not duplicate issue. 3 weeks later same thing happened Both incidences happened while having cruise control on.

NHTSA ID

11702410

Incident

Oct 15, 2024

Transmission valve body failure after factory warranty expired.

NHTSA ID

11684848

Incident

Aug 18, 2025

This is the 5.3 and not the 6.2. The vehicle turned off and switched to neutral while driving, that almost caused an accident. Dash displayed engine/transmission failure. Vehicle became a boat anchor and was towed to dealership. Possible transmission valve body issue.

NHTSA ID

11678052

Incident

Jul 31, 2025

2022 Tahoe RST with 5.3 10 Speed. Bought new in Sept of 2021. The 2022 we have had problems with shuttering in the drivetrain from very low miles. We have brought it into the dealership atleast 3-4 times before for this issue. This was all while it was still under its 60k drivetrain warranty. Dealership always told us that since there was no check engine light or codes that they can’t fix what is not broke or broke yet. We needed to wait for it to break or light then bring it in. We also received a letter in the mail for the trans recall (program)last year which was preformed. That day after, my wife started to notice it shuttering more than usual and more often. I call the dealership that performed the recall which they said to bring it in. After looking it over. I get a call saying that I should get the transfer case fluid, front and rear diff fluid changed. It might be the transfer case slipping. Advisor told me that since it was about due for this service. Fast forward to May 9th of this year. My wife was at church. She parked it which it ran fine. Came out about 30-40 mins later put it into drive and wheels where locked up. She called me panicking that something was wrong. Go to her aid which I had to have it towed to the same dealership that serviced it before. Even check it in with the same advisor that helped us before after the recall issue. I should now mention our 22 Tahoe has 68,700 miles. Dealership called us a few days later saying it was the valve body. Especially since we had have problems before with the drivetrain and documented. The vehicle is still inoperable. We are waiting for a valve body with no ETA.

NHTSA ID

11674262

Incident

May 9, 2025

several times we will be driving down the road and it feels like the vehicle is trying to shift into park and the tires lock up. Then it goes into a mode where acceleration is limited.

NHTSA ID

11669907

Incident

Jun 2, 2025

Faulty valve body Safety was put at risk, I was traveling on a 4 lane road at 45 mph when my vehicle experienced a significant jump in RPM with immediate loss of propulsion. I immediately drove to the dealership as the incident was frightening. The vehicle was also not able to go into reverse. This valve body failure issue has been confirmed by the GM Chevy Dealership, and GM corporate executive services. My vehicle has been undriveable and at the dealership since 3/4/25. This is a known issue with GM, parts are not available and are back ordered with no ETA on when they will be available. Even with a replaced valve body it is likely the vehicle will have future transmission issues &/ additional valve body failure. Please strongly consider a recall related to this known issue and safety concern.

NHTSA ID

11662116

Incident

Mar 3, 2025

The contact owns a 2022 Chevrolet Tahoe. The contact stated while driving at an undisclosed speed, the contact noticed a loud knocking sound coming from the vehicle and the vehicle jerked abnormally. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was no warning light illuminated. Additionally, the contact stated that the gear shifter failed to operate as intended and the vehicle failed to shift into reverse. The vehicle was driven to the residence. The vehicle was scheduled to be towed to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 85,000.

NHTSA ID

11659440

Incident

May 6, 2025

Mileage

85,000 mi

Dear. My name is [XXX] . Phone # [XXX] . My email: [XXX] On [XXX] my Tahoe suddenly shut off while I was driving over 70 mph on the highway. It was towed to the South pointe chevrolet dealership in tulsa. I was told a fuse had failed and paid nearly $400. On April 17, 2025 they returned my Tahoe and said it fixed. [XXX] When i tried to start engine, then it acted like something almost can't start, then i text dealership and told them situation. On [XXX], the same failure occurred again — again at highway speed — nearly causing an accident with an 18-wheeler. The Tahoe was towed a second time. 2 times i was able to re-start engine drive until i stop then can't start it agian. Both time i smell something burned when i tried to re-start it. On April 21, I texted the service manager about GM TSB N252494000, which describes propulsion loss involving the L87 engine — the same engine in my Tahoe. Two days later, I was sent an invoice for $865.30 for a starter replacement. I was told the repair would not be covered under warranty — despite the vehicle still being under 60,000 miles at the time and the defect appearing to fall under a known GM issue. This is a recurring, life-threatening failure that GM and its dealer have not fixed. The vehicle is still under warranty, yet GM is refusing to cover the repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11658342

Incident

Apr 21, 2025

2022 Chevy Tahoe with 32,292 miles of in-town and highway driving, never any towing. Perfectly maintained on time. Suddenly started to not respond to acceleration, and jolting, then would not reverse. Transmission valve body has already gone out. GM acknowledged the problem. States there is a national shortage of this part. There is nothing they know of being done about. Park the vehicle and wait for a part to become available. No ETA, but 2,200 of this part have already been requested recently.

NHTSA ID

11652371

Incident

Feb 26, 2025

While driving down the highway, the vehicle suddenly experienced multiple issues. The headlights went out, the vehicle would not continue to accelerate, and all interior lights shut off. The vehicle then shifted into neutral and stalled. There were no warning signs or indicators before this happened. Our safety was at risk as we barely managed to pull the vehicle over to the shoulder, with no working emergency lights. The highway had no street lights, and we were constantly worried about being hit by other cars since our vehicle was nearly invisible without the emergency lights. The malfunction left us stranded more than two hours from home. We had to have the vehicle towed to a Chevrolet dealership for inspection, which was also over two hours away. Prior to the failure, there were no warning lamps, messages, or other symptoms—everything happened suddenly without any notice.

NHTSA ID

11647680

Incident

Mar 8, 2025

Continuous alert(3 months)- service transmission, unable to shift gears. Safety concerns due to possibility of transmission failure.

NHTSA ID

11645775

Incident

Dec 12, 2024

The contact owns a 2022 Chevrolet Tahoe. The contact stated while driving at approximately 35 MPH, the vehicle was losing motive power. The contact stated that the "Service Transmission" message was displayed. The contact stated that the transmission temperature gauge was showing that the transmission was almost 200 degrees. The contact was able to drive the vehicle to the residence. The contact made several attempts to reset the transmission by turning the vehicle off and on and then attempted to reset the Transmission Control Module by disconnecting the battery. The contact was able to drive the vehicle to a local dealer. The dealer diagnosed the vehicle and determined that the transmission valve body had failed and needed to be replaced. The contact was advised by the dealer that the parts needed to repair the vehicle were on a national backorder. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 38,000.

NHTSA ID

11640447

Incident

Dec 26, 2024

Mileage

38,000 mi