Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2005 Dodge Durango submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 751 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 751, in the owner's own words
My car is having identical symptoms to a recall for it, but dodge is saying my vehicle is "Not affected", despite having identical symptoms from an identical cause. The check valve on my fuel tank has failed, and it overflows when I fill it with gas
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the contact became aware that gasoline was spilling out of the fuel filler neck. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline); however, the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.
The contact owns a 2005 Dodge Durango. The contact stated while refueling the vehicle, the fuel started leaking from the filler neck. The contact waited for a while to refuel the vehicle. Additionally, the contact stated that a message was displayed on the instrument cluster "Gas Cap". The contact stated that she checked the gas cap and was properly placed then replaced the gas cap however, the message recurred. The dealer was notified of the failure and confirmed that the VIN was not included in a recall. The vehicle was not repaired. The contact refenced the NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline. The manufacture was not notified of the failure. The failure mileage was approximately 126,337.
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the fuel tank spilled gasoline to the vehicle. The fuel also leaked onto the driveway while the vehicle was parked. Additionally, the vehicle lost motive power while driving with the air bag warning light illuminated. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the vehicle had previously been repaired under NHTSA Campaign Numbers: 09V003000 (Fuel System, Gasoline), 15V313000 (Air Bags), and 16V352000 (Air Bags). The failure mileage was approximately 152,000.
The contact owns a 2005 Dodge Durango. The contact stated that fuel spilled out of the filler neck at the end of refueling. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was previously repaired under NHTSA Campaign Number: 05V034000 (Fuel System, Gasoline). However, the contact related the failure to NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline) but the VIN was not included in the recall. The failure mileage was approximately 120,000.
I have own my Durango for about 4 years and I recently had the air bag recall repaired that it had. My vehicle also had a previous recall for the fuel tank filler tube inlet check valve. It causes gas to splash out at a large amount which splashes out at you, all over the truck and the ground. It does this every time I fill my tank. I looked it up online and mine was never replaced but “checked” before I owned it. I don’t know why it was replaced because my vehicles is obviously affected by this recall and the dealer will not fix it because it was previously checked. I’m scared of the danger this issues has. I’m a single dad and this is my only vehicle. It happens regularly every time I refuel.
The contact owns a 2005 Dodge Durango. The contact stated that the vehicle was previously repaired under NHTSA Campaign Numbers: 16V352000 (Air Bags) and 05V034000 (Fuel System, Gasoline) however, the failure occurred after the recall repairs were performed. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The contact stated that the dashboard was damaged, and the passenger's side air bag compartment was opened. Additionally, fuel was spilling out of the filler tube while refueling the vehicle. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 215,000.
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
VIN: [XXX], 2005 Dodge Durang0 SLT, 4.7L. Vehicle purchased party on 07/20/2022. Register and insured 07/21/2022. SAFETY FCA Recall #: H45. NHTSA Recall #: 09v-003; The fuel tank inlet check valve sticks in the open position, causing fuel to spill out of the filler tube when the vehicle is being refueled. Fuel in the presence of an ignition source can result in a fire. Repair Description: The fuel inlet check valve must be tested for proper operation. A vehicle with a sticking check valve must have the fuel tank replaced. On 08/08/2022 during the second attempt of refueling as the current owner. There was fuel spillback during refueling. On 08/08/2022, I contacted Daimler Chrysler at [XXX], case number [XXX] explaining the incident. However, customer service ([XXX]) stated that the safety recall had been completed but in fact per recall status according to FCA, only an INSPECTION was performed. This is not only a serious safety concern to myself and my family but also to the community at large. Especially during refueling, with the possibility of an explosion and fire caused by fuel spilling and igniting in the process. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
When filling up my gas tank occasionally fuel will spit out of my gas tank and all over my car and ground
Was driving 2005 dodge Durango when it stalled and stopped running at a bottom of a hill. Would not start . Replaced idiole control sensor, starter, battery, crank shaft sensor and relays. Started ran for 30 minutes again just died in the middle of the road. Will not start. If someone would of come over the hills could of hit us with sever injury or possibly death. Still wont run crank over wont run.
When filling up vehicle, fuel pump spits fuel back out when full instead of shutting off. Or pump will not fill at full speed and pump continually shuts off. Then it cannot tell when full, spitting fuel back out the filler
After filling gas tank to completion and hearing the auto stop on the fuel pump engage I saw about a liter of fuel spill out from the gas tank. Fuel was all over the vehicle and ground.
I cant put more then 10 dollars in my tank because the nosle keeps clicking and gas pours out all over me and the ground. There was a recall for this, but it is no longer happening. I just bought this car used and now my mechanic cant even find a gas tank to replace it. My legs have felt like they where on fire and became red from the gas pouring out on me, my husband has had to hose me down outside in my backyard from having fuel all over my legs. This is very dangerous, nerve racking and a total safety hazard.
Engine is intermittent stalling when driving or taking a sharp corner at Low speed. The vehicle engine has just stalled when driving at different speeds. No check engine lite on at all the engine just stalls and I can restart the engine almost all the time right away the repair facility has no idea what is going on. Need to get this figured out before an accident happens
WHEN YOU FILL THE FUEL TANK FULL IT GUSHES OUT ALL OVER THE PLACE. HOW HASN'T THIS MATTER BEEN TAKEN CARE OF. IT'S EXTREMELY DANGEROUS AND UNSAFE. DODGE MUST ENJOY SEEING UNSAFE [XXX]. IT HAPPENS ALL THE TIME WHEN YOU FILL UP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
FUEL SHOOTS OUT OF FILLER TUBE WHILE FUELING THE VEHICLE
THE GASOLINE WILL OVERFLOW FROM THE FUEL FILLER PIPE AND CAP AND NOT SHUT OFF ON ITS OWN. THIS HAPPENS WHEN FILLING THE VEHICLE STATIONARY, WITH THE CAR OFF AT GAS STATIONS. IT HAPPENS VERY CONSISTENTLY, REGARDLESS OF THE FILL RATE OF THE GAS, THE STYLE OF GASOLINE DISPENSER, OR LOCATION OF THE GAS STATION. THE GASOLINE WILL CONTINUE TO SPILL OUT FROM THE FUEL NECK UNTIL SOMEONE MANUALLY INTERVENES AND TURNS OFF THE NOZZLE. THERE HAVE BEEN 2 RECALLS ISSUED FOR THIS ISSUE WITH 2005 DODGE DURANGO'S (RECALL ID# 40367, AND 27198) HOWEVER THE RECALL IS LIMITED TO CERTAIN VINS, WHICH DOES NOT INCLUDE MINE. TO BE CLEAR, EVEN THOUGH MY VIN IS NOT INCLUDED IN THE RECALLS, I AM EXPERIENCING THE EXACT SAME ISSUE AS DESCRIBED IN BOTH RECALLS. THE BODY ON THAT SIDE OF THE VEHICLE (DIRECTLY UNDER THE FILLER CAP) HAS BEEN COMPLETELY EATEN AWAY FROM THE EPISODES OF GASOLINE POURING OUT OVER IT.
WHEN FILLING GAS TANK, GAS SHOOTS BACK OUT FILLER TUBE. THE GASOLINE WILL SPLASH BACK AT YOU WHEN TANK IS NOT EVEN FULL. VERY DANGEROUS AND CHECKED FOR RECALL BUT MY VEHICLE NOT COVERED BUT MANY OWNERS REPORT SAME ISSUE.
TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT AFTER DRIVING OVER A BUMP IN THE ROADWAY, THE GEAR SHIFTER BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT RECENTLY, AFTER DEPRESSING THE BRAKE PEDAL, THE VEHICLE STALLED WITHOUT WARNING. ADDITIONALLY, WHILE REFUELING THE VEHICLE, FUEL OVERFLOWED DUE TO A DEFECTIVE FUEL FILLER NECK. THE CONTACT LINKED THE FAILURES TO NHTSA CAMPAIGN NUMBER: 05V460000 (POWER TRAIN) AND 05V034000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
GAS FILLER LINE EJECTS FUEL WHILE FILLING CAR. *TR
FUEL SPLASHES OUT OF THE FILLER NECK WHEN FUEL TANK IS FILLED.
WHEN FILLING THE GAS TANK, AFTER THE GAS PUMP SHUTS OFF (INDICATING TANK FULL), GAS SPEWS OUT OF THE TANK AND INTO THE VEHICLE, GROUND, AND PERSON PUMPING GAS IF THEY DON'T JUMP OUT OF THE WAY QUICKLY.
STATIONARY: WHEN REFUELING, GREAT AMOUNT OF FUEL LEAKS OUT WITH HIGH PRESSURE, SOAKED ME IN GASOLINE CAUSING BURNS AND SKIN IRRITATION ON HALF OF MY BODY, ALSO DAMAGED THE FUEL PANEL SIDE OF THE VEHICLE. CHRYSLER REFUSES TO RECOGNIZE AN EXISTENT RECALL ON VEHICLES FROM THE SAME YEAR THAT EVIDENTLY HAVE SAME DEFECTS. MY VEHICLE NOT LISTED ON THE RECALL BUT DEFECT WAS FOUND BY 2 DIFFERENT DODGE MECHANICS SO WAS SUPPOSEDLY REPAIRED. UNFORTUNATELY, IN MY FIRST DRIVE IT ALMOST KILLED ME IN A ZONE WHERE VEHICLES GO AT 70 MPH. IN THE HIGHWAY SOMETHING SUDDENLY SNAPPED LOUDLY, FUEL SPLATTER LEAKING OUT WITH PRESSURE, SMOKE COMING OUT, VEHICLE STARTED TO SHAKE AGGRESSIVELY OUT OF CONTROL, THEN VEHICLE SHUTS OFF WHILE RUNNING, TWICE. THE VEHICLE REMAIN WITH AN ASPHYXIATING FUEL ODOR, FIRE DEPARTMENT AND POLICE WERE AT SCENE, CHRYSLER KEPT ME HOURS IN THE PHONE CONSTANTLY WASHING THEIR HANDS FROM 2PM UNTIL 8PM, CALL AFTER CALL AND NEITHER CHRYSLER OR THE DODGE DEALERSHIP PROVIDED ANY SOLUTION NOR HELP, WE ALMOST DIED TODAY, THIS DEFECT ALMOST KILLED US.
WHEN I GET GAS IT DOESN'T MATTER IF I HAVE A LITTLE GAS OR HALF A TANK MY GAS AS I'M PUMPING ALWAYS COMES OUT AND BACKFIRES AT ME ....IT JUST STARTS SPITTING OUT AT ME FOR NO REASON... EVEN WHEN I'M EMPTY AND I START PUMPING GAS IT HAPPENS AFTER ABOUT 10 SECONDS OF PUMPING GAS IT JUST DECIDES TO COME BACK AT ME.. SO I'M WASTING GAS ALL THE TIME IT HAPPENS ABOUT EVERY FOURTH TIME I GET GAS....
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .