RoadVitals

1996 Ford Aerostar

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
104
Latest Mar 11, 2020
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Latest Mar 13, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
13
7 injuries, 0 deaths reported

Overview

Our database contains 104 NHTSA owner-reported complaints for the 1996 Ford Aerostar, most frequently naming the other / unspecified, brakes and electrical categories. 6 safety recalls have been issued covering this model year; 2 NHTSA investigations name it; and 104 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

6 campaigns cover this model year

View all 6

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06E022000

SERVICE BRAKES, HYDRAULIC

Mar 13, 2006
7,440 units potentially affected
The defect: CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
The risk: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
The remedy: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
BRAKE PARTS, INC.View on NHTSA.gov
99V029000

ELECTRICAL SYSTEM:IGNITION:SWITCH

Feb 9, 1999
762,201 units potentially affected
The defect: VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
The risk: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
The remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
FORD MOTOR COMPANYManufacturer number 99S02View on NHTSA.gov
98E010000

SERVICE BRAKES, AIR:DISC:ROTOR

Apr 8, 1998
23,500 units potentially affected
The defect: EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
The risk: LOSS OF BRAKING CAN RESULT.
The remedy: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.
AIMCO PRODUCTS INC.View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA99002ClosedEngineering Analysis

TRANSFER CASES AND REAR DRIVE SHAFT

Opened Jan 7, 1999
Closed Nov 14, 2000

There is no summary currently available

POWER TRAINLed to recall 99V094000
RQ98012ClosedRecall Query

TRANSFER CASES AND REAR DRIVESHAFT

Opened Jul 31, 1998
Closed Jan 7, 1999

There is no summary currently available

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)Led to recall 97V204000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 104
Body & structureOther / unspecified
Filed Mar 11, 2020

CONDENSED VERSION: @ 70MPH POSTED SPEED LIMIT GOODYEAR ALLEGRA TOURING TIRE EXPLODED LIKE A 1/4 STICK OF DYNAMITE AND ALMOST COST ME MY LIFE IF MY REACTIONARY TIME HAD BEEN ANY SLOWER. 3 OTHER TIRES SAME LEAKING THROUGH SIDEWALL GOODYEAR DECORATIVE GILLS ON SAME THIS HAS NOT RESOLVED. SELLER HAS NOT RESOLVED AND REFUSES THOUGH GOODYEAR SAID TO REPLACE BEFORE THE MAIN ISSUE OF THE LEFT FRONT DRIVER TIRE EXPLODING AT 70 MPH, . LITIGATION IS NEXT STEP IF AMICABLE RESOLUTION CAN NOT BE HAD. CONTACT HAS BEEN EXTENSIVE WITH GOODYEAR TO NO RESULTS.

NHTSA ID
11317548
Incident
Jul 2, 2019
Electrical
Filed Aug 23, 2017
Fire reported

I HAD SMOKE AND ACRID SMELL COMING FROM UNDER MY DASH (WHILE DRIVING), WHERE THE STEERING COLUMN FITS TO IT. I HAVE CONTACTED A MAJOR FORD DEALER (BRANDON FORD), AND THEY ARE REFUSING TO HELP ME. I CALLED FORD CUSTOMER SERVICE AND HE SAID MY VIN IS NOT LISTED FOR A RECALL, BUT YET HAD NO ANSWER FOR ME WHEN I ASKED WHY IS MY VEHICLE NOT ON THE RECALL LIST, WHEN IT IS IN THE GROUP OF VEHICLES THAT WERE RECALLED AND THAT ARE CATCHING ON FIRE WHILE DRIVING DOWN THE ROAD. OVER 887,000 WERE RECALLED FOR FIRE RELATED PROBLEMS, BUT THEY REFUSE TO EVEN LOOK AT MINE. SO, CAN I KEEP DRIVING IT? I DON'T KNOW IF IT WAS A ONE TIME THING, OR WHAT.....

NHTSA ID
11019124
Incident
Aug 23, 2017
Mileage
107,000 mi
Seat belts
Filed Dec 6, 2014

12/6/2014 @ 18:20 C.S.T. TO WHOM IT MAY CONCERN, (HOPEFULLY A SUPERVISOR OR DIRECTOR) THE DRIVERS SIDE SEAT BELT FLOOR CLASP FAILS. I RELEASES THE SEAT BELT WHILE DRIVING. AFTER TWO OR THREE TIMES OF RE-HOOKING THE SEAT-BELT TO THE HOLD DOWN CLASP BOLTED THROUGH FLOOR BOARD OF THE VEHICLE, IT WILL NO LONGER ACCEPT AND HOLD THE SEAT BELT IN PLACE. THIS HAS HAPPENED TO BOTH OF MY VEHICLES, THE 1993 OCCURRED AT APPX. 190,000 MILES AND WHEN I CONTACTED FORD ABOUT THIS SAFETY ISSUE AND FAILURE OF THE SEAT BELT TO REMAIN CLASPED, THEY SIMPLY SAID, IT IS AN OLDER VEHICLE AND YOU HAVE TO PURCHASE THE ENTIRE SEAT BELT ASSEMBLY FOR OVER $500.00...[XXX]. THIS IS A SAFETY ISSUE...AND FORD NEEDS TO REPLACE THE HOLD DOWN CLASP WHICH IS BOLTED THROUGH THE FLOOR BOARD FREE OF CHARGE. LABOR AND PART FREE. IF I HAD BEEN ATTEMPTING TO AVOID AN ACCIDENT OR WAS IN AN ACCIDENT AND THAT BELT LET LOOSE, I MIGHT BE DEAD. THIS SHOULD NEVER HAPPEN. MY 1976 FORD TORINO NEVER HAD THIS PROBLEM, NOR THE OTHER VEHICLES REFERENCED, NOR ANY OTHER VEHICLE I HAVE EVER OWNED. THIS IS A SAFETY AND DRIVER SAFETY WHICH NEEDS TO BE ADDRESSED, AND NO MATTER THE AGE OF THE VEHICLE, IT IS A SAFETY FEATURE MANDATED BY ALL STATES MOTOR VEHICLE LAWS TO BE ENGAGED AT ALL TIMES WHILE DRIVING. IF THE ITEM IS DEFECTIVE BY DESIGN, AND AS IN MY CASE, IT ARBITRARILY AND WITHOUT NOTICE OF ITS IMMINENT FAILURE, FAILS WITH NO PRESSURE ON IT, IT NEEDS TO BE A RECALLED ITEM. I ALSO SUSPECT THAT FORD IS STILL PURCHASING FROM THE SAME SUPPLIER AND IF THIS IS TRUE, THEN ALL SUBSEQUENT SEAT BELT HOLD DOWN CLASPS WILL FAIL LIKEWISE AT THE 6 - 9 YEAR RANGE, WITHOUT NOTICE AND EXPOSE FORD TO WRONGFUL DEATH SUITS DUE TO MECHANICAL DEFECTS IN THOSE SEAT BELT HOLD DOWN CLASPS. I AM CUTTING AND PASTING A COPY OF THIS FORMAL COMPLAINT SO THAT I HAVE A RECORD OF ITS SUBMISSION TODAY DECEMBER 6, 2014 @ 18:20 C.S.T. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID
10662582
Incident
Nov 19, 2014
Mileage
158,000 mi
Powertrain (other)
Filed Sep 13, 2011

TL* THE CONTACT OWNS A 1996 FORD AEROSTAR. WHILE DRIVING APPROXIMATELY 50 MPH THE FRONT DRIVERS SIDE TIRE BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THE TRANSFER CASE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NHTSA RECALL CAMPAIGN ID NUMBER: 97V204000 (POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)) MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

NHTSA ID
10425204
Incident
May 1, 2011
Mileage
160,000 mi
Other / unspecified
Filed Nov 13, 2007

TL*THE CONTACT OWNS A 1996 FORD AEROSTAR. WHILE DRIVING 50 MPH, THE CONTACT HEARD A LOUD ROARING SOUND. SHE STOPPED THE VEHICLE AND NOTICED THAT THE REAR PASSENGER WHEEL SPOKES FAILED. THE WHEEL WAS REPLACED WITH A SPARE TIRE. THERE WAS NO DAMAGE TO THE TIRE OR VEHICLE. THE WHEEL WAS INSPECTED BY THE REPAIR SHOP AND THEY STATED THAT THE WHEEL WAS DEFECTIVE. THE WHEELS WERE THE ORIGINAL WHEELS FOR THE VEHICLE. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 58,000.

NHTSA ID
10208767
Incident
Oct 28, 2007
Mileage
58,000 mi
Electrical
Filed Dec 12, 2006

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS BEING DRIVEN 30 MPH, ALL POWER FAILED AND THE ENGINE STALLED. THE STALLING HAS ALSO OCCURRED AT HIGHER SPEEDS AND WHILE THE VEHICLE WAS IMMOBILE. A FUSE CONNECTED TO THE BATTERY CABLES BLEW. WHEN THE FUSE WAS REPLACED, THE ENGINE WOULD RESTART. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER. THE CONTACT WAS INFORMED THE VEHICLE WAS NOT INCLUDED IN RECALL # 99V029000, FOR THE ELECTRICAL IGNITION SWITCH DUE THE VIN EVEN THOUGHT VEHICLE HAD THE SAME PROBLEMS. THE MANUFACTURER WAS NOT NOTIFIED.*AK

NHTSA ID
10175900
Incident
Dec 11, 2006
Mileage
115,000 mi
Powertrain (other)
Filed May 8, 2006

DT*: THE CONTACT STATED THE VEHICLE WAS TAKEN TO A TIRE DEALER FOR REPLACEMENT OF THE TIRES. AFTER THE TIRES WERE REPLACED AND VEHICLE WAS BEING DRIVEN HOME AT 45MPH, THE VEHICLE HESITATED AS IF THE GEARS WERE NOT CHANGING PROPERLY. THE VEHICLE WAS RETURNED TO THE TIRE DEALER WHO DETERMINED THE DRIVE SHAFT WAS LOOSE. THE DEALER RECOMMENDED THE VEHICLE NOT BE USED UNTIL THE DRIVE SHAFT WAS WELDED AND THE UNIVERSAL JOINT WAS REPLACED.

NHTSA ID
10156967
Incident
May 4, 2006
Mileage
214,000 mi
Other / unspecified
Filed Apr 18, 2006

DT*: THE CONTACT STATED THE FRONT WHEELS ON THE VEHICLE CRACKED. THIS WAS NOTICED FROM A VISUAL INSPECTION BY THE CONTACT. THE MANUFACTURER WAS ALERTED AND STATED THE WHEELS CRACKED UNDER STRESS FROM THE VEHICLE.

NHTSA ID
10155593
Incident
Mar 20, 2006
Mileage
124,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

02138

POWER TRAIN:MANUAL TRANSMISSION

LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT

03148

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT

02221

ENGINE AND ENGINE COOLING:ENGINE

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ

870197

ENGINE AND ENGINE COOLING:ENGINE

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT

02176

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

02142

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION AND A 4.0L OHV ENGINE MAY EXHIBIT A NOISE / VIBRATION, NO DRIVE, UNUSUAL NOISE DURING CRANKING OR A NO CRANK CONDITION. *TT

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Ford Aerostar by model year
YearComplaintsRecallsInvestigationsIssue Index
2000600—
1999700—
1998400—
1997635259.7
1996Viewing1046260.5
19951577365.5
19942575566.7
19933744566.4
19923175566.5
19912234271.0
19901957574.3
19892606975.6
198817751270.9
198711452075.3
19865391775.7
1985002—
1984000—
1976000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.