2014 Ford Explorer Engine Problems

When I'm driving on the freeway. I could be on flatland and it will stall, I could be going down a hill and it stalls, I could be on a regular road, turning a corner, hitting a bump. And it stalls when I'm on the freeway, I have to get over very scary happens all the time when It happens I coast, I put it into park, i turn it off, and it restarts immediately every time. This is constantly happening. IHave a video and picture but it will not upload on this.But it says hell descending control fail

NHTSA ID

11723535

Incident

Feb 10, 2026

Engine over heat warning while driving and I checked there is a coolant leakage.

NHTSA ID

11697807

Incident

Oct 31, 2025

The contact owns a 2014 Ford Explorer. The contact stated that while the vehicle was stopped, the vehicle jerked, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle stalled. No warning light was illuminated. The contact was able to restart the vehicle. The contact stated that on a separate occasion, while driving at various speeds, the vehicle jerked and then the engine stalled. After several attempts, the vehicle was restarted. The check engine warning light was illuminated. The contact stated that on a separate occasion, when the contact was able to restart the vehicle, the failure recurred after driving a short distance. The contact stated that the failure persisted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000.

NHTSA ID

11695502

Incident

Oct 24, 2023

Mileage

170,000 mi

Engine stopped working I wanna know if there is a warranty

NHTSA ID

11690130

Incident

Sep 19, 2025

The contact owned a 2014 Ford Explorer. The contact stated that while driving approximately 45 MPH, black smoke started to come from the rear end of the vehicle. The contact pulled to the side of the road and turned off the vehicle. The contact noticed the smoke continued and that black smoke was now coming from underneath the hood of the vehicle. The contact opened the hood of the vehicle and noticed a fire starting near the engine on the driver's side, closer towards the windshield. The fire department arrived and was able to extinguish the fire. The fire diagnosed a mechanical error was the cause of the fire. A police report was filed. The vehicle was towed and deemed totaled. The contact had not sustained any injuries and did not need medical assistance. The dealer was not contacted. The manufacturer was informed of the failure, and a complaint was made. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was approximately 145,000.

NHTSA ID

11678728

Incident

Jun 28, 2025

Mileage

145,000 mi

The contact owns a 2014 Ford Explorer. The contact stated that the vehicle had experienced hard start-ups, and the engine was revving high while idling, with the check engine warning light remaining illuminated. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that the timing chain, crankshaft, and cam shaft sensors were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The local dealer was not contacted. The failure mileage was 84,000.

NHTSA ID

11669263

Incident

May 1, 2025

Mileage

84,000 mi

Noticing a problem with the steering and wheel suspension that is affecting other Ford explorers between 2018 and 2025. Engine oil blow by. Causing oil to leak and ending up under the carriage and on the back of the vehicle. Rear camera problems.

NHTSA ID

11661662

Incident

May 18, 2025

Vehicle has code C0063-64ABS. Also has a problem with the restraint control module and ABS module causing the front tires to lock and make the car slide. I was about to get into a car crash on Oct 24,2024 because the cars front tires locked and just slide from one side to other the steering wheel went loose and I wasn't able to control the car I took it to ford dealership where they told me that it has the code that appears at the beginning of this message

NHTSA ID

11647641

Incident

Oct 24, 2024

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed exhaust Y-pipe. The contact was informed that the exhaust Y-pipe needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 135,000.

NHTSA ID

11637320

Incident

Dec 21, 2024

Mileage

135,000 mi

Making a right turn I was startled by a vehicle running a red light. Front wheel passenger side cleared the curb. Right rear tire jumped the curb jolted back to ground. I looked at tire pressure gauges and no leaks were evident. Being on a single lane road I continued driving looking for a turn in place after traveling about a quarter of a mile an engine rattle developed and there was faint smell of smoke. I traveled another block and turned into a dollar general parking lot. The entrance was on an incline and the car stopped. I had just purchased a new battery a week before and had an oil change about 3 weeks before. The car refused to start. I called triple A and had it towed to dealer. They looked at car and could not come up with a rational reason and doubted car stopped because of violent rear contact with curb at right rear wheel was cause of engine seizing. I called USAA my insurance company their investigating agent agreed. My car is serviced at this dealer and I follow all of the maintenance guidelines I have the records as well as dealer. The car has 125,000 miles and has been well maintained. I am curious if there are any other reports this has happened with 2014 Ford Explorer or any other vehicle. I find it hard to accept such a violent jolt of the running engine did not cause something to fall loose on the running engine. The dealer and appraiser found the car oil full and in pristine condition. There was no frame damage.Turning the crank towards rear they hear metal falling into oil pan. Your thoughts?

NHTSA ID

11626686

Incident

Nov 15, 2024

The contact owns a 2014 Ford Explorer. The contact stated that the front passenger’s side door panel had started to detach from the body of the vehicle. The vehicle was taken to a dealer where the contact was informed that there were no recalls on the VIN and the contact was provided an estimate for the repair. The vehicle was not repaired. The contact stated that while driving at highway speeds, there was an abnormal whining sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where the contact was informed that the rear wheel bearing needed to be replaced. The dealer repaired the vehicle. The contact stated that the check engine warning light later was illuminated. The vehicle was taken back to the dealer where the contact was informed that the catalytic converter needed to be replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The vehicle was not repaired. The failure mileage was approximately 100,000.

NHTSA ID

11617492

Incident

Jan 1, 2021

Mileage

100,000 mi

The contact owns a 2014 Ford Explorer. The contact stated that the security light was illuminated, and the battery was drained. The vehicle was taken to the local dealer, where it was diagnosed that the security panel needed to be replaced. The vehicle was repaired, but the failure recurred. While driving, the lights failed to turn on, and the horn was inoperable. The vehicle was taken back to the local dealer, where it was determined that the electrical system needed to be replaced. The vehicle was repaired. The contact stated that there was no longer a dinging sound when the doors were ajar. The interior lights were dim, and the horn was inoperable. The rubber trim was detaching. The moon roof failed to close. The vehicle was taken back to the local dealer, who determined that water had entered the vehicle through the sunroof and that the wires were wet. The dealer added plastic and glue to the sunroof. Additionally, the vehicle failed to start. There was an abnormal clicking sound while attempting to start the vehicle. The vehicle was taken back to the local dealer, where it was diagnosed that the compressor needed to be replaced because the compressor was clogged. The manufacturer was contacted, who opened a case. The failure mileage was approximately 127,000.

NHTSA ID

11606756

Incident

Jan 17, 2023

Mileage

127,000 mi

VEHICLE ENGINE LIGHT CAME ON. TOOK CAR INTO MECHANIC AND FOUND OUT A CODE POINTS TO A PROBLEM WITH THE TIMING CHAIN/CAM POSITION SENSOR. PRIOR TO THE ENGINE LIGHT COMING ON CAR PREVIOUSLY HAD (2) RANSOM ISSUES THAT NOW AFTER GETTING THE DIAGNOSIS MAKES SENSE WHY THE CAR WAS AT TIMES MAKING A FLUTTER SOUND WHEN STARTING ALONG WITH THE ENGINE RANDOMLY AT TIMES ACTING LIKE TO WAS GOING TO STOP RUNNING WHILE DRIVING THE VEHICLE. I TOLD FORD AND THE MECHANIC ABOUT IT PREVIOUSLY BUT THEY BOTH SAID AS LONG AS THERE'S NO ALARMS KEEP DRIVING IT. THE VEHICLE STILL DRIVES GOOD, BUT I WAS ADVISED NOT TO DRIVE IT UNTIL REPAIRS MADE. THE REPAIR IS $4,000.00 AND PUTTING THAT KIND OF MONEY INTO A VEHICLE THAT IS CURRENTLY VALUED AT $8 TO 10K WITH 136,000 BASED OFF MY RESEARCH IS NOT PRUDENT CONSIDERING OTHER THINGS THAT WILL EVENTUALLY NEED EXPENSIVE REPAIRS. I HAVE TAKEN GOOD CARE OF THE VEHICLE ALONG WITH KEEPING UP ON ALL SERVICES. DISCUSSED WITH A COUPLE EXPERIENCED FORD MECHANICS AND THIS REPAIR IS UNFORTUNATELY VERY COMMON. I BOUGHT THE EXTENDED WARRANTY WHEN THE CAR WAS NEW FOR YOUR INFORMATION. I HOPE FORD CAN STAND BEHIND THIS MECHANICAL FAILURE THAT APPARENTLY IS A KNOW ISSUE AND ACCOMMODATE ME FOR MY LOSS OF EQUITY IN A VEHICLE THAT SHOULD NOT BE HAVING THIS KIND OF WELL KNOWN BREAKDOWN. 1. VEHICLE IS AVAILABLE FOR INSPECTION 2. SAFETY AT RISK WHEN ENGINE LOSES POWER AND ALMOST STOPS RUNNING 3. YES, YESTERDAY I WAS AT THE LOCAL FORD DEALERSHIP MET THERE TOP "HEAVY END" MECHANIC WHO WAS VERY FAMILIAR WITH THE PROBLEM ALONG WITH (2) INDEPENDENT EXPERT MECHANICS FAMILIAR WITH THE DIAGNOSIS. 4. THE MANUFACTURER YESTERDAY SAW THE VEHICLE, AFTER TALKING TO THE HEAD MECHANIC, BASED OFF THE CODE AND SYSTEMS I DECIDED IT WAS NOT PRUDENT TO THROW MONEY AWAY ON GETTING AN OFFICIAL DIAGNOSIS BASED OFF MY COMFORT LEVEL FROM THE DISCUSSIONS WITH THE MECHANICS. 5. YES, THE CHECK ENGINE LIGHT CAME ON AND I HAD THE CAR PROMPTLY INSPECTED BY A MECHANIC.

NHTSA ID

11606159

Incident

Jul 16, 2024

The contact owns a 2014 Ford Explorer. The contact stated while the vehicle was idle, the contact noticed smoke coming out from underneath the passenger's side of the hood. The contact stated upon exiting and inspecting the vehicle, she noticed burning plastic falling from underneath the passenger's side of the vehicle onto the ground, and there was fire. The contact poured water underneath the vehicle and opened the hood and poured water at the fire location. The contact was able to extinguish the fire. There were no injuries sustained. No police report or fire department report was filed. The contact added water to the coolant reservoir and drove to the residence. The vehicle was taken to two independent mechanics, where it was diagnosed that the A/C fan had caught on fire due to a stuck clutch bearing. The mechanics informed the contact that the radiator was damaged and was leaking due to the fire. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

NHTSA ID

11593890

Incident

Jun 9, 2024

Mileage

120,000 mi

The contact owns a 2014 Ford Explorer. The contact stated while approaching a stop light, the vehicle started to lose motive power and stalled. There was no warning light illuminated. The vehicle was able to be restarted, and the vehicle was towed to the residence. The dealer was not contacted; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 105,000.

NHTSA ID

11592084

Incident

Jun 3, 2024

Mileage

105,000 mi

N/A

NHTSA ID

11587968

Incident

Dec 20, 2021

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the camshaft position sensor and the ABS. The vehicle was not repaired. Later, the contact stated that while driving at an undisclosed speed, the temperature gauge began to indicate that the engine was overheating. After a visual inspection of the engine compartment, the contact observed that the coolant level was abnormally low. The vehicle was taken back to an independent mechanic, who determined that coolant was leaking into the engine, resulting in damages to the engine, and advised the contact to take the vehicle to the dealer. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 151,000.

NHTSA ID

11584070

Incident

Apr 15, 2024

Mileage

151,000 mi

Water is leaking from front of engine and into oil from water pump being told it will cost 1600 to over 2000 dollars to fix

NHTSA ID

11580947

Incident

Mar 26, 2024

Fumes are leaking into the cabin of the car. Possibly issues with an exhaust leak that is causing nausea and headaches when driving vehicle.

NHTSA ID

11568934

Incident

May 5, 2023

Car was sitting idle when a fan inside the engine compartment starting being very loud. Sound went away when car started moving. Noticed coolant was empty. Filled with coolant and made a 5 mile trip. Checked again and coolant was empty again.

NHTSA ID

11568342

Incident

Jan 22, 2024

My car keeps running out of coolant yet I’m leaving no puddles anywhere

NHTSA ID

11566621

Incident

Jan 5, 2024

I own a 2014 Ford Explorer. When driving home on November 4th the engine coolant light came on and there was white smoke coming from under the hood and the coolant was leaking under the vehicle. I had the vehicle towed to my local mechanic who said that the water pump needs to be replaced. He does not do this type of work so I'm unsure if there is additional damage since he stopped his inspection there. I have to have it towed to another place. I'm seeing this same issue with many vehicles with the same make/model and felt it should be reported. I did contact Ford and made a complaint.

NHTSA ID

11553784

Incident

Nov 4, 2023

Repeated catalytic converter failure. Issue was repaired at least twice. Converter failure caused both turbos to need replacement and has now caused engine damage. This appears to be a common issue with this engine model.

NHTSA ID

11547912

Incident

Mar 18, 2023

Water pump coolant leak. I’m experiencing this problem and have seen that Fire has known about this issue and hasn’t recalled it and it’s causing engine failure and leaving consumers to fort the 2000 bill to fix since it’s internal. Does needs to recall and fix this issue and replace the pump.

NHTSA ID

11544886

Incident

Sep 10, 2023

The contact owns a 2014 Ford Explorer. The contact stated that while driving approximately 35–40 MPH, the engine was overheating. There was fluid leaking from the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the water pump was leaking. Additionally, antifreeze was leaking from the vehicle. The contact was informed that the timing chain and water pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 113,535.

NHTSA ID

11544250

Incident

Sep 5, 2023

Mileage

113,535 mi