2014 Ford F-150 Driver assistance Problems

**VEHICLE SAFETY INCIDENT REPORT & RECALL FAILURE COMPLAINT** **1. COMPONENT FAILURE & INSPECTION** * **System:** 6R80 Transmission Molded Lead Frame Assembly / Output Speed Sensor (OSS). * **Failure:** Intermittent OSS signal loss caused the Powertrain Control Module (PCM) to misread vehicle speed and command an uncommanded, severe downshift from 5th gear directly into 1st gear. * **Inspection Availability:** Vehicle is currently located at the Ford dealership service center and is available for immediate physical and electronic inspection upon request. **2. SAFETY HAZARD & INCIDENT DETAILS** * **Risk:** Severe risk of high-speed rear-end collision, loss of control, and catastrophic injury. * **Incident:** On October 29, 2026, while driving 45 mph on an active highway, the transmission abruptly downshifted to 1st gear without driver input. This caused instantaneous rear-wheel lockup and tires screeching, bringing the truck to a complete halt in live traffic. * **Prior Symptoms:** Following the dealer-mandated software update for Recall 24S37 / 24V444, the truck experienced 5 documented transmission dropouts (5th to 1st gear) with an illuminated Wrench / Service Engine Light. **3. RECALL FAILURE & REMEDY DISPUTE** * **Recall Involved:** Recall 24S37 / NHTSA 24V444 (Issue Date: June 14, 2024 - 6R80 Sudden Transmission Downshift PCM Reprogramming). * **Defect/Failure:** The dealership completed Recall 24S37 (PCM software reflash). However, the software fix failed to eliminate the hazard, resulting in full rear-wheel lockup at 45 mph. * **Current Status:** The servicing dealer confirmed the lead frame must be replaced, but refuses recall/warranty coverage and is forcing out-of-pocket payment because diagnostic trouble codes were not active during the initial software flash months ago. The software remedy failed to remediate the unsafe condition, and hardware replacement is required to restore vehicle safety.

NHTSA ID

11774715

Incident

Oct 29, 2026

I own a 2014 Ford F-150 equipped with the 6R80 six-speed automatic transmission (VIN: [XXX]), currently at approximately 133,000 miles. On XXX, while driving at ~70 mph on [XXX], my truck experienced an abrupt, unintended downshift — the precise failure mode described in Recall 24S37. The software patch prevented it from making it worse and a orange wrench came across the dashboard, but still it required some evasive maneuvering. I proceeded directly to the dealer to investigate; however, they were booked for the day. Not understanding the full impact I left to come back in the morning. The vehicle eventually became unsafe to operate, would not start, and had to be towed to Gullo Ford. The dealer then pulled diagnostic trouble codes, confirmed the transmission lead frame had failed, and replaced the lead frame at my expense of $1,977.04 (2127.04 with a coupon of 10% off) (invoice and repairs completed enclosed). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11770903

Incident

Oct 7, 2026

My 2014 Ford F-150 was previously included in Ford Safety Recall 24S37 regarding unintended transmission downshifts caused by an intermittent Output Shaft Speed (OSS) sensor issue. The vehicle was inspected by a Ford mobile technician on January 20, 2026. No qualifying codes were found at that time, and the recall was closed under my VIN. The recall involved the risk of an unintended downshift into first gear that could result in loss of vehicle control. On August 20, 2026, while my husband was driving approximately 40-50 mph, the truck suddenly downshifted and rapidly lost speed. The vehicle would not accelerate beyond approximately 10-15 mph and had to be moved into a parking lot to avoid remaining in traffic. After parking, the truck would no longer move under its own power. The wrench warning light illuminated and the vehicle became undrivable. The symptoms experienced appear substantially similar to those described in Recall 24S37. The dealership has indicated that the current failure may involve the transmission lead frame and speed sensor system, but I am concerned that this event may be related to the same transmission downshift condition addressed by the recall. I am requesting that NHTSA document and review this incident.

NHTSA ID

11758660

Incident

Aug 20, 2026

I was driving on the highway at about 60-70 mph and my truck shifted into first gear with my tires basically locking up and slid along the highway. I brought my truck into a ford dealership and they told me they couldn’t get it to replicate the incident so they turned me away. I personally replaced my battery terminals and it hasn’t done it again. Now I will be driving and randomly my truck will rev bomb and my gauge cluster will shut off and it shows up with an orange wrench symbol but when I turn the car off it resets. The research I’ve done it can come from a speed sensor or the lead frame. I know 2014 fords have a recall on transmissions but my truck does not have a documented one but there is something funky going on with it.

NHTSA ID

11752915

Incident

May 3, 2026

On July 2, 2026, the vehicle was brought to an authorized dealer for a scheduled appointment to resolve active Safety Recall 26S45 / NHTSA Campaign 26V378 (6R80 transmission sudden downshift defect). The dealership refused to perform the recall software update, claiming it was not needed for the vehicle. On July 12, 2026, while traveling at highway speeds on a public highway, the transmission suffered the exact un-commanded sudden downshift described in the recall. The violent mechanical force instantly snapped the rear driveshaft in half and severed the undercarriage air conditioning lines, creating a sudden, life-threatening loss of control and wheel speed reduction on a live highway. The vehicle is now permanently disabled due to the dealer's refusal to fulfill a federal safety mandate.

NHTSA ID

11750595

Incident

Jul 12, 2026

I am the owner of a 2014 Ford F-150 that is experiencing sudden, unexpected downshifts into a lower gear while driving at highway speed. This has happened on multiple occasions and has nearly caused accidents, including loss of vehicle control momentarily. This defect matches the description of Ford safety recall 26S45 (loss of signal between the transmission output shaft speed sensor and the powertrain control module, causing unexpected downshift into first gear). Despite this, my vehicle was not included when I checked recall status, even though I have an open Ford claim number: Cxh-08412521-F6L5j4. I am filing this complaint to ensure this incident is on record given the ongoing safety risk, and to request that NHTSA confirm whether my VIN should be captured under recall 26S45 or a related campaign (24S37/24V444). Description: Transmission suddenly and dramatically downshifts at highway speed without warning, causing loss of vehicle control and near-accidents.

NHTSA ID

11750426

Incident

Jul 13, 2026

Hello, I recently brought my 2014 Ford F-150 (VIN: [XXX]) to the dealership regarding Recall 24S37. The vehicle experienced the following symptoms: • Check Engine Light illuminated. • Wrench Light illuminated. • Intermittent loss of power. • Abnormal transmission behavior. • Intermittent no-start condition. • Vehicle would only start after moving the gear selector. The dealership informed me that no physical repairs would be performed because the diagnostic trouble codes retrieved were different from those associated with Recall 24S37. However, the vehicle continues to exhibit transmission-related symptoms, and I am concerned that the underlying condition may be related to or aggravated by the conditions addressed in Recall 24S37. I am requesting that Ford review this case and determine whether additional diagnostic evaluation or repairs should be considered. However, they refuse to accept that the codes have anything to do with the recall, even though it is the same part and the affected sensor that is triggering the error codes on the scanner. They are asking me to pay for the transmission repair because the codes are not the ones approved for the recall, but based on the signs and symptoms the truck is showing, it is a chain reaction that triggered the previously mentioned failures. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11746012

Incident

Jun 23, 2026

My 2014 Ford F-150 is exhibiting symptoms consistent with the Ford transmission molded lead frame safety recall 24S37. While driving approximately 55 mph late at night on a five-lane roadway, the vehicle suddenly and violently jerked, downshifted and came to a complete stop becoming stalled out as I was approaching a major traffic intersection. The truck was disabled in traffic and would not restart for approximately 2-3 minutes, leaving me stranded in an active travel lane and at risk of being struck from behind by another vehicle at high speed. The vehicle has displayed transmission-related symptoms including inability to correctly indicate gear position, harsh shifting, unexpected downshifts into 1st gear while driving, transmission fault warnings, and check engine lights. Initially it was mostly dying while idling and we thought it was the common "Fuse 27" issue, being unaware of the recall. Then the condition reproduced multiple times and symptoms worsened dramatically. Ford dealership inspected the vehicle. According to the technician's written report, the truck was found to be "having transmission problems, unable see what gear the truck is in and shifts to 1st gear while driving" and recommended replacement of the molded lead frame. The dealership confirmed transmission-related diagnostic trouble codes were present and documented symptoms consistent with lead frame failure. Despite the recommendation of the lead frame replacement and documenting symptoms consistent with the safety recall, the repair was not approved. The vehicle continues to experience symptoms associated with the recalled defect and is unsafe to drive away. Dealership confirms software update will not correct problem. I am submitting this complaint as the transmission defect poses a significant safety hazard to me, my children, and other drivers due to unexpected downshifts, loss of power, stalling, and the risk of becoming disabled in traffic. The truck remains available to inspect

NHTSA ID

11743580

Incident

May 10, 2026

I have had the 24S37 recall applied to my truck it was a software update, after the update it was ok for about a month then the problem became worse than it was before the software update. My truck is now downshifting and locking up the rear wheels and dose not shift sometimes and skips gears. This problem is getting worse everyday. I talked to the Ford dealership by my house and they told me I needed to buy a new transmission from them and there was no remedy for my problem other than the new transmission. I noticed the are recalling the 2015 trucks with the same transmission problem. Will my truck be added to the recall ? I have the same transmission

NHTSA ID

11735892

Incident

May 4, 2026

It was Tuesday 04/14 I had just left a store. Drove to the corner stop sign and applied the breaks which have always been just fine, easy to stop and slow. Until thst day I eased on the breaks and all of a sudden the peddle went to the floor. I came home and called my mechanic shop. They told me to bring it in. When I did they told me the master cylinder had gone out and was leaking all into the booster. They felt it was unsafe for me to drive it. They gave me a loaner vehicle. Upon returning to my home that's when I saw all the break fluid running down my driveway where I had parked when I got home from the store the day prior. Which I hadn't noticed before. So, now I'm without my vehicle because I simply can't afford a $900 repair bill. I've looked it up and on your website it shows in 2025 there was a recall on the 2014 Ford F-150 that named the master cylinder as a problem. It also stated that on Google. Please help.

NHTSA ID

11732148

Incident

Apr 14, 2026

Two separate times, driving at highway speed, the truck shifted into first gear and I had to pull over. A wrench symbol also popped up where the speed is usually displayed.

NHTSA ID

11721932

Incident

Mar 3, 2026

My truck’s brakes failed unexpectedly. I know there’s been a recall on similar year and engine models for brake issues. Even though my VIN isn’t showing an open recall, I’d like this inspected because the failure feels identical to the recall problem.

NHTSA ID

11721345

Incident

Feb 28, 2026

NHTSA Investigation PE24010 (or related transmission downshift probes.. Safety Risk: the vehicle unexpectedly downshifts and locks rear wheels, creating an immediate life-threatening risk on the highway. Dealer Response: dealer claimed their "computer doesn't pick up anything," as this helps investigators understand that the diagnostic tools are failing to detect the fault. VIN Number: [XXX] Dealer Record: that Grieco Ford performed the recall update and that the issue persists. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11716515

Incident

Jan 7, 2026

The contact owns a 2014 Ford F-150. The contact stated that while shifting into reverse or drive, the vehicle seemed to be in neutral and failed to move. The vehicle failed to shift into gear. The wrench symbol was displayed. After resetting the codes, there was an abnormal squealing sound. The engine light was illuminated. The vehicle went into safe mode. The contact stated that the vehicle was taken to the local dealer and the contact was informed that a diagnostic test was needed. The vehicle was not diagnosed or repaired. The vehicle was previously reprogrammed under NHTSA Campaign Number: 24V444000 (Power Train). The manufacturer was contacted and was referred to the local dealer for assistance. The failure mileage was approximately 220,288.

NHTSA ID

11712471

Incident

Jan 16, 2026

Mileage

220,288 mi

I need to open a safety case. My 2014 Ford F-150 had recall 24S37 performed. Immediately after the recall, the steering locked, the truck stopped itself while still in Drive, and a blue oil pressure warning light appeared. The vehicle is unsafe and cannot be driven out of my driveway. The dealership is refusing responsibility and wants to charge diagnostics. I need this inspected and towed under recall responsibility.”

NHTSA ID

11708415

Incident

Dec 3, 2025

Back up camera and warning stop not working while backing up. Most F150 pick ups are in the recall but mine is not for some reason even though it fails almost every time I back up. There is many children using the side walks in my neighbor hood creating a serious situation.

NHTSA ID

11694694

Incident

Oct 21, 2025

The contact owns a 2014 Ford F-150. The contact stated that while reversing, the rearview camera image was blank, distorted, or flipped to the opposite side. The driver was concerned about crashing. The contact shifted to park and back to reverse several times, but the camera was still inoperable. There were no warning lights illuminated. The local dealer was contacted and informed the contact to purchase a new camera. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

NHTSA ID

11691221

Incident

Oct 3, 2024

Mileage

120,000 mi

Our 2014 Ford F150 is doing the same back-up camera distortions as the current recall and the Ford dealer says it's our problem. The back-up camera on lots of other Ford models need to be recalled.

NHTSA ID

11687465

Incident

Nov 1, 2023

Backup camera started out intermittent loss of image some times distorted now no image. Filed a complaint with Ford Motor. Case number is: [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11686919

Incident

Jul 22, 2025

The contact owns a 2014 Ford F-150. The contact stated that while reversing, the back over prevention camera screen was solid black, and there was no rear image displayed. Occasionally, the image was distorted and undistinguishable. The contact stated that the failure was intermittent. The cause of the failure was not yet determined. The manufacturer was contacted, but no assistance was offered. The local dealer was not yet been contacted. The failure mileage was 145,000.

NHTSA ID

11686334

Incident

May 10, 2025

Mileage

145,000 mi

Vehicle Information: 2014 Ford F-150 VIN [XXX] Transmission: 6R80 Description of the problem: My 2014 Ford F-150 has a dangerous transmission issue. It suddenly downshifts from higher gears (like 4th or 5th) into 1st gear while driving, without warning. This creates a serious risk of loss of control or rear-end collision. Ford performed the recall for the 6R80 PCM reprogramming, but the issue persists. The problem was not resolved, and the vehicle still downshifts abruptly. My vehicle has over 200,000 miles, so the extended warranty for the lead frame (program 19N01) no longer applies, but this is a serious safety defect that continues after the recall. I’m requesting that the NHTSA investigate this issue, as it seems the recall fix is not effective in all cases. Many other owners report similar symptoms even after the recall. Safety concern: I feel unsafe driving this vehicle. The transmission can cause a sudden deceleration in traffic, and I fear it may lead to an accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11677119

Incident

Jul 29, 2025

Ford supposedly repaired my truck via recall 24S37 on June 6 2025. However, while driving at approx 65 mph 2 days later, my truck downshifted again to first gear. This went on for another 2 weeks until I took it back to Crossroads Ford in Henderson NC again and they notated that I have a code P1500 AND CODE p0722 WHICH IS A LEAD FRAME IN TRANSMISSION ISSUE but they did not repair it..AGAIN. It is currently at the same dealership and they called me from Dearborn MI to inform me that I am not covered. It is a 2014 with 308,000 miles. I am relegated to driving 30 mph if I am to drive it as shifting down is unsafe. The issue is that it is a Ford defect even if I am at 308k and they refuse to rectify my issue so that my family can ride safely. SUMMARY FROM CROSSROADS FORD IN HENDERSON READS OSS SENSOR CIRCUIT FAULT CODE P0722, P1500...POSSIBLE LEAS FRAME TRANSMISSION.....I AM FULLY AWARE A RECALL REPAIR CARRIES WITH IT AT LEAST A 1 YEAR WARRANTY.

NHTSA ID

11672880

Incident

May 15, 2025

BACKUP CAMERA ONLY WORKS INTERMITTENTLY. MOST OF THE TIME THE DISPLAY JUST SAYS "REAR CAMERA UNAVAILABLE," SOMETIMES JUST A BLUE SCREEN, AND OCCASIONALLY WILL DISPLAY THE IMAGE BRIEFLY, THEN GO BLUESCREEN/CAMERA UNAVAILABLE. TURNING IGNITION OFF, THEN RESTARTING MAY RESET CAMERA AND BRIEFLY DISPLAY THE IMAGE, THEN BLUESCREEN/UNAVAILABLE AGAIN.

NHTSA ID

11669505

Incident

Jan 22, 2021

The contact owns a 2014 Ford F-150. The contact stated that while in reverse(R), the screen was black or displayed a blue screen. The failure impeded the driver's visibility, preventing the driver from safely operating the vehicle. The message "Rearview Camera Unavailable" was displayed during the failure. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The contact related the failure to NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the VIN was not included. The failure mileage was approximately 195,000.

NHTSA ID

11666846

Incident

Jan 13, 2025

Mileage

195,000 mi

The contact owns a 2014 Ford F-150. The contact stated that while in reverse, the back over prevention camera displayed orange and green lines across the screen. The screen was flashing on and off. The dealer was contacted and informed of the failure. The message advising the contact to take the vehicle to the dealer was displayed on the screen. The contact related the failure to NHTSA Campaign Number: 25V315000 (Back Over Prevention). The dealer advised the contact to take the vehicle to be diagnosed and confirmed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.

NHTSA ID

11663873

Incident

Apr 30, 2025

Mileage

200,000 mi