2003 Dodge Ram Van

THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.

IN JULY OF 2015, THE BRACKET THAT HOLDS THE STEERING ARM TO THE FRAME, ON THE PASSENGER SIDE, COMPLETELY DISCONNECTED AS I WAS MAKING A TURN. THIS I HAD REPAIRED (WELDED) SHORTLY AFTERWARD. THE FRAME WAS DISINTEGRATING FROM UNDERNEATH ME. ON 09/02/2016 THE FRAME TOTALLY SEPARATED WHERE THE STEERING CONNECTS ON THE DRIVERS SIDE, MAKING IT IMPOSSIBLE TO STEER. I FIND THE METAL THAT WAS USED FOR THE FRAME THIN, CHEAP, UNTREATED, AND UNSAFE! 12 YEARS IS MUCH TO SHORT OF TIME FOR A VEHICLE TO BE RETIRED BY A RUSTED FRAME! CHRYSLER HAS A DOCUMENTED COMPLAINT FROM ME ABOUT THIS AND OF COURSE THEY'RE DOING NOTHING ABOUT IT.

NHTSA ID

10918694

Incident

Sep 2, 2016

Mileage

190,000 mi

DRIVING DOWN THE ROAD AT 65 MPH AND LOST TOTAL CONTROL OF VEHICLE STEERING FOUND OUT IT WAS DUE TO A RUSTED FRAMED. TOTALLY UNSAFE VAN. I WAS GLAD IT WAS NOT VERY BUSY ON THE INTERSTATE OR I COULD HAVE BEEN KILLED. I AM VERY DISAPPOINTED A MANUFACTURE CAN HAVE SO MANY COMPLAINTS ONLINE AND NOTHING HAS BEEN DONE. IT IS TOTAL FRAME LOST TO RUST.

NHTSA ID

10780681

Incident

Oct 5, 2015

Mileage

148,505 mi

FOR 2 DAYS PRIOR TO INCIDENT , NOTICED STEERING WHEEL KEPT CHANGING ORIENTATION WHILE DRIVING IN A STRAIGHT LINE. A LOT OF GROANING AND CREAKING NOISE FROM RIGHT FRONT SUSPENSION IN RIGHT TURNS AS WELL AS VIBRATION AT HIGHWAY SPEED. PARKED VEHICLE AND INSPECTED UNDERSIDE TO FIND THAT IDLER ARM BRACKET WAS TEARING AWAY FROM FRAME RAIL DUE TO ROT. AFTER PARKING VEHICLE , I MOVED IT AROUND IN THE DRIVEWAY NO MORE THAN 3 TIMES BEFORE IDLER ARM BRACKET COMPLETELY SEPARATED FROM THE FRAME RAIL WITH A VERY LOUD POP.. VAN NOW HAS NO STEERING AND IS JUNK SITTING IN MY DRIVEWAY. INSPECTION OF FRONT FRAME RAIL AREA REVEALS HEAVY ROT ON BOTH FRONT FRAME RAILS AND STEERING GEAR MOUNT AS WELL. THE REST OF THE BODY IS TYPICAL FOR 10 YRS OLD IN UPSTATE NY. I HAVE PREVIOUSLY OWNED VEHICLES 20+ YRS OLD WITH BODY ROT , BUT HAVE NEVER HAD ANY FRAME ISSUES ASSOCIATED WITH ROT. AFTER MUCH RESEARCH , THIS APPEARS TO BE QUITE COMMON ON FULL SIZE DODGE VANS. WILL BE FILING A COMPLAINT WITH CHRYSLER CORP. , BUT DON'T EXPECT MUCH TO COME OF IT. ABSOLUTELY AMAZED THAT PEOPLE HAVE NOT DIED AS A RESULT OF THIS DEFECT. CONSIDERING THE NUMBER OF THESE VANS STILL ON THE ROAD , I WOULD CONSIDER THIS A GROWING CONCERN FOR THOSE THAT OWN AND DRIVE THEM AS WELL AS OTHER PEOPLE ON THE ROAD WITH THEM. *TR

NHTSA ID

10557231

Incident

Nov 20, 2013

Mileage

120,993 mi

TL* THE CONTACT OWNS A 2003 DODGE RAM VAN. THE CONTACT STATED THAT WHILE CONTACT WAS SITTING IN THE VEHICLE WITH THE ENGINE RUNNING, SMOKE WAS EMITTED FROM THE VEHICLE. THE DASHBOARD THEN CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXIT VEHICLE WITHOUT INJURY. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS PRESENT AND A FIRE REPORT WAS FILED. THE FIRE DEPARTMENT STATED THAT THE FIRE BEGAN IN THE AIR CONDITIONING SWITCH. THE FAILURE WAS NOT REPORTED TO THE MANUFACTURER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 30,000. UPDATED 8/19/13 *CN

NHTSA ID

10515477

Incident

Aug 30, 2010

Mileage

30,000 mi

VAN SHUTS DOWN ANY WHERE ANY TIME ANY SPEED AND READS NO BUS THIS HAS BEEN HAPPEN FOR TO LONG AND THEY DON'T EVEN OFFER A SOLUTION.I BOUGHT A SCANNER FOR A 100.00 DOLLARS IT WAS A WASTE OFF MONEY CAN'T READ CODES WITH THE NO BUS ANY WAY IF IT'S NOT THE PCM THEN WHY HAVE CODES FOR ALL THE OTHER SENSORS IF IT TURNS OFF ANYWAY. *TR

NHTSA ID

10367303

Incident

Nov 10, 2010

Mileage

143,508 mi

AFTER PURCHASING A PRE-OWNED DODGE RAM CONVERSION VAN, I DISCOVERED THAT THE LATCH SYSTEM IS INCOMPATIBLE WITH COMMERCIALLY AVAILABLE CHILD CAR SEATS THAT I PURCHASED FOR MY CHILD. THE SIDE ATTACHMENTS WORK FINE, BUT THE SEAT BACK EXTENDS TOO FAR UP TO ALLOW THE TIP LATCH HANESS TO REACH THE ATTACHMENT POINT LOCATED UNDER THE SEAT ITSELF.

NHTSA ID

10322497

Incident

Jun 15, 2009

TL*THE CONTACT OWNS A 2003 DODGE RAM VAN. HE CRASHED INTO A TELEPHONE BOOTH WHILE DRIVING 25 MPH. THE VEHICLE WAS COMPLETELY DESTROYED AND NONE OF THE AIR BAGS DEPLOYED. THE MANUFACTURER WAS NOTIFIED; HOWEVER, THEY PROVIDED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 58,563.

NHTSA ID

10285916

Incident

Aug 6, 2009

Mileage

58,563 mi

COLD WEATHER OUTSIDE. WINDOWS FOG UP AND GET ICE ON THEM. SIDE WINDOWS CAN NOT SEE OUT OF AND FRONT WINDOW GETS OVAL ON IT. MUST USE ICE SCRAPER TO SCRAPE ICE AWAY TO SEE. TOOK TO DEALER, FIRST TIME FIXED FOR ABOUT A YEAR WITH REPLACING A PART IN THE DEFROSTING SYSTEM, NEXT TIME DEALER COULD NOT FIND A PROBLEM. THIS COULD BECOME A DANGEROUS SITUATION AS YOU CANNOT SEE OUT THE WINDOWS AT TIMES AND I HAVE HAD TO PULL OVER. GETS WORSE AT HIGHER SPEEDS. *TR

NHTSA ID

10282950

Incident

Nov 25, 2008

Mileage

30,000 mi

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Disinfectant Solution Recommended for COVID-19

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.