2019 Ford Fusion Problems

Bought my car in 2019. Was unaware of coolant intrusion problem on my vehicle. Check engine light came on and mechanic just quoted me $13,000 to fix.

While driving we noticed the engine light came on so we took it to our local mechanic. He said we were leaking coolant and it was too extensive fro him to fix so he suggested we put coolant in every few days. We researched the problem and found that these cars had a recall for this exact issue yet our VIN does not show it. We went to Ford Dealership and they confirmed we need a new engine as they connected the IDS. This vehicle was built at the Hermosillo plant, has the same 1.5L EcoBoost engine, and has experienced the exact coolant intrusion failure that Ford recalled or extended coverage for on other vehicles. I am asking Fotrd to reconsider my case because my vehicle has the identical defect despite my VIN not being included. My kids purchased this car for my wife and I in October 2025. I also included a VIN Report based on my VIN Number and if scroll to the bottom of that report maybe page 23 you will see the Recall.

My backup camera often freezes after I shift from reverse to drive. The screen turns blue and at time will have a live video of me driving showing what’s behind my car. Also my engine loses power and doesn’t accelerate as it should. There is a powertrain and censor error that shows due to the Che k engine light being on. I had the issue fixed once at a ford dealer however the issue was not resolved. It started up again 48 hours later.I have noticed that all other ford fusions have the same two issues and were included in the recalls but the 2019’s are not ? Please assist I have been trying to have these issues resolved for years with no success.

When driving all of a sudden I feel the car loose power as I accelerated the car just reeved up and slowed down to a full stop. I put it in park turned it off sat for a few minutes. Restarted the car and put it in drive the engine RPM made a reving sounds but did not engage. I had to wait for a tow truck. When the tow truck arrived he started the car and drove it on the ram and locked it in and drove the car to my home. Tow truck driver unlocked my car and drove it off the bed of his truck. The car starts and that is it. It will dive a few feet then disengage.

My backup camera often freezes after I shift from reverse to drive. The screen turns blue and at time will have a live video of me driving showing what’s behind my car. Also my engine loses power and doesn’t accelerate as it should. There is a powertrain and censor error that shows due to the Che k engine light being on. I had the issue fixed once at a ford dealer however the issue was not resolved. It started up again 48 hours later.I have noticed that all other ford fusions have the same two issues and were included in the recalls but the 2019’s are not ? Please assist I have been trying to have these issues resolved for years with no success.

The contact owns a 2019 Ford Fusion. The contact stated that after receiving notification of NHTSA Campaign Number: 23V440000 (ELECTRICAL SYSTEM); that the parts were available, the local dealer was contacted, and the contact was informed that parts were still not available and were on back order. The manufacturer was notified of the issue and confirmed that parts were still on back order. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

I have took it in to get it repaired about a year ago the sensor went off and got them fix but when I explain what else was happening they found nothing months down I has other people and couldn’t find the problem with my vehicle which is now a risk to drive the steering wheels gets stiff and hard to turn I have to wait for the system to kick back originally I was told it was a O2 sensor

Very frequently, the rear view camera will stop working, glitch and go black. Then give the message, camera is unavailable

Known Coolant intrusion issue came up with the 2.0 Ecoboost. Began to lag on takeoff causing unsafe acceleration profiles. Took to dealership who confirmed poor design was the root cause.

Engine catastrophicly over Revs when charging and plugged in phev plug.

I have a 2019 ford fusion turbo engine and everytime I accelerate the turbo is wicking into the pcm the control module which is causing hazards sucking as at random times whenever I turn left the steering wheel with get stuck and the brakes will lock for a couple seconds and then go back to normal. I had Meineke do a diagnostic on the car and they showed oil in the pcm aswell as the loss of connection between the pcm and its sensors. They drove the car and while driving the car going 20mph the car is reading as going 100

First, we will start with every time I turn my car to the left the steering wheel box and the brakes skid then the ABS sensor comes on Then we will start with the car every time I put it into a gear. It automatically goes back to park, and I cannot move the car in any direction. When the issue first started, I could reverse then when I put the car and drive in the middle of the street it would automatically go back to park which could cause a crash I only have video proof of this.

The vehicle wheels and steering wheel bounce and shake when brakes are applied, regardless of the speed level; this felt like I am losing control of the vehicle and as if the wheels, and components of suspension or brake system will collapse all of the sudden. No warning lights came up in the dashboard. The vehicle was inspected by the dealership (Kearny Mesa Ford Service, 7303 Clairemont Mesa Blvd, San Diego, CA 92111) and they confirmed the problem, the problem still persisted after they performed checks and repairs, their response was "we are not sure what's causing the problem and we need more time to diagnose.".

The contact owns a 2019 Ford Fusion. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. No warning lights were illuminated. The vehicle was taken to an independent mechanic who diagnosed a misfire in cylinder #3. The vehicle was not repaired. The independent mechanic related the failure to Ford Customer Satisfaction Program: 21N11. The manufacturer was made aware of the failure and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 2,690.

The contact owns a 2019 Ford Fusion. The contact stated that while coming to a stop, the contact heard a loud sound coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the flex plate, torque converter, and front pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.

The contact owns a 2019 Ford Fusion. The contact stated that upon starting the vehicle and shifting the gear selector into the drive position the vehicle shifted back into park on its own. After which a warning message displayed reading "Transmission shifter fault." The transmission warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the shifter bushing. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 131,000.

The contact owns a 2019 Ford Fusion. The contact stated that while the wife was driving approximately 70 mph the vehicle crashed into a deer. During the crash, the front end of the vehicle was severely damaged but no airbags were deployed. The driver sustained back and neck injuries. A police report was taken at the scene and the vehicle was towed away. The manufacturer and local dealer were notified of the failure. The failure mileage was 65,000.

Fusion traveling northbound and t-boned sedan traveling westbound in intersection. Fusion has significant front end damage. No airbags deployed in Fusion. All airbags deployed in other vehicle. Driver of Fusion, wearing seatbelt, suffered sternum fracture. Available for inspection. Failure of airbags to deploy likely cause sternum fracture. Fusion just arrived at car repair for scan and inspection. The Fusion was started less than 5 minutes prior to accident and driver received message indicating the front camera was unavailable.

The lower latch/tether fails to secure the car seat. Any time that the lower latch is tightened for installation, it becomes loose within an hour of installation. The car and car seat were taken to the local fire department to be installed by a certified installer and it still came loose within a hour of installation. The lower latch will not remain sufficiently tightened and the unoccupied seat can move horizontally, laterally and vertically about 3-4 inches. The seat will loosen even when unoccupied by a child.

My 2019 Ford fusion while driving, the trunk opens by itself. It blocks the rear view of the vehicle. I had to pull over and close it several times while driving for this. I had to put a bungee cord around the trunk to keep it from opening. The trunk opening by itself is a safety hazard and the contents of what is in the trunk it exposed. I already spent over $210 in repairs with the dealer estimating the cost would be over $1100 including the wire harness from the body control module and including the body control module if the harness does not fix this.

My 2019 Ford fusion while driving, the trunk opens by itself. It blocks the rear view of the vehicle. I had to pull over and close it several times while driving for this. I had to put a bungee cord around the trunk to keep it from opening. The trunk opening by itself is a safety hazard and the contents of what is in the trunk it exposed. I already spent over $210 in repairs with the dealer estimating the cost would be over $1100 including the wire harness from the body control module and including the body control module if the harness does not fix this.

For the third time in two years my trunk opened while I was driving. Today, it opened while I had lumber in the trunk. Had I been on the freeway this could have caused a serious accident. I confirmed that the button on the dash was not being pushed and the emergency release in the trunk was not pulled either. This seems to be a somewhat common issue with Ford Fusions based on online commentary. Please look into this before it leads to serious injuries or worse. Thank you for your help.

The contact owns a 2019 Ford Fusion. The contact stated while driving 15-20 MPH in light rainfall, the windshield wipers were activated and the front driver's side windshield wiper suddenly reversed, struck the cowl, and seized. Additionally, the contact stated that there was a significant amount of smoke coming from underneath the driver's side hood, reducing the visibility of the roadway. The contact attempted to deactivate the windshield wipers using the switch; however, the wipers failed to respond as needed. The contact pulled over to the side of the road and turned off the vehicle. The contact opened the hood and allowed the smoke to dissipate. The contact then drove to the residence. The vehicle was taken to the dealer, where it was diagnosed that the windshield wiper motor had failed and needed to be replaced. The vehicle was being repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 37,000.

Driving on highway in a thunderstorm; windshield wipers were on full out max. They did not go fast enough to clear the water from the windshield so I could see the road. After this incident, I went to Ford and told them about it. They inspected it and said the wipers worked as designed. When I told them that was inefficient and unacceptable and a safety hazard for a downpour, they told me to "pull over" if I get caught in a storm. That is unacceptable. It is not always safe to pull over. I should be able to see for at least a half second to tell if I am driving within my lane. I had to drive on the bumper of a truck to follow their lights. I had the 2018 Ford Fusion and the windshield wipers worked properly.

my transmission is faulty my car is a 2019 Ford Fusion and it has all the same problems as earlier models with recalls that are equipped with the same components as mine my it keeps stalling when I come to a stop which I see numerous complaints of the same thing it there were no warning lights on at the time it occurred I've done research on my own through forums and there are thousands of complaints of the same thing happing to there's there's no way that can be just are luck there has to be something wrong with the way the car is built or made

THE HEADLIGHTS ON THE 2019 FORD FUSION ARE HORRENDOUS! THERE IS VERY LITTLE VISIBILITY, I'M CONSTANTLY HAVING TO TURN ON MY BRIGHTS TO EVEN SEE SOME ASPECTS OF THE ROAD I'M ON. THIS IS IRRESPONSIBLE ON FORDS PART AND NEEDS TO BE ADDRESSED AS SOON AS POSSIBLE! THERE'S NO TELLING HOW MANY ACCIDENTS THIS HAS CAUSE AND OR WILL CAUSE IN THE FUTURE.

sometimes when i get in the car and put my seat belt on i can be driving and it unclip tey to put it back in and it want go have to play around with it before im able to clip it into the other part for safety. my safety is put at risk cause when im driving the seatbelt un hooks. no cant afford to take it because it cost almost 200.00 to diagnose any problem with the car.no warning light or anything also sometimes my car say my blind spot camera are not working and it will pop up on my dash. my back up camera instead of it showing whats in back of me it sometimes show whats in front of me

A COUPLE MONTHS BACK, I RENTED A 2019 FORD FUSION, SO THE VIN NUMBER IN THIS REPORT IS ONLY A SAMPLE. TWICE, WHEN I WENT TO BUCKLE THE DRIVER-SIDE SEATBELT, THE END WENT NOT INTO THE LATCH, BUT INSTEAD INTO THE CASING AROUND THE LATCH (SEE PICTURES). THERE WAS JUST ENOUGH FRICTION TO HOLD IT IN PLACE AND MAKE IT FEEL LIKE IT WAS LATCHED, WHEN IN ACTUALITY, IT WAS NOT. I CONTACTED THE LOCAL FORD DEALER TWICE, BUT GOT NO REPLY. I THEN WROTE A LETTER TO FORD MOTOR CO. SIMPLY SAYING I HAD FOUND AN ISSUE, BUT ONLY GOT AN OBVIOUS FORM LETTER SAYING "THANK YOU". THEY DIDN'T EVEN ASK FOR ANY DETAILS. UPON DISCUSSION OF THE ISSUE WITH A FRIEND, HE SAID HE HAD THE SAME EXACT ISSUE WITH A 2015 FUSION.

The vehicle wheels and steering wheel bounce and shake when brakes are applied, regardless of the speed level; this felt like I am losing control of the vehicle and as if the wheels, and components of suspension or brake system will collapse all of the sudden. No warning lights came up in the dashboard. The vehicle was inspected by the dealership (Kearny Mesa Ford Service, 7303 Clairemont Mesa Blvd, San Diego, CA 92111) and they confirmed the problem, the problem still persisted after they performed checks and repairs, their response was "we are not sure what's causing the problem and we need more time to diagnose.".

TL* THE CONTACT OWNS A 2019 FORD FUSION. THE CONTACT STATED WHILE DRIVING AT 25 MPH, THE FRONT AXLE ON THE PASSENGER SIDE FRACTURED CAUSING THE TIRE TO FOLD UNDER THE VEHICLE. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE AND THE VEHICLE COULD NOT BE TURNED TO THE LEFT OR RIGHT DIRECTION. THE VEHICLE HEADED STRAIGHT FOR 30 YARDS AND WENT OVER A CURB LANDING ON AN INCLINE OF A PRIVATE PROPERTY. ALL THE AIR BAGS DEPLOYED EXCEPT FOR THE FRONT DRIVER SIDE AND STEERING WHEEL AIR BAGS WHICH FAILED. A POLICE REPORT WAS FILED UNDER REPORT NUMBER: 212000012. THE CONTACT SUSTAINED TWO 9 CM LACERATIONS TO THE HEAD AND 19 STITCHES, A CONTUSION TO THE HEAD, CONCUSSION, LOSS OF MEMORY, AND MASSIVE BODY ACHES THAT REQUIRED MEDICAL ATTENTION. A POLICE OFFICER DROVE THE CONTACT TO THE HOSPITAL AFTER THE IMPACT. THE CONTACT MENTIONED THAT THE INFORMATION PROVIDED WERE BASED ON PICTURES AND VIDEOS OF THE EVENTS OF THE IMPACT DUE TO HIM HAVING MEMORY LOSS. THE FOLLOWING DAY THE CONTACT WENT BACK TO THE SCENE AND FOUND THE PASSENGER FRONT AXLE ON THE ROAD. THE VEHICLE WAS TOWED TO A TOW TRUCK COMPANY. THE INSURANCE COMPANY WAS SCHEDULE TO INSPECT THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED AS OF YET. THE FAILURE MILEAGE 13,000. *LN *JB *TR

All four tires separated at the bead, catastrophic tire failure. Thank goodness they went flat in the driveway and not traveling at 65 mph on the interstate. 235/50R/17. These are 80,000 mile tires and this occurred at 35,500 miles. Purchase from Costco and when we went back they basically told us they would only warranty 20% of tire even though the warranty should have been 50%.

The contact owns a 2019 Ford Focus. The contact stated that the vehicle was taken in for an annual inspection but failed due to the lug nuts. The contact was informed by the technician that the lug nuts needed to be replaced with aftermarket one-piece lug nuts. The vehicle was then taken to the dealer where it was confirmed that the lug nuts needed to be replaced. The vehicle had not yet been repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,000.