2020 Ford Escape Powertrain (other) Problems

There is a malfunction in the AWD system that gives a code for low voltage. I tracked down the issue to a factory defect where the connector to the AWD module doesn’t have a ground wire. Ford has acknowledged the issue under “Ford Customer Satisfaction Program 21B19” but it has since expired. (Expired after the vehicle was purchased) As a result of the fault, It disables AWD, hill start assist, forward collision assist.

NHTSA ID

11766344

Incident

Sep 6, 2026

Vacuum pump went and replaced then rpms spiking between 1500 and 2000. Then traction control light came on and noise in from end. All within a week.

NHTSA ID

11766311

Incident

Aug 23, 2026

Vehicle: 2020 Ford Escape I am experiencing a recurring drivability issue with my 2020 Ford Escape. During normal or light acceleration, primarily between approximately 1,000 and 2,000 RPM, the vehicle intermittently jerks, surges, or hesitates. At the same time, I can observe slight RPM fluctuation. The condition continues to occur even when the vehicle is driven in Sport mode. On some occasions, the vehicle has also accelerated suddenly and more aggressively than expected, making the vehicle’s response unpredictable. I have had situations where I nearly collided with another vehicle because of the unexpected acceleration. The vehicle has displayed diagnostic trouble code P0600 – Serial Communication Link. The ignition coils and spark plugs have already been replaced, but the condition remains unchanged. I am concerned because the hesitation, jerking, surging, and unexpected acceleration occur while the vehicle is being driven and could affect safe and predictable vehicle control in traffic. I have not yet received a final diagnosis confirming whether the cause is related to the transmission, torque converter, PCM/TCM, communication system, speed control system, or another component. I am reporting this issue so that NHTSA has a record of the condition in case other owners of 2020–2021 Ford Escape vehicles are experiencing similar drivability and unexpected acceleration problems.

NHTSA ID

11766259

Incident

Sep 9, 2026

The contact owns a 2020 Ford Escape. The contact stated while driving at an undisclosed speed, the message that the door was unlocked was displayed. The vehicle was taken to a dealer, and the contact was informed of an unrepaired recall associated with the VIN. The contact was informed that an unknown device was installed, and the vehicle was repaired; however, the failure reoccurred. The contact stated that the front driver's and passenger's side doors failed to unlock. The contact stated that the family crawled into the vehicle through the trunk. The vehicle was taken back to the dealer. The contact was informed that the driver’s and passenger’s side front doors needed to be replaced. The vehicle was taken to an auto body shop as per the dealer. The driver’s and passenger's side front doors were replaced but the failure reoccurred. In addition, the transmission shift to park warning light was illuminated. The vehicle was taken back to the dealer. The contact was informed that the auto body shop had clipped the wiring harness from an unknown sensor. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with battery failure. The battery was replaced, and the vehicle was repaired. The failure reoccurred. The contact stated that the front driver's and passenger's side doors failed to unlatch occasionally. The doors unlatched and the transmission shift to park error messages were displayed. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the dealer was an independent dealer. The failure mileage was approximately 58,986.

NHTSA ID

11761090

Incident

Mar 10, 2026

Mileage

58,986 mi

The contact owns a 2020 Ford Escape. The contact stated that upon shifting into drive(D), the vehicle jerked significantly. The contact continued to drive the vehicle despite the failure, which intensified while coming to a stop. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 130,000.

NHTSA ID

11758510

Incident

Aug 20, 2026

Mileage

130,000 mi

I have a 2020 Ford escape all-wheel-drive, it only has 42,000 miles on it, and I had to have the differential replaced.

NHTSA ID

11757833

Incident

Aug 12, 2026

On 8th of June 2026, exiting I35W onto Convery Dr. I notice my dash gauges failed in proving any information. I immediately pulled over turned off the vehicle and turn it on. Gauges did not work, but vehicle did start and was running normal. I utilize the Waze app to monitor my speed and arrived home safely while putting no one at risk. I had to take a different vehicle to Hopps automotive for repairs, upon return my vehicle gauges were working as normal. Two days after the incident started the vehicle and the gauges were not working, but vehicle did make it to the auto shop for repairs and was told the gauge clusters were out. Took roughly a few weeks for the repair because the clusters still wouldn't work after repair. had a safety recall went to ford for the software updates. After the updates everything seem to be running just fine. Ford Cleburne did a curtsey inspection, Transmission passed, but now my transmission is having issues. I have a zip file full of reports on my vehicle maintenance, but unable to upload all the information.

NHTSA ID

11756059

Incident

Jun 8, 2026

The contact owns a 2020 Ford Escape. The contact stated that while driving at an undisclosed speed and turning the steering wheel, the vehicle failed to accelerate as needed with an abnormal popping sound coming from the vehicle. There was no warning light illuminated. The contact was stopped before resuming normal driving. The vehicle was taken to the dealer, and the failure was associated with the rear differential. The contact stated that four repairs had been performed on the rear differential; however, the failure persisted. Recently, the contact was informed that the rear differential needed to be repaired, and that the repair was not covered under warranty. The dealer reached out to the manufacturer, and the manufacturer agreed to cover a portion of the cost of the repair. The vehicle was not yet repaired. The failure mileage was approximately 30,000.

NHTSA ID

11754909

Incident

Jul 1, 2023

Mileage

30,000 mi

The transmission on my 2020 Ford Escape began shuddering around 30 mph and occasionally shifted harshly during acceleration without any warning lights or messages. I took the vehicle to Beechmont Ford, where the technician confirmed the concern, found metal contamination in the transmission fluid, and determined the transmission has internal damage consistent with a failed output planetary bushing, requiring a complete transmission overhaul. The vehicle has approximately 65,000 miles, and the estimated repair cost is $7,200. This issue creates a safety concern because the transmission could unexpectedly lose power, fail to shift properly, or stop propelling the vehicle while driving, increasing the risk of a crash.

NHTSA ID

11753469

Incident

Jul 28, 2026

I've taken my car 3 times for the same recalls 1st time was to jack Kisse for power train and fuel injector he told me the recall wasn't to my car I argued I can tell something was wrong with my car it keeps stalling and it's going to end up killing me in traffic from the fuel injectors so I take it too [XXX] of Norton and broken arrow they tell me after sitting there for 8 hours that the powertrain is not taking it takes 4 hours to do it and they only have 30 minutes left and all of a sudden it takes that's a bunch of crap cuz there was only 30 minutes anyway I leave still notice something then a wrench and engine light come on so I take it again were I was charged 've taken my car three different times to get my powertrain recall and fuel injector recall fixed they have failed to do so... and now I have a wrench and engine light showing up on my car I take again cuz my app is still tells me that I have recalls for a powertrain and fuelI injector recalls all they did was charge me to get the code when I knew it was for the recalls over $200 the very next day the lights come right back on my powertrain and fuel injector never been fixed my they told me I have an open fuel line and let me drive off with it now I'm concerned that my car is going to catch on fire especially in the heat and what do I do if you just taking it back for them to not do anything to my car and now I have the ranch and the engine light coming on and off a different time one day one minute will be the ranch next will be the engine sometimes it's both and I have records of it I keep trying to report it to you guys and I'm not hearing anything back I don't know what else to do I believe that my car is a lemon and they're not going to be able to fix it since I'm taking it three times already please contact me back to let me what I should know where I should do thank you you reach me at [XXX] or at my email [XXX] I prefer you contact me through email thank your INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5

NHTSA ID

11753441

Incident

Jun 16, 2026

Since about 80,000 miles my escape has been jerky when shifting in low gears and hesitates to accelerate or accelerates slow putting me and other drivers at risk. I have taken it to ford several times and each time they fixed something but not the problem. They replaced my rear differential, alternator, compressor and AWD module. Also they have done transmission fluid exchanges and updates on the software, however they never fixed the issue. I stressed everytime I took my car in that I was worried about my transmission and powertrain and everytime they did diagnostics I was told everything was great. They drove it as well.( it dont take much to reproduce the symptoms) All that happened over the past 2 years and the car is still shifting hard in low gears and hesitates to accelerate. Recently I had an incident where it seemed to go in to neutral while shifting between gears on acceleration and actually rolled backwards and the wrench light came on 😳. So I took it back. Now im told I need a new transmission and turbo boost at just over 100,000 miles for $13,098. The car isnt even worth that much. I've done some research and there are definitely alot of other escape/ford owners with same issues.

NHTSA ID

11752563

Incident

Jul 2, 2026

Our transmission is going out. We started having issues without any warning lights coming on. The car jumps heavily at stops lights when we are coming to a stop. The car then doesn't want to accelerate from a stopped position. When we hit the accelerator, the car starts skipping/jumping and the gas pedal feels like it doesn't have any grip. We had an independent mechanic ride in the vehicle and hook it up to the computers and saw that the codes reading is all transmission related. This has made the car undrivable because there have been several times that we have stalled in the middle of intersections and have to cut the car off and turn it back on to try to get it out of the road. Also, the car jumps so far forward when stopping that we are risking rear ending someone. We had the catalytic converter recall done and two days later we started having codes for the transmission pawl. We contacted Ford (who did the recall), and they wanted to charge us for diagnosing it even though it started right after they had it. Only a few weeks after that, we started having the jumping/skipping of the transmission. The pawl seems to have been a wire issue and was fixed. But we are being told we need a new transmission. The car is only 6 years old.

NHTSA ID

11752507

Incident

Jun 4, 2026

I have things wrong with my vehicle that are not currently included in recalls for my specific VIN but they are for the same model year. Yesterday, I paid $6000 to fix a stuck wastegate on the turbo and something to do with the ABS. I was informed that there is a $700 problem with a vacuum pump. I have also paid for 2 costly repairs, one that wouldn't let the car start after refueling and something else that triggered a check engine light. How do you get a recall extended to include other VINs? I work as a contractor at Ford, what an embarrassment to have one of our vehicles with so many issues. Please help. I'm a young widow with limited income, commuting 2 hours a day. I cannot be without my car and I can't afford to pay for repairs while also financing.

NHTSA ID

11752422

Incident

Apr 8, 2024

I have taken my vehicle to 2 different ford Dealership one tell me that this wasn't for my car and immediately it shows up that I need a fuel injection second one Jim Norton charges me for the lights on my car to get a diagnostics when the recalls and I should never been charged and then the light comes on the next day for the wrench and the engine I've taken my car three times for the recalls and never had to get fixed my engine sounds like crap now it barely runs and it's because of the recall that are not getting fixed

NHTSA ID

11750715

Incident

Jun 16, 2026

Transmission needs to be replaced at 70k miles. In reading other user's stories online and hearing from mechanic, I was told to make a report here in reference to Ford's internal memo (SSM 54939). It would be nice for NHTSA to urge Ford to replace/fix transmissions on the 1.5L Dragon engines on the Escape 2020, etc. Too many widespread safety concerns/issues with a defective engine that they know about yet failed to act.

NHTSA ID

11750322

Incident

Jul 14, 2026

I noticed the Powertrain slipping after 583 miles. Took to ford which ford recalibrated the software. Powertrain continued to slip during shift change. Noticed ford dealership in norco. Another recalibration. This continued until my transmission flush at 60,000. Took my ford escape at 95,000 for the same thing, then I was told I needed and new transmission, which would cost $4600. All of this back and forth, at a dealership i didn't buy the car from. Why wasn't it recommended to me at my 60,000 mile why my car was under warranty. Fast forward to now. Stopped driving my car at 109,000 miles. Had it parked for over 3 months. Went back to ford in norco was told transmission would cost me $8600!!! Found a auto shop that bought the transmission from norco ford and was charged $5600. What a headache.

NHTSA ID

11750134

Incident

Mar 11, 2021

Complete transmission failure under normal driving at about 50,000 miles. Cost about $7500 to completely rebuild the transmission since Ford has none available within the next 6 months, probably because so many of them are failing early.

NHTSA ID

11749617

Incident

Apr 24, 2026

My low mileage 2020 Ford Escape has rear differential shuddering, grinding, and bumping during low speed turns.

NHTSA ID

11749199

Incident

Jun 1, 2026

I bought my car 2 years ago I heard about a recall so I had check turns back if you don't inject your powertrain and they can't fix it feel injector because they don't have the part apparently but it goes to the powertrain I've had to check three times the last time the light came on the very next day the wrench and the engine now it's saying something by my Cadillac converter and it open fuel line that won't close due to this problem they made me pay $27 just to take the codes off didn't do anything to my car let me drive this car off the lot the very next day the lights come back on I know these are recalls and they're very dangerous for me to drive I'm a mother and a wife and I am not trying to die driving his vehicle I took it if they're three times there has got to be something done they need to give me a vehicle or I've already filed a report with you guys on June 16th 2026

NHTSA ID

11749146

Incident

Jun 16, 2026

I have a 2020 Ford Escape SE That I am having a lot of issues with the transmission. I looked to see what kind of recall is for on it and I'll see there is a lot of complaints related to the transmission and when I called Ford they said mine was not included with the recalls on the transmission although my transmission is also jerking, hard shifting, along with a shuddering, loud clunking when you shift and to reverse or drive, Also my park break has been kicking on by itself and it's done it to me while sitting in traffic, decrease in acceleration (it about got me hit on the highway) as the car could not get gas It would drop dramatically from 70 down to nothing almost on interstate I-75 highway. Also I've had a burning smell coming from the engine. My car is now at the transmission shop and they are trying to figure out what's going on with it I've had it to AutoZone for them to put it on their tester and a lot of transmission codes came up and one of them so happen to bend the clutch solenoid which could be caused by leaking fluids! I called Ford the corporate office that and they said well you're 20 20 Ford Escape It's not the one in the recalls or the will with the transmission issues but yet it is doing the exact same thing as the other ones that are listed!! It has just a little over 100,000 mi on it The car's not driven hard whatsoever. I was not giving much warning about the transmission The little wrench thing came on flashing and then suddenly these things start happening while on the highway, but then did not stay on! I had to drive my car 45 mi at speed about 30 to get it home.. I do use my car once in a while to drive Lyft which now I'm without being able to make some extra money for groceries and whatnot because of this car! Also the one of the recalls that is on this car pertains to the transmission updates and according to Ford they don't have the tool to update it but yet this update could affect the functioning of the transmission.. I was at ris

NHTSA ID

11748713

Incident

Jun 19, 2026

Electrical issues: Media screen blacks out/glitches including speakers. Gear switch "Dial" will move on its own and park itself. Switching from "Drive to Park". "Transmission not in park" on dash , Lights on dash for engine 4x

NHTSA ID

11748433

Incident

Dec 31, 1969

The vehicle jerks forward when driving at slower speeds, around 10-25 miles per hour. I have especially noticed this on the highway when there is moderate to heavy traffic as I am consistently driving at slower speeds. The vehicle was checked by the original dealer I bought it from as well as a Ford dealership, but neither could replicate the problem. However, I have driven with multiple people who have agreed that the issue is happening, and I have read on many, many online forums and Facebook groups that others are having the same problem.

NHTSA ID

11748427

Incident

Oct 1, 2025

Clutch inside transmission failed while driving. Started lurching and I was able to pull into a parking lot. Towed to service station where it was confirmed. Warning sign came on after attempting to drive the car to service station.

NHTSA ID

11747683

Incident

Jun 29, 2026

Power train fault, AWD OFF, Colision assist off

NHTSA ID

11747569

Incident

May 9, 2026

Transmission shuddering, slipping and or hesitating.

NHTSA ID

11747567

Incident

Jun 15, 2026