1995 Chrysler Cirrus

THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS ATTACHED HERETO.

THE MANUFACTURER IDENTIFED VEHICLE OWNER COMPLAINTS OF THE SUBJECT BALL JOINT FAILURES AS TABULATED ABOVE.IN ADDITION, A TOTAL OF 72 WARRANTY REPORTS WERE IDENTIFIED FOR REPLACEMENT OF BROKEN OR CRACKED BALL JOINT ASSEMBLIES IN THE SUBJECT VEHICLES.CHRYSLER ALSO REPORTED THAT 1996 AND 1997 MODELS ARE EQUIPPED WITH IDENTICAL BALL JOINT ASSEMBLIES AS THE SUBJECT 1995 MODEL YEAR VEHICLES.A PARTIAL RESPONSE TO NHTSA'S INFORMATION REQUEST INDICATED THAT THE MANUFACTURER'S ANALYSES AND EVALUATIONS OF THE CONDITION WERE CONTINUING.IN ORDER TO CONTINUE NHTSA'S COMPLETE ASSESSMENT OF THE NATURE AND SCOPE OF THIS MATTER, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

TL* THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY SHIFTED INTO NEUTRAL. THE VEHICLE THEN SHIFTED OUT OF NEUTRAL, BUT WOULD NOT ACCELERATE OUT OF FIRST GEAR. THE VEHICLE WAS TAKEN TO A MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10453215

Incident

Feb 1, 2012

Mileage

130,000 mi

OUR CAR WILL SHIFT PERFECTLY ONE DAY AND DON'T WANT TO SHIFT THE NEXT SECOND FOR NP REASON, WE HAVE REPLACED THE MODULATOR.. COOLANT TEMP SENSOR.. WE HAVE ALSO EVEN RECABLIORATED THE SHIFTING PATTERN AND STILL HAVE THIS PROBLEM.. IS THIS GOING TO KEEP HAPPENING OR IS THERE SOMETHING I CAN DO TO FIX IT. WE DID A DIAGNOSTIC ON IT AND THE TRANSMISSION WAS GOOD.. I DON'T KNOW WHAT ELSE TO DO.? *TR

NHTSA ID

10453166

Incident

Feb 8, 2012

Mileage

35 mi

TRANSMISSION WITHOUT WARNING EITHER SHIFTS DOWN INTO SECOND GEAR AND WILL NOT SHIFT UP OR WORSE THE TRANSMISSION GOES LIMP WHEN DRIVING AT ANY SPEED IN OTHER WORDS YOU END UP COASTING AND COULD POSSIBLY CAUSE A SERIOUS ACCIDENT, THE FIRST TIME THIS HAPPENED TO ME I WAS GOING 65 MPH ON THE FREEWAY. FORTUNATELY, I WAS ON THE RIGHT HAND SIDE OF THE ROAD SO I COULD COAST OFF AND COME TO A STOP. IF I HAD BEEN IN HEAVY TRAFFIC IN EITHER THE CENTER OR LEFT HAND LANE THERE WOULD BE NO WAY FOR ME TO AVOID OTHER CARS AND THIS WOULD HAVE RESULTED IN A SERIOUS ACCIDENT. I TOOK THE CAR TO THE CHRYSLER DEALER AND THEY SAID IT WAS A FAULTY SOLENOID PACK AND THEY REPLACED IT FOR $900+ DOLLARS. THE CAR RAN FOR A COUPLE OF WEEKS AND THE SHIFTING DOWN AND LIMP EPISODES BEGAN AGAIN. I NOW HAVE A CAR WITH 45000 MILES PARKED IN MY GARAGE AND AM AFRAID TO DRIVE IT. THERE ARE DOZENS OF BLOGS ON THE INTERNET DESCRIBING THE SAME PROBLEM AND I DO NOT SEE ANY RECALLS BUT THIS IS CERTAINLY A LIFE THREATENING HAZARD. UNFORTUNATELY THIS IS AN INTERMITTENT PROBLEM THAT HAPPENS WITH NO WARNING. *TR

NHTSA ID

10352499

Incident

Aug 15, 2009

Mileage

40,000 mi

I BOUGHT A 1995 CHRYSLER CIRRUS LXI AND FOR THE FIRST LITTLE WHILE IT WAS GREAT, THEN ALL OF A SUDDEN I WAS DRIVING DOWN THE ROAD AT 62 MPH AND THE CAR SHIFTED INTO NEUTRAL I SLOWED DOWN TO ABOUT 30MPH AND IT DROPPED INTO GEAR BUT IT WOULD NOT SHIFT FROM FIRST GEAR. NOW SOMETIMES IT WILL SHIFT FINE AND OTHER TIMES IT WILL NOT SHIFT AT ALL. AND MY A/C QUIT WORKING AND THE RPM GAUGE STOPPED WORKING AT AROUND THE SAME TIME AS THE SHIFTING ISSUES STARTED. *TR

NHTSA ID

10261432

Incident

Feb 24, 2009

Mileage

140,000 mi

TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. SEVERAL MONTHS AGO, WHILE DRIVING 20 MPH, THE DRIVER'S SIDE FRONT SUSPENSION BEGAN MAKING A CREAKING NOISE. THE NOISE DID NOT SOUND LIKE THE SPRINGS, BUT MORE LIKE PLASTIC RUBBING OVER A HEAVY LOAD. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT BOTH THE PASSENGER AND DRIVER'S SIDE FRONT SUSPENSION WERE OUT OF LUBRICANT. IN ADDITION, THE SUSPENSION JOINTS NEEDED TO BE REPLACED. AFTER RESEARCHING THE ISSUE, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 97V201000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT) FOR THE SAME FAILURE HIS VEHICLE WAS EXPERIENCING. THE MANUFACTURER STATED THAT THE RECALL DID APPLY TO HIS VEHICLE; THE MANUFACTURER WAS TAKING RESPONSIBILITY FOR THE REPAIRS. THE FAILURE MILEAGE WAS 75,500 AND CURRENT MILEAGE WAS 76,200. UPDATED 12-02-08 *BF UPDATED 12/02/08. *JB

NHTSA ID

10248559

Incident

Jun 1, 2008

Mileage

75,500 mi

TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. WHILE APPROACHING A STOP SIGN OR RED LIGHT, THE VEHICLE SHUTS OFF AND WILL NOT RESTART. THE VEHICLE IS ALSO RATTLING VERY LOUDLY. THE DEALER REPAIRED THE STARTER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 89,000 AND FAILURE MILEAGE WAS 86,000.

NHTSA ID

10216959

Incident

Oct 15, 2007

Mileage

86,000 mi

TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT ATTEMPTED TO START HER VEHICLE, BUT WAS UNSUCCESSFUL. THE ENTIRE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE STATED THAT THE MODULATOR NEEDED TO BE REPLACED. THE WORK WAS PERFORMED, BUT THE FAILURE RECURRED A MONTH LATER. THERE IS A ROD ON THE REAR DRIVER SIDE THAT IS SUPPOSED TO HOLD THE WHEEL IN PLACE, BUT IT HAS RUSTED. THE ROD FELL APART AND THE CONTACT HAD IT REPLACED. WHILE THE VEHICLE WAS PARKED, SHE NOTICED THAT THE BRAKELINE WAS LEAKING BRAKE FLUID ONTO THE GROUND. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND HAD IT REPAIRED. THE VIN, ENGINE SIZE, NUMBER OF CYLINDERS, POWERTRAIN, AND FAILURE MILEAGE WERE UNKNOWN. THE CURRENT MILEAGE WAS 63,742.

NHTSA ID

10215361

Incident

Nov 18, 2005

I HAD A FRONT END CRASH AT 25 TO 30 MPH, AND NONE OF THE AIR BAGS DEPLOYED JEOPARDIZING MY LIFE. THIS MAY BE ISOLATED OR MY BE ALL THE CARS LEFT ON THE ROAD. *TR

NHTSA ID

10212007

Incident

Dec 15, 2007

Mileage

122,876 mi

Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.

Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.

05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.

CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.

Warranty Operations Newsletter Updates from Warranty Operations

Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 55372082AA. Replacement part number is 55372082AF w hich is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.