2014 Ford F-150 Engine Problems

I was driving on the highway at about 60-70 mph and my truck shifted into first gear with my tires basically locking up and slid along the highway. I brought my truck into a ford dealership and they told me they couldn’t get it to replicate the incident so they turned me away. I personally replaced my battery terminals and it hasn’t done it again. Now I will be driving and randomly my truck will rev bomb and my gauge cluster will shut off and it shows up with an orange wrench symbol but when I turn the car off it resets. The research I’ve done it can come from a speed sensor or the lead frame. I know 2014 fords have a recall on transmissions but my truck does not have a documented one but there is something funky going on with it.

NHTSA ID

11752915

Incident

May 3, 2026

While driving, transmission will randomly shift gears from a higher gear all the way down to first gear regardless of travel speed. When traveling at highway speeds, this results in a loss of traction on the rear wheels, causing fishtailing and a momentary loss of control. This problem is getting worse, and is the result of a known defect in the transmission speed sensor that has been acknowledged by Ford in previous recalls. The previous recall repair attempt by Ford involved a dealer reset of the computer rather than replacing the defective sensor, which did not fix the problem. The frequency of this sudden downshift is approximately 2-4 times per ten miles driven.

NHTSA ID

11737753

Incident

May 14, 2026

My 2014 Ford F150 truck went into “limp mode” last week. A wrench showed up on my dashboard, my speedometer didn’t function, and it sounded like the transmission was “winding up” if I tried to accelerate. After hitting “ok” to remove the wrench and restarting the truck a couple of times, my check engine light illuminated. I was driving at about 40 MPH when this occurred and it was a scary moment. Luckily I was able to keep my truck under control and drove very slowly back home considering I was less than 4 miles from my home. The truck went into a Ford dealership in 2024 for the “transmission recall” in which the only thing I noticed different was that I couldn’t see the digital shifting of the transmission on the screen anymore and they “killed” my battery. I still had issues every so often with power loss or the transmission shifting down abruptly, but it wouldn’t throw a code. Last week it threw a code. P0720 to be exact, the reason for the transmission recall in the first place. There was no fix done with the recall and it made it so that I had to watch my RPM’s to track my transmission shifting. This is extremely concerning especially since I was having the issues prior to a computer reprogram and it wasn’t addressed. I have also seen that there’s yet another Ford transmission recall that could affect my truck considering it was assembled in June 2014 and fits the transmission 6R80 that needs fixed. Could someone please help? Thank you.

NHTSA ID

11735821

Incident

Apr 30, 2026

Na

NHTSA ID

11730611

Incident

Apr 1, 2026

Two separate times, driving at highway speed, the truck shifted into first gear and I had to pull over. A wrench symbol also popped up where the speed is usually displayed.

NHTSA ID

11721932

Incident

Mar 3, 2026

My 2014 f150 xlt Ecoboost 4x,4 was experiencing symptoms directly related to Recall 24S37 / 24V444 (erratic/harsh shifting while on the highway). P0606, P0607 (PCM Processor Faults) P0706, P0707 (Transmission Range Sensor issues) P1702-00 (TRS Circuit Intermittent) P1921-00 (Transmission Range Signal issues) This was following the software update in the last recall. Plus the truck would not start despite a brand new battery. I purchased a new lead frame and was told by Ford to take it to Conklin Automotive in Newton Ks so I had it towed Jan 7th. My truck is still there. They replaced the lead frame but released it to me without a diagnosis, without replacing transmission fluid due to a stripped dipstick they were unable to remove, without trying the many options for removal or refilling it and without checking to see if the lead frame fixed the main issue. I had said from the beginning they needed to check the neutral safety switch and fuses. Finally by end of Jan he checked and found a corroded fuse and the truck started but because of refusal to refill the fluid they didn't check the lead frame. So I have had to rent cars for a month resulting in financial distress and return the truck to a different shop to be fixed. Ford refuses to honor the recall even tho it was extended to my year and model of truck, and refuses to help because Conklin, where they told me to go, is not an authorized dealership. I've attached all the correspondence with them and Ford.

NHTSA ID

11715240

Incident

Jan 6, 2026

The contact owns a 2014 Ford F-150. The contact stated that while shifting into reverse or drive, the vehicle seemed to be in neutral and failed to move. The vehicle failed to shift into gear. The wrench symbol was displayed. After resetting the codes, there was an abnormal squealing sound. The engine light was illuminated. The vehicle went into safe mode. The contact stated that the vehicle was taken to the local dealer and the contact was informed that a diagnostic test was needed. The vehicle was not diagnosed or repaired. The vehicle was previously reprogrammed under NHTSA Campaign Number: 24V444000 (Power Train). The manufacturer was contacted and was referred to the local dealer for assistance. The failure mileage was approximately 220,288.

NHTSA ID

11712471

Incident

Jan 16, 2026

Mileage

220,288 mi

Ford Recall #24S37. 2014 Ford F150 Transmission Module(6R80). My vehicle downshift while driving and the dashboard lights and speedometer stops working. I notified the Ford Dealership (Capital Ford of Wilmington, NC, and they scheduled an appointment for Feb. 202i6. However, my check light came on, so took my truck to Delaney Tire and Auto, Wilmington, NC. The problem got so bad (daily) I had to have it repaired. Delaney replaced the module for $2,956.47. I am asking Ford to reimburse me the $2,956.47. I have the invoice a repair order.

NHTSA ID

11711056

Incident

Aug 22, 2025

I need to open a safety case. My 2014 Ford F-150 had recall 24S37 performed. Immediately after the recall, the steering locked, the truck stopped itself while still in Drive, and a blue oil pressure warning light appeared. The vehicle is unsafe and cannot be driven out of my driveway. The dealership is refusing responsibility and wants to charge diagnostics. I need this inspected and towed under recall responsibility.”

NHTSA ID

11708415

Incident

Dec 3, 2025

Coil packs need constant changing in this vehicle. I’ve owned it almost 8 years and sometimes I would have to change the coil packs more than 1 time a year. Obviously I would change the spark plugs also. But there is always a misfire. A lot with 3 and 5.

NHTSA ID

11706502

Incident

Apr 1, 2018

The contact owns a 2014 Ford F-150. The contact stated that while depressing the accelerator pedal after being stopped or while idling, the “Low Oil” warning light would illuminate, and the gauges would fall to zero. The failure was intermittent. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.

NHTSA ID

11701900

Incident

Nov 26, 2025

When driving the vehicle will drop down into a lower gear such as first gear causing the tires to lock up while going into the lower gear, throwing your body in the truck forward causing whiplash and sending my vehicle into other lanes or oncoming traffic. There's a loyd bang when it happens and the engine vibrates so bad when you accelerate it feels like the engine is gonna fall out. They said there's no recall for my vehicle by Vin number but if you put the model in the search registry then 7 recalls come up. Why is my model excluded from this? This is highly dangerous and can kill me or other people on these roads. Ithappens daily. I had just bought it 2 months ago and it happend the same day I bought it and every day since.

NHTSA ID

11698771

Incident

Sep 14, 2025

Front Engine cover leaking. I have had this issue twice with the same truck two separate engines. I bought my truck used and it was leaking oil. I took it to the dealership and they diagnosed it as the front engine cover leaking. Then before the dealership could get it in to be repaired it started having problems with the timing components. All the problems were supposedly fixed but then about 5 months later the engine failed due to a camshaft failure and I was told this was due to lack of oil. The truck was not even due for an oil change after the dealership had done the repairs. I saved up and bought a brand new engine purchased April 25, 2025. I had the Ford dealership do the first oil change on the new engine and then it started leaking. I took it back and it was determined that it was leaking from the front engine cover, the same as the old engine which I pointed out to the dealership and they informed me that Ford is aware of the problem but there are not any recalls for this. The new engine is under warranty as it isn't even 6 months old and doesn't even have 5000 miles on it.

NHTSA ID

11689992

Incident

Sep 19, 2025

After receiving a call from Mullinax Ford in Mobile, AL regarding a recall for our 2014 Ford F-150 Raptor (recall related to unexpected downshifting), I brought the vehicle to my workplace on [XXX], where a technician performed the software update (flash) on-site. Before the update, the vehicle was functioning without issue. That same evening while driving home, I experienced extremely hard downshifting, initially in lower gears, and worsening over time. The truck now violently downshifts, primarily into 4th gear, and sounds as if the transmission is slipping. I drove the truck again the next morning and the symptoms persisted. I contacted Zachary, the original representative at the dealership, who said it may be part of the “relearning” process. My husband drove it a week later after returning from a business trip and he confirmed the issue. It has progressively worsened to the point of being undrivable. We returned the truck to Mullinax Ford for evaluation on 7/29/25, and they claimed the failure was unrelated to the update and that the transmission needed to be replaced, at our expense. The truck unpredictably drops gears at high speeds, creating a sudden jerk that could lead to loss of control. This poses a serious safety risk to both the driver and others on the road. The dealership performed the recall software update and later diagnosed the truck with transmission failure, but is denying responsibility. No other third-party inspections have been done at this time. There were no warning lights or issues prior to the update. The issue started immediately after the recall software was flashed and worsened over the next 24–48 hours. The vehicle is currently at the dealership and available for inspection. We believe the issue stems directly from the PCM/TCM update applied under recall conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11677003

Incident

Jul 9, 2025

The contact owns a 2014 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted with the check engine warning light illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 207,600.

NHTSA ID

11676979

Incident

Jul 29, 2025

Mileage

207,600 mi

The contact owns a 2014 Ford F-150. The contact stated that upon leaving the grocery store and attempting to start the vehicle, the vehicle failed to start while the engine was continuously turning over. There was no warning light illuminated. The vehicle was towed to the residence, and the contact replaced the fuse, and the vehicle was able to start. The local dealer was not contacted, and the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 190,000.

NHTSA ID

11670766

Incident

Jul 1, 2025

Mileage

190,000 mi

Cam phasers yes engine could blow up cause to lose control of my vehicle yes by a ford dealer no no warning lamp or message rattle at cool startup

NHTSA ID

11670760

Incident

May 28, 2025

The contact owns a 2014 Ford F-150. The contact stated that while driving at approximately 35 MPH and exiting the gas station, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle jerked and then stalled. The check engine warning light was intermittently illuminated. The contact was able to coast to the side of the road. The vehicle was restarted; however, the failure persisted. The vehicle was taken to a dealer where it was diagnosed and determined that the timing chain was stretched and needed to be replaced. The vehicle was not repaired. The contact stated that three months prior to the failure, the heater on the vehicle failed to operate as intended. The heater was repaired. The contact also stated that several weeks later, the backlight failed to operate as intended. The vehicle was taken to the dealer where it was diagnosed that the socket had corroded. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 178,000.

NHTSA ID

11662342

Incident

Oct 21, 2024

Mileage

178,000 mi

Truck randomly downshifts/ jerks really hard while driving all speeds. On 4/19 I was driving 65mph and truck felt like slamming brakes on, while speedometer pin bounces around, then a wrench showed up on the dash screen, I pulled over turned truck off sat for a few minutes, turned it back on, everything seemed finer and continued driving home, with no more issues. On 4/27 I was coming home from groccery store going about 30-35mph truck dropped down to first gear and then back to 4th gear. My pregnant wife and daughter were in the car when this happened. I've called local Ford dealership, and they ask me to come in for diagnosis, but I know this is a factory recall issue via 24V-444. I'm not sure if the truck is safe to drive, this randomly happens, but seems to be happening more and more frequently past 2 months or so

NHTSA ID

11657079

Incident

Apr 19, 2025

The contact owns a 2014 Ford F-150. The contact stated that while the vehicle was parked and idling, the vehicle inadvertently lost motive power and was unable to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the timing chain tensioner, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 86,000.

NHTSA ID

11655302

Incident

Apr 17, 2025

Mileage

86,000 mi

Fuse 27, a known problem with the 12th generation F150, manufactured from 2009-2014, burned through in my truck melting the fuse block in the process. The fuse block in question is the main fuse block located toward the front of the engine bay near the radiator. This resulted in a no start condition while parked in a parking lot. I was required to purchase Ford’s repair kit for their engineering problem and relocate the fuse to a new spot in the fuse block. If this had happened while driving, I fear my truck could have resulted in an electrical fire with my family inside. Please consider requiring Ford to issue a safety recall for this incredibly dangerous situation.

NHTSA ID

11650479

Incident

Jul 20, 2024

Ford Motor Company issued a recall for my truck (the transmission could suddenly shift into neutral), stating that they needed to update the PCM, and my local dealership service center said they could send an employee out to fix it remotely. I had not experienced the shifting into neutral prior to the "fix". Less than a week later, as I was driving around 35mph, the speedometer dropped to 0 and the transmission stuck in 3rd gear. I waited until the next stop sign and turned off the engine and started it again and it went back to normal. The next day the same issue occurred. The speedometer would drop to 0 and the transmission would stick in whichever gear it was last in. This time is was 5th gear on a highway. I had to pull over and restart it 3 times before it resumed normal driving. I went back to the dealership and they said the electronic update wouldn't have caused the OSS to malfunction and that it was a coincidence that the exact issue I was having was the same as the cause and reason for the recall. I went to an independent Transmission mechanic to have the OSS replaced and it has now been over a month and the problem has not returned. I don't know if the cause of the OSS malfunctioning was a coincidence or if it was related to a faulty electronic update (like if the Ford mechanic didn't disconnect the battery or overloaded an electric charge when he updated the PCM). The warning sign of a wrench did appear each time the OSS would drop to 0. The check engine light went on the first time but not after that.

NHTSA ID

11650330

Incident

Jan 25, 2025

Warning light is staying on stating the engine is out of time. We have had the vehicle assessed by a licensed mechanic to obtain this information. No issues have been detected other than the light coming on and the mechanic pricing the repairs.

NHTSA ID

11650059

Incident

Mar 24, 2025

Engine light but no issue

NHTSA ID

11633764

Incident

Jan 2, 2025

I was instructed to take my truck in for a recall of a sudden downshift issue with the transmissions molded leaf frame. I had told the ford representative that i was experiencing similar symptoms with my vehicle. and some symptoms that were even of even greater risks to me where when coming to a complete stop my vehicle would fail to gain proper speed facing oncoming traffic!! Also i had told the representative that due to those issues i also had the computer re-programmed previously to try to resolve the issue before becoming aware of the recall... i also had purchased an engine and transmission harness from a ford dealer prior to the recall as well, All for which i have not been re-compensated for..after becoming aware of the recall did i understand that the issue lied in the transmissions molded leaf frame which has not been repaired...no actions were taken to remedy my vehicle and i was upset and unsatisfied with the entire process!

NHTSA ID

11632858

Incident

Sep 13, 2024