2025 Ford Maverick

The contact's employer owns a 2025 Ford Maverick. The contact stated that while driving approximately 45 MPH, the pre-collision warning light suddenly activated, and the vehicle abruptly stopped. After pulling over and waiting for several minutes, the contact was able to continue driving. The contact also had whiplash from the failure, and medical attention was needed. The contact mentioned completing 12 sessions of physical therapy. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer was unable to duplicate the failure. The failure reoccurred a week later while driving approximately 30 MPH. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,000.

NHTSA ID

11753287

Incident

Apr 14, 2026

Mileage

3,000 mi

2025 Ford Maverick XL EcoBoost AWD with 2,000 lb tow package. Vehicle displays an 'Engine Coolant Over Temperature' warning recurrently at idle and upon initial startup when ambient temperature is 84°F or above. The warning has occurred multiple times under these conditions. Most recently, the warning appeared while the vehicle was stationary at 0 MPH immediately before entering a highway, creating a safety concern. Vehicle currently has 3,911 miles. No prior dealer service visits for this issue. The problem appears to be temperature-dependent and repeatable. Warning is displayed on the instrument cluster with a red coolant temperature icon and the temperature gauge needle visible in the high range

NHTSA ID

11747507

Incident

Jun 27, 2026

A year ago while driving on the interstate, my Ford Maverick suddenly threw a "Stop Safely Now" alert. I was able to turn the ignition off and back on to safely exit the highway. The alert came back once I made it to a parking lot and stuck around for a while. I was able to get it started and drove to a Ford dealership that told me it was just a software update. The same issue happened 2 more times before I made it to my destination after leaving the dealership, showing that it actually wasn't caused by a missed software update. Returning from my trip it happened 4th time. Afterward, the issue seemed to go away. Now a year later I got in the Maverick to leave work and the alert came back. I was not able to get it started and will attempt to get it over to a Ford dealership tomorrow to be seen for what seems to be the same issue, only worse if it still is not starting in the morning.

NHTSA ID

11746575

Incident

Jun 25, 2026

The passenger side floor is soaking wet every time it rains. Google says this is a defect with the windshield cowl, which other owners say is a common problem. Our safety is at risk with potential for mold, rust, and water intrusion into the electrical system. The truck is going to the dealership on Monday to have this issue addressed. It has been reproduced every time it rains. It has not been inspected by anyone other than myself. There were no warnings or alerts. We've noticed the wet carpet a couple times and researched the problem.

NHTSA ID

11728937

Incident

Mar 27, 2026

THE WINDSHIELD WIPERS SOMETIMES WORK & SOMETIMES DON'T WORK - A RECALL FOR THE 2023 & 2024 FORD MAVERICK HAVE A RECALL BUT NOT FOR THE 2025 MODEL - PLEASE ISSUE A RECALL FOR THE 2025 MODEL YEAR THE FORD SERVICE CENTER WOULD NOT DO ANYTHING WI THOUT A 2025 RECALL- THIS STARTED HAPPENG WHEN THE WEATHER GOT VERY COLD - WHEN THE WARM WEATHER RETURNED THE WIPERS WOULD WORK AGAIN - IT IS DANGEROUS TO DRIVE UNDER THESE CONDITIONS - PLEASE ISSUE A RECALL FOR THE 2025 YEAR - THANKS!

NHTSA ID

11727027

Incident

Jan 15, 2026

The vehicle is a 2025 Ford Maverick. The engine experienced a major internal failure that was later diagnosed by the dealership as a gouge in the #4 cylinder wall. This defect caused significant engine malfunction and required major repair/replacement. This issue which triggered a CEL created a serious safety concern because a failure of this type can result in sudden loss of engine power while driving, which increases the risk of a crash, especially when traveling at highway speeds or when attempting to merge into traffic. Loss of propulsion can place the driver and other motorists at risk. The problem was confirmed by an authorized Ford dealership, which inspected the vehicle and documented the gouged cylinder wall in cylinder #4. Repair documentation from the dealership is available.

NHTSA ID

11723004

Incident

Dec 1, 2025

My Wife went out to the truck 2025 Ford Maverick XLT FX4 OFF ROAD PACKAGE TOWING PACKAGE LUXURY PACKAGE to back out of our drive way as She ALWAYS Does and instead of reverse she ended up in the garage door. it went forward I have a picture to show it was in reverse tried to engage emergency brake tried to put it in park and nothing worked until she was in the door and crashed. NO COLLISION ALARMS OR PREVENTIVE COLLISION HELP THAT IS SUPPOSED TO BE ON THESE TRUCKS. thank god no one was SERIOUSLY HURT that we know of BUT IT LITERALLY MESSED WITH MY PTSD AND MENTAL HEALTH. she sat in the vehicle and cried because its brand New and there is less than 400 miles on it. so know I have to pay for a GARAGE door that I don't own and fix a brand new truck. that I have only made 3 payments on. I don't have pictures of front yet because I'm afraid to move it until the tow truck comes to get it in the morning. then I will get to see the truck damage

NHTSA ID

11722381

Incident

Mar 5, 2026

not every time, but several times throughout driving around all day, i notice: the vehicle is in 'eco' driving mode, and while i start to slow down, lightly applying constant pressure to the brake pedal, the vehicle goes from a smooth constant slowing down pace, and all of a sudden, the vehicle seems to surge/lurch/lunge forward at a faster pace, and then a fraction of a second later, the vehicle then slows down closer to expected. Im not sure if its an issue with the hybrid eCVT , the regenerative hybrid braking, or the electronic ABS ... or some mixture of these systems. The griffin Ford dealership claims they cant re-create it, and there is no 'fix'. I drive around basically every day, and notice it now at least once to 10 times per day. the current local weather is around 20 degrees, up to maybe 50 at the hottest.

NHTSA ID

11721847

Incident

Feb 25, 2026

Some 2025-2026 Maverick vehicles built on or before 05-Dec-2025 and 2024-2026 Nautilus vehicles built on or before 04-Sep-2025 may exhibit limited power and display "Stop Safely Now" or "Service Vehicle Soon" stored in the message center after start up with diagnostic trouble codes (DTC) P0A5D, P0A60, P0A63, P0A6F, P0A72, P0A75, and/or P0E52 stored in the inverter system controller (SOBDMC). The Ford Diagnostic and Repair System (FDRS) may refer to this module as the "Secondary On-Board Control Module C". If the vehicle exhibits these conditions, replace the inverter system controller. Refer to Workshop Manual, Section 307-01B. For claiming, use causal part 7B012 and labor operations 12651D and 12651D58. NOTE: This article does not remove any RVC, Prior Approval or Warranty and Policy requirements for component replacement.

Some 2021-2026 Ford/Lincoln vehicles may exhibit various symptoms including but not limited to the auto start/stop system not operating as intended with a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is operating properly with no charging related diagnostic trouble codes (DTC) stored. This may be due to someone using an aftermarket programmer to change the body control module (BCM) configuration to disable the auto start/stop system or perform other unsupported programming modifications. To correct this condition on F-150 and Bronco vehicles, download and run the Ford Diagnosis and Repair System (FDRS) application titled "BCM-Charging System Configuration Correction". Running this application will determine if the BCM configuration was modified by the customer and if so, provide the option to return the configuration back to factory settings. For other vehicle models exhibiting concerns related to unsupported aftermarket BCM programming, submit a Technical Support Request (TSR) requesting support to revert the BCM configuration

Some 2025-2026 Bronco/Bronco Sport/Corsair/F-150/F-Super Duty/Maverick/Mustang/Mustang Mach-E/Ranger vehicles may exhibit a no audio/sound condition. This may be due to the software in the audio control module (ACM). To determine if it is a software concern, disconnect the vehicle's 12-volt battery cables for 10 minutes and reconnect. If the concern is still present, continue with normal diagnostics in Workshop Manual (WSM), Section 415-00 Information and Entertainment System > General Information > Diagnosis and Testing and repair as necessary outside of this article. If the no audio/sound concern is resolved, reprogram the ACM using the latest software level of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 18C869 and labor operations 10654C, 12651D and 12651D4.

Some 2021-2026 Ford vehicles may exhibit inoperative heated/cooled seats, heated steering wheel and/or front/rear defrost features after a remote start is performed through the Ford mobile application or with the key fob. Customers may also experience heated/cooled seats, heated steering wheel and/or front/rear defrost features turning on in unexpected conditions such as during warmer weather. These features will operate normally when commanded in the center display screen. This may be due to the customer not setting up their "Climate Settings" through the Ford mobile application. To correct this condition, inform the customer they should perform a remote start from the Ford mobile application and then adjust the "Climate Settings" in the Ford mobile application as desired. These settings only need to be set once and will persist through subsequent remote starts. Heated and cooled seats will be set to Level 2 when turned ON via "Climate Settings" in the Ford mobile application during a remote start event. This is normal operating characteristic. This condition does not affect vehicle durability and no a

NEW VEHICLE DELIVERY HOLD - Emissions Recall 26E04 Certain 2021-2025 Model Year F-150, Maverick, Mustang, Ranger, Expedition, Bronco Sport, Explorer, Bronco, Navigator, and Aviator Vehicles Powertrain Control Module Software Update

Some of the vehicles listed in the model statement above equipped with SYNC4 may experience a blank center display screen or black center display after welcome animation. The rear-view camera will still function when shifting the vehicle to reverse under these conditions.