2002 Dodge Neon

THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.

THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.

I WAS DRIVING DOWN THE ROAD AND HEARD A WHIRRING NOISE FROM UNDER THE HOOD AND I LOST THE ABILITY TO GO INTO DRIVE AND REVERSE COME TO FIND OUT IT WAS A CLOGGED TRANS FILTER SO I REPLACED IT AND THE CAR RAN GREAT FOR ABOUT 2 WEEKS AND NOW I HAVE TORQUE CONVERTER OUT OF RANGE CODES POPPING UP THE CAR HAS 88000 MILES ON IT AND I WOULD LIKE TO THINK TRANSMISSIONS ARE SUPPOSED TO BE ABLE TO LAST AT LEAST 150 TO 180 THOUSAND MILES BEFORE GOING BAD THIS IS NOT A CHEAP NOR EASY FIX PLEASE HELP

NHTSA ID

11164248

Incident

Dec 31, 2018

TL* THE CONTACT OWNS A 2002 DODGE NEON. WHEN THE CONTACT OPENED THE VEHICLE DOOR, A MOUSE WAS SEEN RUNNING FROM THE FLOOR OF THE PASSENGER SIDE OF THE VEHICLE AND UNDER THE SEAT. THE CONTACT STATED THAT THE RODENT ENTERED THE VEHICLE THROUGH THE AIR VENTS IN THE REAR OF THE VEHICLE TO CHEW ON THE WIRES INSIDE THE ENGINE COMPARTMENT. THE CONTACT HAD TO PLACE MOUSE TRAPS INSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 29,000.

NHTSA ID

11012272

Incident

Jul 24, 2017

Mileage

29,000 mi

I BOUGHT THIS CAR WITH 49000 MILES ON IT. I WAS DRIVING EVERYTHING SEEMED FINE THEN I SLOWED DOWN FOR A STOP SIGN TO BETWEEN 3 AND 7 MPH AND THE WHOLE THING JUST LOCKED UP. I TRIED EVERY GEAR BUT NOTHING WOULD UNLOCK THE TRANNY.. IT'S STILL LOCKED UP NOW I HAD TO GET IT TOWED.. LUCKILY I WAS ON A LITTLE TWO LANE ROAD WITH NOT MUCH TRAFFIC SO THERE WASN'T TO MANY MAD PEOPLE I FEEL DODGE SHOULD TAKE CARE OF THERE PROBLEMS AND PROBLEM CARS.. IM NOT ASKING FOR MUCH JUST FOR MY CAR TO MAKE IT OVER 50000 MILES.

NHTSA ID

11010048

Incident

May 3, 2016

TL* THE CONTACT OWNS A 2002 DODGE NEON. WHILE DRIVING VARIOUS SPEEDS, A KNOCKING SOUND WAS COMING FROM THE ENGINE AND THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE PISTON DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

NHTSA ID

10994128

Incident

May 17, 2017

Mileage

200,000 mi

TL* THE CONTACT OWNS A 2002 DODGE NEON. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF THE PRECEDING VEHICLE. THE AIR BAGS DID NOT DEPLOY WITHOUT WARNING. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS CONTACTED, BUT THE CALL WAS FORWARDED TO VOICEMAIL. THE CONTACT LEFT A VOICEMAIL MESSAGE. THE FAILURE MILEAGE WAS 106,696.

NHTSA ID

10865246

Incident

May 16, 2016

Mileage

106,696 mi

2002 DODGE, WAS IN A FRONT END COLLISION AND THE FRONT AIRBAGS DIDN'T DEPLOY. THE HOOD WAS BENT. ACCIDENT HAPPEN ON THE HIGHWAY

NHTSA ID

10811629

Incident

Dec 21, 2015

I DRIVING OFF THE INTERSTATE WEN CAR SHUT OFF IDLED TRIED TO CRANK IT UP BUT IT ONLY MADE WHINING NOISE AND WON'T START I ALSO NOTICE MY CAR WAS SMOKING SO I LET THE CAR COOL OFF BEFORE I PUT WATER... THE NEXT DAY I WENT AND A NEW TIMING BELT PUT ON AND A CRANK SHAFT SENSOR AND IT STILL WON'T CRANK

NHTSA ID

10787551

Incident

Oct 28, 2015

TL* THE CONTACT OWNS A 2002 DODGE NEON. WHILE SERVICING THE VEHICLE, THE CONTACT DISCOVERED THAT THE SUBFRAME WAS RUSTED AND PARTIALLY FRACTURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.

NHTSA ID

10778467

Incident

Sep 25, 2015

Mileage

116,000 mi

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Disinfectant Solution Recommended for COVID-19

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.