2002 Dodge Ram Owner Complaints

The contact owns a 2002 Dodge Ram 1500. The contact stated that while her husband was driving at various speeds, the ABS warning light illuminated and the vehicle seized. The contact managed to coast the vehicle to the shoulder of the road and place the vehicle in park. The contact exit the vehicle to inspect the engine and without warning when the front hood was open 4-foot flames shoot out from the hood. The contact sustained burns to the right hand. No medical attention was sought. The contact ran to the rear of the vehicle open the trunk and poured water that he had in a bucket on the flames. No police report was made. The fire department was not contacted. The vehicle was not repaired or diagnosed. No dealer was contacted nor the manufacturer was notified of the failure. Damages were to the wire harness, ABS module, and connecting rod. The failure mileage was approximate 220,000.

NHTSA ID

11430600

Incident

Aug 19, 2021

Mileage

220,000 mi

THE DASHBOARD STARTED CRACKING AROUND 60,000 MILES. IT HAS CONTINUED TO CRACK AND ALL OF THE PLASTIC VENT COVERS HAVE FALLEN APART INTO THE VENTS. I HAVE NOW FOUND OUT THAT THE INSULATION IN THE DASH IS DRY ROTTING AND FALLING INTO THE A/C VENTS AND CAUSING PROBLEMS WITH THE A/C MOTOR. THIS COULD POTENTIALLY CAUSE AN ELECTRICAL PROBLEM. *TR

NHTSA ID

10456343

Incident

Aug 1, 2006

Mileage

60,000 mi

1) ELECTRICAL PROBLEMS. LIGHTS KEPT GOING IN AND OUT 2) DASH CRACKING AND CRUMBLING. PIECES FALLING INTO AIR VENTS AND PREVENTING WINDSHIELD FROM DEFROSTING! DANGEROUS! COULD CAUSE AN ACCIDENT. DASH IS IN SUCH BAD SHAPE THAT IF PASSENGER AIR BAG WERE TO BE DEPLOYED IT COULD KILL SOMEONE DUE TO FLYING PIECES OF HARD PLASTIC ALL OVER THE VEHICLE. MAKE DODGE RECALL THIS PRODUCT! WHAT ARE YOU WAITING FOR? YOU ALREADY HAVE THOUSANDS OF COMPLAINTS FOR THIS PROBLEM! *TT

NHTSA ID

10444610

Incident

Jan 5, 2009

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2002 DODGE RAM MODEL R35. THE CONTACT WAS DRIVING 5 MPH WHEN SMOKE EMITTED INSIDE OF THE VEHICLE AND FLAMES WERE VISIBLE FROM THE HOOD. THE FAILURE CAUSED THE CONTACT TO DRIVE INTO A DITCH BUT THERE WAS NO CRASH. THE DOORS FAILED TO OPEN DURING THE FAILURE SO THE CONTACT ESCAPED BY PUNCHING AND SHATTERING THE WINDSHIELD. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE THE MECHANIC CONFIRMED THAT THE POWER DISRUPTION CAUGHT FIRE. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGES WERE 50,000.

NHTSA ID

10434257

Incident

Oct 29, 2011

Mileage

50,000 mi

THE DASH IN MY 2002 DODGE RAM QUAD CAB PICKUP BEGAN TO CRACK AND HAS NOW COMPLETELY SHATTERED. THERE ARE PIECES THAT HAVE BROKEN OFF AND ARE NOW EFFECTING MY HEATING AND COOLING SYSTEM. I AM CONCERNED THAT IF I HIT A BUMP TO HARD THAT A PIECE MIGHT ACTUALLY DISLODGE AND HARM SOMEONE. OR CAUSE EVEN MORE SEVERE INTERNAL DAMAGE THAT MIGHT EFFECT MY ABILITY TO OPERATE THE VEHICLE. *TR

NHTSA ID

10432304

Incident

Aug 6, 2009

Mileage

80,000 mi

THE DASH WAS FINE NO EVENTS UNTIL SEPT.2008. OPENED THE TRUCK UP ONE DAY TO REVEAL A HUGE CRACK IN THE DASH. THE DASH IS CRACKING IN THE RATE OF 2 CRACKS IN 2008 AND ONE IN 2009 ,ONE IN 2010. WE ARE UP TO 4 CRACKS NOW. HASN'T BEEN FIXED. I AM HEARING HORROR STORIES OF THIS CAUSING SERIOUS PROBLEMS. I DO NOT LET MY KIDS RIDE IN IT.THE MORE IT CRACKS THE LESS SAFE WE FEEL DRIVING IT. *TR

NHTSA ID

10422521

Incident

Sep 8, 2008

DASH CRACKING ON 2002 DODGE RAM QUADCAB; NOT THE FIRST VEHICLE TO BE EXPERIENCING THIS. MANY FORUMS AND COMPLAINTS REGARDING THIS MATTER. FORMAL COMPLAINT ON DODGE TO NHTSA. VEHICLE HAD ABOUT 95K WHEN FIRST APPEARED; PROGRESSIVELY WORSE, BECOMING A DRIVING HAZARD. *TR

NHTSA ID

10381304

Incident

Jan 1, 2008

Mileage

95,000 mi

TL*THE CONTACT OWNS A 2002 DODGE RAM. WHILE THE VEHICLE WAS STATIONERY, THE EXTERIOR BODY PAINT EXPOSED A WHITE SPOT THE SIZE OF A SOFTBALL. THE DEFECT WAS LOCATED ON THE DRIVER'S SIDE DOOR AND THE HOOD. IN ADDITION, THERE WAS BUBBLING ON THE EXTERIOR PAINT NEAR THE DRIVER'S SIDE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE EXTERIOR BODY PAINT DEFECT WOULD EVENTUALLY RUST FROM THE INNER TO THE OUTER SURFACE. THE AUTHORIZED DEALER ADVISED THAT THE VEHICLE BE BROUGHT IN WHEN IT BEGINS TO RUST AND POSSIBLY REPAIRED AT NO COST. AS OF JULY 24, 2008, THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT TOOK THE VEHICLE TO AN AUTO BODY SHOP FOR A SECOND OPINION. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 85,000 AND CURRENT MILEAGE WAS 89,000.

NHTSA ID

10235686

Incident

Feb 2, 2008

Mileage

85,000 mi

AFTER OWNING THIS VEHICLE FOR 6 YEARS< THE PAINT IS STARTING TO PEEL, AND IT IS RUSTING FROM THE INSIDE OUT. ALTHOUGH THIS IS NOT A SAFETY ISSUE I AM HOPING YOU CAN POINT IN THE RIGHT DIRECTION. THANK YOU. *TR

NHTSA ID

10235315

Incident

Feb 1, 2008

Mileage

88,000 mi

1. REPLACED FUSE (ORIGINAL EQUIPMENT) ON MY 2002 DODGE RAM PICKUP FOR THE LEFT REAR TRAILER LIGHTS WITH STOREHOUSE FUSE BOUGHT AT HARBOR FREIGHT STORE. 2. FUSE DID NOT "BLOW" AS IT SHOULD AND "WELDED" ITSELF INTO FUSE BLOCK. I CANNOT REMOVE THE REMNANTS OF THE FUSE. 3. THIS MAY NECESSITATE COMPLETE REPLACEMENT OF THE FUSE BLOCK AT CONSIDERABLE COST. POSSIBLE HUNDREDS OF DOLLARS. *TR

NHTSA ID

10215125

Incident

Jan 5, 2008

EMAIL CONCERNED THAT THE AIRBAGS IN HIS 2002 DODGE RAM TRUCK FAILED TO DEPLOY IN A 25 TO 30 MPH ACCIDENT. *KB

NHTSA ID

10206071

Incident

Aug 22, 2007

DASH ON OUR 2002 DODGE RAM IS CRACKING. *JB

NHTSA ID

10204043

Incident

Aug 23, 2007

CONSUMER IS COMPLAINING ABOUT CRACKS IN THE DASHBOARD. CUSTOMER STATES THAT VEHICLE HAS ABOUT 10 CRACKS IN THE DASHBOARD. THE CUSTOMER WOULD LIKE TO KNOW WHY DODGE IS NOT DOING ANYTHING ABOUT THIS PROBLEM. *KB

NHTSA ID

10203765

Incident

Jan 1, 1901

2002 DODGE RAM FRONT PASSENGER SIDE WHEEL CAME OFF THE VEHICLE. *KB (OHIO TRAFFIC CRASH REPORT) *JB

NHTSA ID

10194663

Incident

May 31, 2007

TL*THE CONTACT OWNS A 2002 DODGE RAM. THE DASHBOARD HAS CRACKED IN SEVERAL PLACES. THE VEHICLE IS OCCASIONALLY PARKED IN DIRECT SUNLIGHT AND HAS NOT BEEN INSPECTED BY A DEALER. THE CURRENT MILEAGE IS 60,000 AND FAILURE MILEAGE WAS 55,000.

NHTSA ID

10193959

Incident

Nov 13, 2006

Mileage

55,000 mi

THE BOARD 2002 DODGE RAM 1500 QUAD CAB DASHBOARD IS ALL CRACKED AND BREAKING APART. READ ABOUT THIS PROBLEM IN MY LOCAL ACTION LINE SECTION WHERE OTHER DODGE OWNERS OF DIFFERENT MODELS BETWEEN THE YEARS 2000 AND NEWER WERE HAVING THE SAME PROBLEM. THE DASHBOARD STARTED CRACKING NEAR THE VENTS AND HAS PROCEEDED TO BREAK IN OTHER PLACES ALONG THE ENTIRE DASHBOARD, ABOUT LESS THAN A MONTH AFTER THE WARRANTY EXPIRED. I' HAVE ASKED AROUND TO PEOPLE RELATED IN THE INDUSTRY, AND HAVE BEEN INFORMED THAT WAS A VERY COSTLY REPAIR. SEVERAL HUNDRED DOLLARS WORTH. ALSO, I HAVE A FRIEND WHO EXPERIENCED THE SAME PROBLEM ON A 2000 DODGE 1500 . PLEASE HELP, THANK YOU. *AK

NHTSA ID

10193686

Incident

Nov 1, 2005

CRACKED DASHBOARD. *AK

NHTSA ID

10190424

Incident

May 1, 2006

TL*THE CONTACT OWNS A 2002 DODGE RAM 3500. THE CONTACT STATED THAT THERE IS A CRACK ON THE VEHICLE'S DASHBOARD WHICH CAUSED THE LIGHTS TO MALFUNCTION. THE DEALER HAS NOT INSPECTED THE VEHICLE. THERE HAVE BEEN NO FAILURES TO DATE. THE CURRENT MILEAGE IS 98,700 AND THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10190161

Incident

Sep 1, 2006

DT*: THE CONTACT STATED THE DRIVER EXITED THE VEHICLE AFTER PUTTING IT IN PARK WITH THE ENGINE RUNNING. THE VEHICLE BEGAN TO ROLL BACKWARDS AND A BYSTANDER GOT IN AND PUT THE VEHICLE IN PARK. THERE WAS MINOR DAMAGE DONE TO THE DRIVER SIDE DOOR. THE VEHICLE WAS NOT INSPECTED BY A MECHANIC. THERE IS A NHTSA RECALL, # 05V462000, REGARDING THE AUTOMATIC TRANSMISSION; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 7/25/2006 - *NM

NHTSA ID

10158772

Incident

Jun 1, 2006

Mileage

60,000 mi

DT*: THE CONTACT STATED WHILE PARKED, THERE WAS A PUDDLE UNDER THE FRONT END OF THE VEHICLE. AN INDEPENDENT REPAIR SHOP DETERMINED THERE WAS A LEAK IN THE STEERING RACK. THE STEERING RACK NEEDS TO BE REPLACED. UPDATED 03/28/06. *JB

NHTSA ID

10152388

Incident

Mar 9, 2006

Mileage

50,000 mi

DT: THE CONTACT OWNS A 1992 HAUL RIGHT 60 BOAT TRAILER MANUFACTURED BY B AND M. WHILE TRAVELING 60 MPH THE TONGUE BROKE WHERE IT HOOKS ON THE TRUCK, CAUSING THE BOAT AND THE TRAILER TO FALL DOWN AND HIT THE PAVEMENT. WHEN THE BOAT TRAILER WAS INSPECTED IT SHOWED ADDITIONAL WEAKNESS IN THE TONGUE. THE CONSUMER PRODUCT SAFETY COMMISSION TOLD THE CONTACT TO CONTACT NHTSA BECAUSE THE TRAILER HAD BRAKE LIGHTS. SHE HAS TRIED TO CONTACT THE BOAT MANUFACTURER, AND COULD NOT CONTACT THEM BY PHONE OR LETTER. THEY HAVE NOT GOTTEN A RESPONSE, AND THE DEALERSHIP WAS OUT OF BUSINESS. *AK

NHTSA ID

10136245

Incident

Aug 8, 2005

DT: THE CONTACT HEARD A RATTLING NOISE IN THE BACK OF THE TRUCK. HE WAS MAKING A TRIP TO LOS VEGAS, WAS WALKING AROUND THE TRUCK ON AND LOOKED UNDER THE WHEEL AND HE NOTICED A CLAMP THAT HELD A SPRING IN PLACE BROKE. *AK

NHTSA ID

10132440

Incident

Aug 2, 2005

Mileage

37,827 mi

WHEN ENGAGING THE CRUISE CONTROL IT WOULD INTERMITTENTLY CAUSE THE VEHICLE TO SHIFT AND ADVANCE TO A HIGHER SPEED. DEALER WAS NOTIFIED VIA PHONE. THE DEALER OR A REPAIR SHOP MADE NO INSPECTION AT THIS TIME.*AK THE VEHICLE HAS ACCELERATED SUDDENLY A NUMBER OF TIMES IN THE PAST 3 YEARS. THE CRUISE CONTROL WAS RECENTLY FIXED BUT THAT WAS BECAUSE IT DIDN'T WORK AT ALL. *BF *NM

NHTSA ID

10115347

Incident

Jan 12, 2005

Mileage

3,000 mi

WHILE DRIVING VEHICLE WILL EXPERIENCED SUDDEN ACCELERATION. HOWEVER, WHEN APPLYING THE ACCELERATOR PEDAL VEHICLE IDLED QUIETLY, AND THEN SUDDENLY ACCELERATED. *AK

NHTSA ID

10117278

Incident

Mar 15, 2005

Mileage

39,600 mi

THE WINDSHIELD AND SIDE WINDOWS WOULD FOG UP WHEN THE HEATER AND DEFROSTER WERE ON, WHICH WAS MAKING IT DIFFICULT TO SEE THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER FOR TESTING, BUT THE CAUSE WAS UNDETERMINED. *AK *SC *JB

NHTSA ID

10109130

Incident

Jan 26, 2004