2014 Ford Explorer Steering Problems

Sudden and complete loss of power steering assist while vehicle was in operation. Vehicle became extremely difficult to steer, creating safety hazard for driver and child passenger. Inspection revealed 150A EPAS Mega Fuse, Part #L0114875AA, was melted due to electrical short in Power Steering Control Module. This is identical to the defect described in NHTSA Safety Recall 14V316000 / Ford 14S06. Fire risk confirmed by melted/burned fuse condition. Photos of failed component attached. Component is available for inspection. Ford Customer Service denied assistance under Recall 14S06 on 07/10/2026, claiming vehicle was not covered despite physical evidence of the exact defect described in the recall. Vehicle manufacture date is 06/2014. Ford Technical Service Bulletin 15-0082 acknowledges some 2014 vehicles may still have defective modules installed. Vehicle is currently inoperable. Owner has dependent child with medical therapy appointments requiring reliable transportation. Current mileage approximate as vehicle cannot be driven. Request immediate NHTSA investigation and enforcement under federal safety law 49 USC 30120.

NHTSA ID

11749538

Incident

Jul 10, 2026

While sitting at a stop light, waiting to turn, the steering wheel went stiff, then I was forced to make the turn without the power steering. it started working again but made a very loud grindy noise. the noise has not gone away. I took it to a shop, and they assesed everything, and stated the power steering rack has a fault code, and that the inner tie rods are loose, along with they can hear the power steering rack motor making a lot of noise. while going down the road the steering wheel shakes, and when making turns the steering wheel sticks and I have to yank the wheel back to unstick it. the vehicle is available to be inspected, at any time. I was almost in an accident multiple times due to the steering sticking and the wild vibration in the wheel. please help

NHTSA ID

11743063

Incident

May 16, 2026

My pillar are coming off to the point when it rains water get inside my car. It’s messed up my system in my car. I can’t close my sun roof and water comes down from my lights that’s above my head where you put your sunny sunglasses in. I been calling around and still haven’t got no where.

NHTSA ID

11739722

Incident

Mar 10, 2026

When driving, the steering wheel became less responsive. The next day, we drove a few hundred miles and got gas. After turning the car back on, the steering became even less responsive, resulting in a lot of force being needed to be used in order to turn the vehicle. In addition to this, the car was extremely difficult to keep straight, making driving on a single-lane road extremely dangerous. We have dropped the car off at the dealership and are waiting until Monday or Tuesday for a diagnosis and repair.

NHTSA ID

11739633

Incident

May 22, 2026

Airbag light is activated and controls do not work.

NHTSA ID

11730607

Incident

Jan 8, 2023

The contact owns a 2014 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The power steering warning light was illuminated. The failure had occurred while taking a minor child to school. The vehicle was driven to an independent mechanic to be diagnosed. The vehicle was diagnosed with an electric power steering assembly failure. The vehicle was not repaired. The vehicle was driven to the residence. While driving at an undisclosed speed, several unknown warning lights illuminated. The contact was advised to tow the vehicle to the dealer. The vehicle was towed to the dealer, where it was diagnosed with steering gear assembly failure. The dealer retrieved DTC: U201149, U300049, and U30096. The contact was informed that the steering gear assembly needed to be replaced. The vehicle was not repaired. The contact was informed that the parts had been ordered. The manufacturer was made aware of the failure. The contact referenced an unknown recall; however, the VIN was not associated with the recall. The contact also referenced a Technical Service Bulletin for the failure; however, the age of the vehicle and the mileage limitation had been exceeded. The failure mileage was approximately 131,000.

NHTSA ID

11716311

Incident

Jan 20, 2026

Mileage

131,000 mi

Power Steering stopped working. Error messages shown are "Power Steering Assist Fault" and "Service AdvanceTrac"

NHTSA ID

11713124

Incident

Jan 24, 2026

All my dash lights turn off u can drive it but all my dash light is off the abs light its on

NHTSA ID

11701781

Incident

Apr 24, 2025

The contact owns a 2014 Ford Explorer. The contact stated that while driving approximately 25 MPH and turning to the left, the steering wheel started shaking, and he felt the rear end of the vehicle start sliding to the right. There was no warning light illuminated. The contact stated that the steering wheel was stuck in the direction that it was turned and had to be manually returned to center. The contact stated that the failure was more frequent while turning to the left. and while driving at slower speeds. There was no warning light illuminated. The contact had taken the vehicle to an independent mechanic who diagnosed and determined that the steering gears needed to be regreased. The vehicle was repaired. The contact stated that the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 140,000.

NHTSA ID

11699419

Incident

Jan 12, 2024

Mileage

140,000 mi

Loss of steering. Driving down the road the my completely locks up while in drive. Was told it was faulty rack and pinions.

NHTSA ID

11698841

Incident

Sep 29, 2025

Steering gear failure and faulty eps module. Second event. The full assembly and eps failed, and fatal crash was avoided.

NHTSA ID

11691446

Incident

Sep 29, 2025

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The Electronic Steering Gear failed causing the steering to "stick" at certain points of steering, and causing a loud rubbing noise. The steering is also more "loose" and feels insecure. Yes it is available for inspection. 2. How was your safety or the safety of others put at risk? The failure of the electronic steering gear can cause unexpected failure of steering ability while operating the vehicle. This could cause a severe accident going any speed, but especially if I were on the highway. A crash due to loss of steering ability could kill me, my family, and others on the road. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, my local Ford dealership has confirmed the issue and stated that they won't repair it because it isn't part of any open recall, even though there was a major recall (14S06/NHTSA 14V-286) opened for the prior model year of my vehicle. Ford should have included 2014 in that recall since the issues persists in 2014 models and is evident by the other 200+ Technical Service Bulletins posted by Ford. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It's been inspected by my local Ford dealership. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps or messages. I noticed the issue after picking the vehicle up from the Ford dealership. They didn't notice the issue until I reported it to them, meaning they missed it during their maintenance inspections and check-up. I noticed the issue on September 21, 2025.

NHTSA ID

11690541

Incident

Sep 21, 2025

Lose of controlled of the Steering will driving

NHTSA ID

11685497

Incident

Aug 25, 2025

The contact owns a 2014 Ford Explorer. The contact stated that while driving on the highway at 65 MPH, the power steering assist feature was disabled, and the steering wheel became very difficult to turn. The messages "Service Advance-trac" and "Steering Loss - Stop Safely" were displayed, and the check engine warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not included in a recall related to the failure. The manufacturer was notified of the failure. The approximate failure mileage was 131,590.

NHTSA ID

11678243

Incident

Aug 2, 2025

Mileage

131,590 mi

electric power steering failure while driving

NHTSA ID

11677609

Incident

Jul 31, 2025

While driving on [XXX] in Atlanta, GA, my 2014 Ford Explorer suddenly lost all power steering without warning. The dash displayed: “Steering Assist Fault – Service Required”, and the steering wheel became extremely difficult to turn. I was in the vehicle with my wife and [XXX] daughter, and we were traveling at highway speed. We were extremely lucky to be in the right lane at the time — otherwise, I may not have been able to safely maneuver or exit traffic. This could have easily led to a catastrophic crash. I was barely able to keep control of the vehicle and managed to pull over onto the shoulder. A few days before this incident, I noticed a brief steering warning, but the system reset on its own. After the highway event, I had the vehicle scanned and received the following diagnostic codes: U2011:00-49 and U3000, indicating a Power Steering Control Module (PSCM) failure. This is the same exact failure that led to Recall 14S06 for 2011–2013 Ford Explorers, but my 2014 model is not currently included — despite having the same EPS system and failure pattern. The component is still in the vehicle and available for inspection. I have not yet had it inspected by a Ford dealer or a certified mechanic but intend to do so. I am submitting this complaint to request an investigation and to express my deep concern for the safety of my family and others who may be driving 2014 Explorers with the same defective system. This is a dangerous, recurring problem that demands immediate attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11677030

Incident

Jul 27, 2025

The contact owns a 2014 Ford Explorer. The contact stated that while his wife driving at an undisclosed speed, the electronic power steering was not functioning properly, requiring increased effort to maneuver the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V286000 (Steering), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 135,000.

NHTSA ID

11676186

Incident

Jul 25, 2025

Mileage

135,000 mi

The contact’s daughter owns a 2014 Ford Explorer. The contact stated that while his daughter was driving on the highway at 55 MPH, the steering wheel seized, and the power steering assist was disabled. The contact stated that several unknown warning lights were illuminated. The contact pulled over to the side of the road and turned off and restarted the vehicle however, the power steering assist feature was still inoperable. The vehicle was towed to a local dealer to be diagnosed, and the contact was informed that the rack and pinion was faulty and needed to be replaced. The vehicle was repaired; however, 2 years later the failure reoccurred. The contact stated that while his daughter was driving 35 MPH, the vehicle lost power steering functionality and the steering wheel became stiff. The contact stated that several unknown warning lights were illuminated. The driver pulled over, restarted the vehicle, and the vehicle regained power steering functionality and the warning lights turned off; however, the failure reoccurred. The local dealer was not contacted and the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 129,000.

NHTSA ID

11675117

Incident

Jul 21, 2025

Mileage

129,000 mi

The contact owns a 2014 Ford Explorer. The contact stated that while starting the vehicle, the steering became difficult to turn. The message “Power Steering Assist Fault" was displayed. The vehicle was taken to the dealer to be diagnosed and the contact was informed that an unknown part had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 180,000.

NHTSA ID

11674636

Incident

Jul 16, 2025

Mileage

180,000 mi

My 'Rearview Camera system' does not work. When I put my truck in reverse, I get the message 'Please contact your dealer or manufacturer' for help with camera repair. Back in July 2022, my entire 'Steering system' went out and I was forced to borrow from my 401k to pay $2,000 for a new steering system after it went out on the [XXX] during rush hour from New Orleans to Baton Rouge. I almost got pushed off the spillway by two 18-wheelers that day. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11673965

Incident

Jul 8, 2022

Power Steering Failure Approximate date

NHTSA ID

11672518

Incident

Jun 5, 2024

When turn left or right the steering did not want to turn right away, and when it did it was sudden release.

NHTSA ID

11668192

Incident

Jun 20, 2025

The contact owns a 2014 Ford Explorer. The contact stated while driving 55 MPH, the vehicle was lost power steering functionality. The message "Steering Fault" was displayed. The contact was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the electric power steering gearbox had failed and needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and informed the contact that assistance could not be provided because the vehicle was out of warranty. The failure mileage was approximately 106,000.

NHTSA ID

11667693

Incident

May 16, 2025

Mileage

106,000 mi

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. In addition, the contact stated that the steering wheel was stiff. The vehicle was taken to the dealer where it was diagnosed with rack and pinion failure. The contact was informed that the rack and pinion needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,564.

NHTSA ID

11666145

Incident

May 10, 2025

Mileage

115,564 mi

I was driving my explorer in a residential area when my power steering assist went out, causing me to not be able to control the steering wheel. I had 3 passengers in the vehicle at the time. I came close to crashing into a ditch but was able to stop the vehicle. It terrified me and my passengers. I struggled to steer it to a restaurant parking lot. After my power steering stopped working, and alarm went off on the dash and said "steering assist fault" needs serviced. I had the explorer towed to AschenBach Ford in Wytheville, Virginia. The Ford service department said that the bar and all electrical steering needs replaced. There was a recall for some 2014 Ford Explorers with this same problem but my VIN is not apart of those recalls and I feel it should have been because that's what happened to my vehicle. It's recalls 14S06/14V-286.

NHTSA ID

11663420

Incident

May 24, 2025