2022 Ford F-350 Sd Owner Complaints

The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V686000 (Back Over Prevention). The contact stated that while in reverse(R) on several occasions, the rear-view camera was black. The contact stated that on one occasion while his wife was driving the vehicle and shifted into reverse(R), the camera went black, and the vehicle reversed into a cement pole. The vehicle was taken to a dealer where the vehicle was not diagnosed; however, the contact was informed that the part to repair the vehicle was not yet available. The manufacturer was not notified of the failure. The failure mileage was approximately 1,500.

NHTSA ID

11754513

Incident

Jun 15, 2022

Mileage

1,500 mi

fuse box is allowing moisture in causing horn to not stop and truck to remain running. Ford has updates in their manual that this is a problem but no recall issued.

NHTSA ID

11749684

Incident

Jul 11, 2026

I have been waiting over a year for this low pressure fuel pump recall and it has stopped me from driving long distance to visit my daughter where part of the trip is hoursbthrew the Nevada high desert with extreme heat and NO CELL SERVICE. I AM FED UP AND NEED YHISNISDUE REDOVLED NOW OR A NEW DARN TRUCK. PLEASE ADVISE

NHTSA ID

11749092

Incident

Jul 8, 2026

While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

NHTSA ID

11748576

Incident

Jul 1, 2026

When the vehicle is moving forward, and rear camera is selected to visibly confirm the status of anything behind the vehicle, there is a giant black bar/box that states "full view not available" Clearly this is a safety hazard in the sense that I am unable to rapidly assess and determine the status of anything behind my vehicle, be it a trailer, a hitch mounted bike rack, or another vehicle. Ford should be required to remove all of these distractions from their software immediately.

NHTSA ID

11741709

Incident

Jun 2, 2026

Trailer Brake Module Failure message at start up. I no longer have any trailer brake function. I was towing when this happened.

NHTSA ID

11740749

Incident

May 28, 2026

The contact owns a 2022 Ford F-350. The contact stated while driving at an undisclosed speed, the trailor lights and the brake lights failed to function as intended. No warning lights were ullimunated. The vehicle was taken to the dealer where it was diagnosed with a malfunction with the trailor brakes and service brakes. The contact was informed that the parts were unavailable. The vehicle was not repaired. The contact received a recall notification, NHTSA Campaign Number 22V193000 Electrical System) however the parts were unavailable.

NHTSA ID

11739487

Incident

Mar 17, 2026

Mileage

105,000 mi

Charging System Fault. Caused multiple error messages like Forward camera not available, collision avoidance not available. Then Radio goes black and reboots. Several cycles later the dash board goes DARK. No speed or RPM anything visible for 5-10 secs, and on some reboots this Dark dash lasted 30 seconds. Thankfully while traveling at midnight the head lights and tail lights remain on, just no interior lights during these Reboots. New batteries made no difference.

NHTSA ID

11736993

Incident

May 6, 2026

While flat towing my 2022 Ford F‑350 behind a motorhome using Ford’s Neutral Tow Mode procedure, the vehicle suffered a catastrophic transmission failure. The Ford dealer documented this clearly on the service invoice: “HAPPENED WHILE THE VEHICLE WAS FLAT TOWED.” After the tow, the truck had severe slipping, delayed engagement, high RPM with no movement, and a wrench light. The dealer confirmed fault codes P0741, P1744, and P27B4. The dealer found catastrophic internal damage: “fluid is burnt with metal debris… filter is packed with metal debris… torque converter has came apart and filled transmission with metal debris… it is catastrophic failure.” These components are available for inspection. The dealer also documented a low battery condition: “batteries. low state of charge.” Ford’s Neutral Tow Mode relies on electronic control modules that require stable voltage, but Ford provides no warning that low voltage can cause the transfer case to exit Neutral Tow Mode. This creates a safety risk because the transmission can be rotated internally without lubrication while being towed, which can lead to sudden drivetrain lockup or loss of control. The problem was confirmed by the Ford dealer, and the vehicle was fully inspected by them. The only warning symptom occurred after towing: wrench light, slipping, and no movement. There were no warnings during the tow itself. This failure mode is not disclosed by Ford and cannot be detected or prevented by the owner.

NHTSA ID

11735855

Incident

Apr 3, 2026

The right rear corner parking sensor on the truck has a 3 foot range. I believe these rear back up sensors normally should have a 12-15 foot range. I was backing up at an angle at slow speeds at hit a large brick mailbox. The mailbox is below the height of the closed tailgate. This could have been a adult or child. The sensor triggered but I did not stop in time. At 5mph a 3 foot distance is covered in .4 seconds. I replaced the bumper and the bumper cover as a result of this .

NHTSA ID

11733762

Incident

Jun 20, 2024

This is not a failed component, the issue is a design interaction issue. This truck when it gets stuck as it unfortunately very easily does even on wet grass goes into a traction control mode where the throttle is VERY damped but the issue is not only is the opening very dampened the closing is also VERY damped. This is made significantly worse by the fact that traction control cannot actually be disabled. There is a switch and it indicates it is disabled but the functionality remains the same. This combination means whenever you're working to get the truck unstuck, like yesterday when it was on wet grass you have to expect that the vehicle will suddenly accelerate as soon as it finds traction. normally you can counteract this by expecting to apply significant brakes as soon as it finds traction but if the front wheels are still on a slippery surface the ABS system will lose it's mind and essentially disable brakes as the vehicle accelerates violently backwards with the new found traction. This combination of software decisions makes it so you can very easily replicate an unintended acceleration scenario where the vehicle jumps back a solid 20' when this happens, not respecting any brake input given by the driver and certainly not respecting that the throttle was released long ago. The throttle closing should not be damped when traction control is running and the ABS system should not be behaving the way it does. I understand getting the vehicle unstuck from wet grass is not normal operation but that's what the traction control disable button should be for and Ford makes that button useless also. When taken together, all these engineering decisions make for a very unsafe situation that has zero reason to exist. I've attached pictures that show the overview of the situation as well as the characteristic ABS marks showing that it was disabling brakes.

NHTSA ID

11732180

Incident

Apr 18, 2026

The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

NHTSA ID

11730352

Incident

Apr 10, 2026

Mileage

30,000 mi

2022 F350 SRW, King Ranch, Tremor Steering column began making clunking sound when hitting rough patches on highway. I then noticed that I was able to lift the steering wheel an inch or two up and also pull it towards me two to three inches and freely push it back in. I could wobble the steering wheel side to side as well. Felt very unsafe as I was on a 7 hour trip home. No warning lights or incident that contributed to problem

NHTSA ID

11730326

Incident

Apr 9, 2026

Front facing camera, located in front grill, has inadequate water proofing, which eventually shorts out the camera and causing it to become inoperable. This creates a blind spot when backing up or driving in tight spaces with such a large truck. When the front camera blacks out, you lose visibility in front of the vehicle. This is a safety issue, because the size of the truck, how high it sits from the factory, and no visibility over the hood could cause a collision with low height persons or kids or property. Yes, this issue has been reproduced by the dealer. And there are numerous reports of people on message forums and social media complaining of this issue. There were no warnings of this prior to failure. One day the front facing camera simply stopped working, leaving a black screen for any camera views that include the front camera.

NHTSA ID

11730191

Incident

Apr 2, 2025

Glass roof panel behind sunroof (over rear seats of crew cab) shattered while driving on the highway at 5:30am with no other vehicles within several hundred yards. No sign of impact, remaining glass seems to be pushed outward.

NHTSA ID

11730058

Incident

Apr 7, 2026

The contact owns a 2022 Ford F-350 SD. The contact stated that while driving approximately 45-50 MPH, in snowy weather, the front driver's side windshield wiper fractured, and the contact pulled over to manually wipe the window. The dealer was notified of the failure and informed the contact that the vehicle could not be repaired under Ford Campaign Number: 22S26 (Both Front Wiper Arm Replacement) because the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed the dealer's information. The failure mileage was approximately 32,076.

NHTSA ID

11721025

Incident

Feb 24, 2026

Mileage

32,076 mi

The contact owns a 2022 Ford F-350 SD. While driving at an undisclosed speed and hauling a trailer, there was a delay with the trailer brakes before the trailer brakes engaged, causing the braking distance to be extended. Occasionally, the trailer brakes failed to engage, causing the electric brakes to activate and stop the vehicle. The contact became aware of NHTSA Campaign Number: 25V132000 (Electrical System) on the NHTSA.GOV website, which referenced a similar failure. The dealer was made aware of the failure. The dealer informed the contact that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer opened a case for the failure; however, no assistance was provided. The failure mileage was approximately 94,000.

NHTSA ID

11717249

Incident

Feb 11, 2026

Mileage

94,000 mi

Our truck is currently experiencing issue with the driver side door. In cold temperatures, the door will not open from the outside of the vehicle nor the inside of the vehicle. This is a known Ford recall with the F150 series as well. TSB/SSM 50543: SSM 50543 is a Ford Special Service Message addressing freezing door latches on 2021-2022 F-150 trucks. It addresses issues with doors failing to lock, unlock, or open in freezing temperatures due to water intrusion, instructing dealers to inspect and, if necessary, replace door latch cables and actuators. This is EXACTLY what we are experiencing with our 2022 F350.

NHTSA ID

11712907

Incident

Dec 1, 2025

The contact owns a 2022 Ford F-350 SD. The contact received the recall notice for NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention). The contact expressed safety concerns about driving the recalled vehicle. The local dealer was contacted and confirmed that the parts to do the recall repairs were not available. The manufacturer was contacted by mail regarding vehicle rental and buyback assistance, which was denied. The contact had not experienced a failure.

NHTSA ID

11707754

Incident

Dec 7, 2025

The contact owns a 2022 Ford F-350 SD. The contact stated that while driving at various speeds, there was an abnormal rattling sound coming from the roof. The vehicle was taken to a local independent mechanic, where it was diagnosed, and determined that the roof rack needed to be replaced. The vehicle was taken to a local dealer, where the failure was replicated. The vehicle was not repaired due to the VIN not being included in NHTSA Campaign: 25V729000 (Visibility). The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.

NHTSA ID

11707446

Incident

Oct 15, 2024

Mileage

40,000 mi

Synce 4 infotainment center with loose connection to phone causing phone to connect and disconnect and become statickey while driving. Ford dealerships when contacted do not have a fix and two dealers have said its a very common issue but no fix for it. safety risk is that while you think your hands free on the phone when it goes in and out of connection can cause a major distraction while driving. I have had two dealers provide feedback that this is an issue but not one that has a fix that they can do. It has not been inspected by police or insurance agent there is no warning lamps that have gone off

NHTSA ID

11704274

Incident

Aug 1, 2025

The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V455000(Fuel System, Gasoline). The contact was concerned about driving the vehicle. The local dealer was contacted and informed the contact that there was no related recall information from the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.

NHTSA ID

11698191

Incident

Nov 7, 2025

The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The contact stated that while attempting to accelerate from a stop, the vehicle hesitated before accelerating. There were no warning lights illuminated. The dealer was contacted, and it was confirmed that parts were not yet available. The manufacturer was made aware of the issue. The failure mileage was unknown.

NHTSA ID

11696043

Incident

Jul 8, 2025

The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY), 24V957000 (FUEL SYSTEM, DIESEL), and 25V686000 (Back Over Prevention). However, the parts to do two of the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11693698

Incident

Dec 15, 2024

The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image appeared distorted. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention), but the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 23,000.

NHTSA ID

11693632

Incident

Oct 15, 2025

Mileage

23,000 mi