2019 Ford F-350 Sd Problems

A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go straight down the road in order to fix it you have to replace the entire steering wheel which is about 3,400 or so.

The contact owns a 2019 Ford F-350. The contact stated that on three occasions while driving approximately 60 MPH, the front end of the vehicle started to wobble violently. The contact stated that when the brake pedal was depressed and the vehicle decelerated below 30 MPH, the wobbling ceased. The contact stated that there were no warning lights illuminated. The contact’s wife observed an unknown recall that might be associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

The contact owns a 2019 Ford F-350. The contact stated that on three occasions while driving approximately 60 MPH, the front end of the vehicle started to wobble violently. The contact stated that when the brake pedal was depressed and the vehicle decelerated below 30 MPH, the wobbling ceased. The contact stated that there were no warning lights illuminated. The contact’s wife observed an unknown recall that might be associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

The contact owns a 2019 Ford F-350. The contact stated that while driving on the highway at 75 MPH, the vehicle started shaking violently. There was no warning light illuminated. The contact pulled over to inspect the vehicle; however, the contact found no fault with the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not under recall. The manufacturer was notified of the failure. The approximate failure mileage was 66,500.

The contact owned a 2019 Ford F-350 hauling a small trailer with 2 horses. The contact stated that while driving at approximately 60 mph, another driver waved him down and informed him there was a fire from the front of the vehicle. The contact merged to the side of the road, parked, and exited immediately. The contact attempted to open the hood but was unsuccessful in doing so as the hood had become too hot to touch from the fire brewing inside. The contacts stated that he and his wife who was the front passenger occupant were able to unload their horses from the trailer just in time, as the entire truck engulfed in flames all within ten minutes. The origin of the fire was undetermined. No injuries were sustained. The location of the fire was the front of the vehicle. The fire department arrived to extinguish the fire. A fire department report was filed. A police department report was filed. The vehicle was destroyed. The remains of the vehicle were towed to a local towing company's lot. The local dealer was contacted. The manufacturer was not notified of the failure. The approximate failure mileage was 19,000.

The contact owns a 2019 Ford F-350. The contact stated that while the vehicle was parked, it was discovered that the air pressure in all four tires were consistently decreasing; the contact also noticed corrosion around the rims and valve stems on each wheel. The low tire pressure warning light was illuminated. The vehicle was driven to a dealer but not diagnosed; however, the contact was informed that the dealer would replace the current tires with new tires to monitor the failure. The vehicle was repaired; however, the failure reoccurred. The contact was constantly adding air to the tires before driving the vehicle. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 25,000.

A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go straight down the road in order to fix it you have to replace the entire steering wheel which is about 3,400 or so.

My rearview camera is showing a distorted image and then goes blank while in reverse creating a safety issue while backing up. The camera is doing everything listed in the following recall campaigns: 20C19/22V252 20C19/24V188 20C19/20V575 but Ford says my truck does not qualify for the recall because my VIN is not listed in the recall.

The contact owns a 2019 Ford F-350. The contact stated while the vehicle was in the automatic car wash, water entered the vehicle from the front windshield. The water leaked into the fuse box and short-circuited the fuse box. The vehicle was towed to the dealer where it was determined that the seal around the windshield needed to be resealed and the fuse box replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 70 MPH, the vehicle abruptly came to a complete stop. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed and determined that the transmission had failed. The vehicle was repaired, but the failure reoccurred 2 additional times. The dealer diagnosed that the clutch plate failed and gear 1 and gear 2 were heat-welded together. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.

Interior cabin Air Conditioning Unit leaks water inside the cab area. Water leaks below the passenger dash area, creating mold to the carpet and flooring. Water damage caused to the inside of the vehicle on multiple areas around the passenger front side inside the cabin.

The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

This model has the same Bosh CP4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20K pounds. The safety concern for this year is the same or greater then newer models.

The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change in line with the manufactured guidelines. When looking on line this is a major problem with the fuel line and under hood filters causing fires. This needs a repair before more people are hurt

My back up camera is not working.

The contact owns a 2019 Ford F-350. The contact stated while the vehicle was in the automatic car wash, water entered the vehicle from the front windshield. The water leaked into the fuse box and short-circuited the fuse box. The vehicle was towed to the dealer where it was determined that the seal around the windshield needed to be resealed and the fuse box replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 70 MPH, the vehicle abruptly came to a complete stop. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed and determined that the transmission had failed. The vehicle was repaired, but the failure reoccurred 2 additional times. The dealer diagnosed that the clutch plate failed and gear 1 and gear 2 were heat-welded together. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.

The contact owns a 2019 Ford F-350 SD. The contact stated that while the vehicle was parked, her husband attempted to turn the key in the ignition, but the vehicle failed to operate as intended. The messages "Service Advanced Trac", "Oil Change Required", and "Hill Start Assist" were displayed. The ABS and check engine warning lights were illuminated. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000.

The contact owns a 2019 Ford F-350 SD. The contact stated that while driving at an undisclosed speed, the contact became aware that the transmission was slipping. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with torque converter failure. The contact was informed that the transmission needed to be replaced. The vehicle was in the process of being repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall associated with the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

The contact owns a 2019 Ford F-350. The contact stated that the driver's side front door latch failed to lock and securely close the door. The contact stated that the failure only occurred during cold weather. The failure had occurred 4 times. The vehicle was taken to the dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The contact was informed that there was an undisclosed Customer Satisfaction Program for the door latch freezing and the door lock actuator failing to operate as designed; however, the contact was not provided the CSP number. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 82,000.

The contact owns a 2019 Ford F-350. The contact stated while driving or while the vehicle was parked, the doors would freeze in cold weather and failed to latch securely. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The contact related the failure to Customer Satisfaction Program: 19N06 (Door Latch Freezing Concerns). The failure mileage was 91,620.

Brake lights stay on won’t go off. Replaced brake module, fuse etc. Can put key in and turn to accessories and put gear selector in drive,neutral, reverse WITHOUT PUTTING FOOT ON BRAKE PEDAL… CANNOT FIGURE THIS PROBLEM OUT…

When you drive this truck for extended periods of time the entire instrument cluster shuts off loosing blinkers lights and any indication of speed, among that if you're towing a trailer the trailer lights shut off, ford has tried fixing it under warranty to no avail, now the truck is out of warranty and the issue is getting worse and they're not sure what's wrong. I also have videos of this issue

Rear window shattered when rear window defrost was activated.

My back up camera is not working.

Brake lights stay on won’t go off. Replaced brake module, fuse etc. Can put key in and turn to accessories and put gear selector in drive,neutral, reverse WITHOUT PUTTING FOOT ON BRAKE PEDAL… CANNOT FIGURE THIS PROBLEM OUT…

The contact owns a 2019 Ford F-350. The contact stated while driving at an undisclosed speed, the contact noticed that the windshield wipers became inoperable. The contact stated that when the windshield wipers were engaged, the contact could not shut off the windshield wipers. The contact had to turn off the vehicle to stop the windshield wipers. The contact restarted the vehicle, and the failure persisted. The contact also stated that the exterior lights were inoperable. The contact stated that the exterior lights were turning off and on while driving. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.

Drivers airbag cover is cracked/splitting, seems to be following the release seam of airbag. I am worried that it will continue, or the airbag will malfunction. Took truck to local FORD dealer and was told that this issue was not covered under my warranty nor restraint system warranty. No warnings, no messages prior.

The air bag light came on

The contact owns a 2019 Ford F-350. The contact stated that while the vehicle was parked, it was discovered that the air pressure in all four tires were consistently decreasing; the contact also noticed corrosion around the rims and valve stems on each wheel. The low tire pressure warning light was illuminated. The vehicle was driven to a dealer but not diagnosed; however, the contact was informed that the dealer would replace the current tires with new tires to monitor the failure. The vehicle was repaired; however, the failure reoccurred. The contact was constantly adding air to the tires before driving the vehicle. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 25,000.

The tires have 40000 miles on them. They are the factory tires and the tread came off as I was driving and done damage to the truck not sure of exact amount will be getting estimates tomorrow . It was the driver side front I have pictures of tire and damage and also of the other 3 tires and still have the tire that failed

Seat belt locks and will not allow movement while driving causing the driver to be pinned against the seat under normal driving conditions.