2003 Ford F-450 Sd

IN A DECEMBER 3, 2007 LETTER, FORD ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO REPLACE THE CAM POSITION SENSOR (CPS) IN APPROXIMATELY 1.2 MILLION SUBJECT VEHICLES TO ADDRESS REPORTS OF ENGINE STALLING.A NEW DESIGN CPS WITH IMPROVED PERFORMANCE AND DURABILITY WILL BE INSTALLED AS A REMEDY.OWNER NOTIFICATIONS WILL BEGIN IN DECEMBER 2007. THE SUBJECT VEHICLES ARE DURABLE, FULL-SIZED, MEDIUM DUTY TRUCKS COMMONLY USED FOR COMMERCIAL PURPOSES, RESCUE/EMERGENCY RESPONSE, AND COMMERCIAL OR RECREATIONAL TOWING.CPS FAILURE IS COMPARABLE TO UNEXPECTEDLY TURNING THE KEY OFF SINCE THE SIGNAL IT PRODUCES IS VITAL TO THE ELECTRONIC ENGINE CONTROL SYSTEM.CPS SIGNAL LOSS TERMINATES FUEL INJECTION RESULTING IN AN ENGINE STALL.ONCE STALLED, THE ENGINE MAY RESTART RIGHT AWAY, OR MAY RESTART AFTER A DELAY (TYPICALLY 5 TO 10 MINUTES), OR MAY NOT RESTART AT ALL.IN ADDITION TO EXPOSING THE DRIVER AND OTHER MOTORISTS TO CRASH RISK DUE TO LOSS OF MOTIVE POWER OR VEHICLE DISABLEMENT, ENGINE STALLING ALSO EFFECTS THE POWER ASSISTED STEERING AND BRAKING. THROUGH CONSUMER INTERVIEWS, ODI DETERMINED THAT CPS FAILURES OCCURRED WITHOUT ANY FORM OF WARNING, AT ANY VEHICLE SPEED (50% AT HIGHWAY SPEEDS), AND UNDER ANY DRIVING CONDITION, SUCH AS ACCELERATING.CONSUMERS REPORTED THAT ABOUT A THIRD OF THE VEHICLES FAILED TO RESTART, WITH ANOTHER THIRD REPORTING DELAYED RESTARTING.HALF THE VEHICLES THAT DID RESTART EXPERIENCED ANOTHER STALL ON THE SAME OR A SUBSEQUENT DRIVE CYCLE (BEFORE CPS REPLACEMENT) RE-EXPOSING THOSE CONSUMERS TO THE RISKS ASSOCIATED WITH A STALLING EVENT.IN THEIR VOQ REPORTS, HALF OF THE ODI COMPLAINANTS DESCRIBED DIFFICULTY CONTROLLING THE VEHICLE DUE TO LOSE OF POWER ASSIST SYSTEMS, ESPECIALLY THOSE WHO WERE TOWING AT THE TIME OF THE INCIDENT. THE ONE ALLEGED INJURY INCIDENT OCCURRED IN AN INTERSECTION WHEN A SUBJECT VEHICLE STALLED WHILE TURNING ACROSS ONCOMING LANES OF TRAFFIC.ALTHOUGH UNSUBSTANTIATED, THE COMPLAINANT ALLEGED AN INJURY TO A CHILD OCCUPANT DURING ODI'S INTERVIEW.THE OTHER CRASH ALLEGATIONS MOSTLY INVOLVED LOW SPEED, LOSS OF CONTROL INCIDENTS OFTEN CAUSED BY LACK OF POWER ASSIST; NO INJURIES ARE REPORTED IN THESE INCIDENTS, AND PROPERTY DAMAGE, IF ANY, WAS MINIMAL.CONSUMERS ALSO REPORTED OTHER INCIDENTS WITH SIGNIFICANT SAFETY RISKS, SUCH AS DISABLEMENT IN A LANE OR ON A SHOULDER OF A HIGH-SPEED ROADWAY OR INTERSTATE, OR EXTENDED DISABLEMENT IN REMOTE AREAS DURING SEVERE WEATHER CONDITIONS. THE POPULATION ABOVE IS FORD'S ESTIMATE OF THE 1.4 MILLION SUBJECT VEHICLES PRODUCED THAT ARE CURRENTLY REGISTERED.THE FORD COMPLAINT AND WARRANTY COUNTS NOTED ABOVE ARE CURRENT AS OF FORD'S LAST SUBMISSION DATED JUNE 21, 2007; THEY DO NOT INCLUDE F-450, F-550, OR ECONOLINE COUNTS AS THESE PRODUCTS WERE NOT FORMALLY WITHIN SCOPE OF THE INVESTIGATION WHEN FAILURE INFORMATION WAS REQUESTED.WARRANTY DATA ANALYSIS INDICATES THAT ABOUT HALF THE CLAIMS INVOLVED A STALL WHILE DRIVING EVENT ( FORD'S ASSESSMENT) AND THAT POOR CPS DURABILITY WAS A LONGSTANDING CONCERN.FORD REPORTED THAT THE NEW CPS DESIGN SHOULD MEET OR EXCEED THEIR 10 YEAR, 150K MILE LIFE EXPECTANCY DESIGN REQUIREMENT.

IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.

FAILURE COUNTS FROM ODI?S ANALYSIS ARE STATED ABOVE; SEE THE ADDITIONAL PROBLEM EXPERIENCE DISCUSSION IN THE SUMMARY REPORT.FORD DATA CONTAINED DUPLICATIVE REPORTS FOR 4 ODI COMPLAINTS AND 1 CRASH.THREE CRASHES WERE ALLEGEDLY DUE TO INTERMITTENT OPERATION OF THE ELECTRONIC THROTTLE CONTROL (ETC) PEDAL, ONE CRASH OCCURRED WHEN AN ETC DISABLED VEHICLE WAS STRUCK BY ANOTHER MOTORIST, ONE REPORT CONTAINED NO DETAIL.THE INJURIES WERE MINOR.AN ISSUE INVOLVING FIXED ETC PEDALS WAS INVESTIGATED ALSO, HOWEVER FAILURE REPORTS AND POPULATIONS ARE NOT SHOWN ABOVE; SEE SUMMARY REPORT FOR DETAIL.ALTHOUGH FORD HAS USED ETC BASED THROTTLE CONTROL SYSTEMS FOR MANY YEARS, THE PAP FEATURE WAS NEW FOR MY 2002.THE SUBJECT ETC SENSOR PRODUCES TWO OUTPUT SIGNALS WHICH THE ENGINE MANAGEMENT SYSTEM (EMS) UTILIZES TO:1) DETERMINE FUELING REQUIREMENTS; AND 2) PERFORM SENSOR DIAGNOSTICS.ONE SIGNAL IS LINEARLY PROPORTIONAL TO THROTTLE PEDAL POSITION; THE SECOND IS A DIGITAL SIGNAL.BY DESIGN, THE DETECTION OF A SENSOR FAULT RESULTS IN THE ENGINE RETURNING TO (OR REMAINING AT) THE IDLE STATE.FORD IDENTIFIED A DEFECT IN THE PAP ETC SENSOR WHICH PREMATURELY AFFECTED AN OUTPUT SIGNAL; THE MIGRATION OF INTERNAL SENSOR LUBRICANT CAUSED A LOSS OF PROPORTIONAL SIGNAL.THE FAILURE MECHANISM IS PROGRESSIVE AND AS THE SENSOR DETERIORATES, THE EMS WILL DETECT A FAULT, STORE A FAULT CODE, ILLUMINATE A WARNING LAMP, AND THE ENGINE MAY REMAIN AT/RETURN TO IDLE.IN THE EARLY STAGES, NORMAL OPERATION CAN BE REGAINED BY PEDAL RE-APPLICATION.THE FAILURE PROGRESSES UNTIL THE ENGINE REMAINS AT IDLE.THE ENGINE DOES NOT STALL, POWER ASSISTED STEERING AND BRAKING SYSTEMS ARE UNAFFECTED. FORD CORRECTED THE ETC SENSOR DEFECT AND CONDUCTED FIELD SERVICE ACTION (FSA) 03B03 TO REPLACE ETC PEDALS, ADDRESSING 50% OF VEHICLES.AT AGENCY REQUEST TO IMPROVE COMPLETION RATE, FORD EXTENDED FSA 03B03 FOR 6 MONTHS.BASED ON ODI'S ANALYSIS OF AVAILABLE DATA, FORD'S ACTION HAS APPROPRIATELY RESOLVED THE ETC SENSOR PROPLEM IN THE SUBJECT VEHICLES.THE CLOSING OF THE INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST, AND SHOULD NOT BE CONSIDERED AS HAVING ANY PRECEDENTIAL VALUE OR EFFECT BINDING THE AGENCY IN FUTURE DEFECT INVESTIGATIONS. SEE THE ATTACHED SUMMARY REPORT FOR ADDITIONAL INFORMATION.

THE TRUCK BEGAN TO SHAKE AND LOSE POWER, EVENTUALLY NOT EVEN BEING ABLE TO STAY RUNNING. THE MECHANIC UPON REVIEW FOUND THE TANK LINER HAD DELAMINATED FROM INSIDE FUEL TANK AND HAD PLUGGED UP FUEL SENDER. BOTH NEEDED TO BE REPLACE AT A COST OF $2800, FORD DEALER STATED THERE WAS NOTHING THEY COULD DO. *TR

NHTSA ID

10510740

Incident

Apr 25, 2013

Mileage

119,311 mi

THE EGR, FICM, AND INJECTORS ON THIS VEHICLE HAVE CAUSED TRAFFIC HAZARDS. WE CAN NOT PULL OUT WITHOUT THE ENGINE SPITTING AND SPUTTERING. WE HAVE REPLACE ALL OF THE ABOVE, SOME MORE THAN ONCE. LAST TIME IN TO THE FORD DEALER THEY SUGGESTED THAT WE USE A THINNER OIL TO LUBRICATE THE INJECTORS BETTER. THIS ALSO DOESN'T WORK. WE HAVE READ MANY PEOPLE ON THE INTERNET THAT HAVE THE SAME PROBLEM WITH THEIR DIESEL ENGINES SO WE KNOW IT'S NOT JUST OURS. WE PAID $8,000.00 TO REPAIR AND NOTHING IS BETTER. FORD REFUSES TO ADMIT THERE IS A PROBLEM. PLEASE HELP THOSE OF US THAT ARE STUCK WITH THESE TRUCKS. THE DATES OF INCIDENTS HAVE BEEN ONGOING. *TR

NHTSA ID

10344315

Incident

Jun 12, 2010

Mileage

5,000 mi

TRUCK HAS NO POWER WHEN FIRST STARTING AND THE FRONT END SHIMMIES SOMETHING TERRIBLE. HARD TO CONTROL. *TR

NHTSA ID

10334371

Incident

Apr 26, 2003

Mileage

25,000 mi

THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTON OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. THE FUEL LINES BECOME FOULED, THE FUEL PUMPS BECOME CLOGGED AND REQUIRE REPLACEMENT. AS THE COATING CONTINUES TO DETERIORATE, THE ONLY RECOURSE IT TO CHANGE THE FUEL TANK, THE SENSORS, AND ENTIRE FUEL DELIVERY SYSTEM. WE HAVE HAD 3 FORD VEHICLES F SERIES EXPERIENCE THIS PROBLEM. THE AVERAGE REPAIR IS APPROXIMATELY $2180 PER VEHICLE. WE ARE REPORTING THIS AS IT SEEMS TO BE A DEFECT IN ALL THE FORD DIESEL FUEL SYSTEMS. AS THE FUEL SYSTEMS BECOME CLOGGED, THE VEHICLES LOSE POWER WITHOUT WARNING AND CREATE A SAFETY ISSUE AND DRIVING HAZARD NOT ONLY TO THE VEHICLE OPERATOR BUT OTHER MOTORISTS.

NHTSA ID

10322799

Incident

Oct 7, 2009

Mileage

64,042 mi

WHEN DRIVING DOWN A HILL WITH LOTS OF TURNS. THE TRUCK STALLED (SHUT OFF) ALL OF THE SUDDEN RIGHT BEFORE A TURN. LUCKILY WAS ABLE TO KEEP THE TRUCK ON THE ROAD AND RESTART THE TRUCK IN NEUTRAL. TOOK TRUCK STRAIGHT TO HANSEL FORD ASKED THEM TO TELL ME WHAT WAS WRONG WITH THE TRUCK. THEY CHECKED THE COMPUTER IN THE TRUCK, AND SAID THEY COULD NOT FIND ANYTHING AND DIDN'T KNOW WHAT TO TELL ME. *TR

NHTSA ID

10256119

Incident

Sep 1, 2006

Mileage

90,000 mi

THE LINING OF THE FUEL TANK HAS BEEN FLAKING OFF INTO MY FUEL LINES, WHICH IS RESTRICTING MY FUEL FILTERS. BECAUSE OF THE LACK OF FUEL, 2 FUEL INJECTORS WENT BAD AND HAD TO BE REPLACED. AND THE TURBO WAS OVER COMPENSATING FOR THE LACK OF POWER, DUE TO FUEL SHORTAGE, SO THE TURBO HAD TO BE REPLACED AS WELL. NOW THAT WE HAVE FOUND THE SOURCE OF THE PROBLEM, THE FUEL TANK AND FUEL PUMP HAS TO BE REPLACED AS TOO. INTO THIS FOR $5000 ALREADY WITHOUT REPLACING THE TANK AND PUMP. NEED SOME HELP. *TR

NHTSA ID

10256109

Incident

Dec 20, 2008

Mileage

136,000 mi

THE LINING OF THE DIESEL FUEL TANK FLAKED OFF WHICH CLOGGED THE FUEL FILTERS, WHICH RESULTED IN POOR ENGINE PERFORMANCE. *TR

NHTSA ID

10249629

Incident

Nov 21, 2008

Mileage

54,579 mi

TL*THE CONTACT OWNS A 2003 FORD F450 SUPER DUTY. THE VEHICLE HAS DOUBLE COIN RADIAL TIRES, SIZE 225/70/19.5 (NA). THIS COMPLAINT IS RELATED TO ODI NUMBER 10239016 REGARDING THE OTHER FIVE DEFECTIVE TIRES. THE TIRES WERE SERVICED BY AN INDEPENDENT TIRE MECHANIC AND TREAD SEPARATION WAS DISCOVERED IN SIX TIRES. THERE WAS ONE TIRE WITH A DIFFERENT DOT NUMBER. THE TIRES WERE REPLACED ON THE VEHICLE. THE FAILURE MILEAGE WAS 95,773 AND CURRENT MILEAGE WAS 96,343. UPDATED 10/16/08. *LJ UPDATED 10/20/08. *JB

NHTSA ID

10239027

Incident

Jul 13, 2008

Mileage

95,773 mi

When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.

This SKU is a Transmission Line. The customer communication requested return of unsold inventory to inspect the connector. The transmission line connector may have an incorrect thread size, which will prevent it from being installed.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successful programing. To ensure the VSM is configured correctly, use the Integrated Diagnostic System (IDS) scan tool and select the blue ball and socket icon in the upper left corner. Select the utility knife in the bottom left corner. Select Update/Special Function and enter 53061 in the blue box then press the tick mark. The screen will go back to the system utilities page. Navigate to the toolbox tab and run the Programmable Module Installation (PMI) on the VSM. The procedure will prompt you to manually enter the as-built into the VSM. Obtain the as-built data from PTS > OASIS > As-Built.

FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE