2002 Ford Windstar Body & structure Problems

The contact owns a 2002 Ford Windstar. The contact received notifications of NHTSA Campaign Numbers: 11V030000 (STRUCTURE) and 15V608000 (SUSPENSION). The contact stated that while approaching a traffic signal and driving slowly, the vehicle shook, and the engine shifted. The contact stated that the engine shifted to the right. In addition, the contact lost control of the steering wheel. The contact stated that the RPMs became elevated. The contact pulled over into a parking lot and turned off the vehicle. The contact exited the vehicle, and upon inspection, became aware that the subframe had detached and was dragging. The contact believed that the motor mounts were fractured. The vehicle was towed to a tow yard. The vehicle was not taken to the dealer or an independent mechanic, and the vehicle was not repaired. The vehicle remained at the tow yard unrepaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline to report the failure. The approximate failure mileage was 108,000.

NHTSA ID

11720212

Incident

Feb 3, 2026

Mileage

108,000 mi

Axle broke on rt side just underneath the bracket that ford installed for recall.i was only going 10mph when it happened no warning I was able to gain control and stop was towed into a shop not driveable if this seems to be a problem mine looked fine they must filled it up with expand foam I would think that would trap in more moisture but these are dangerous they should all be fixed or bought back from the customer

NHTSA ID

11660690

Incident

May 12, 2025

The van took off without my control and the brakes stopped working and the fuel system it caused me to have two accidents within a week of each other

NHTSA ID

11511077

Incident

Mar 9, 2023

The contact owns a 2002 Ford Windstar. The contact received notification of NHTSA Campaign Number: 10V385000 (Suspension) and 11V030000 (Structure) however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the subframe was severely corroded. The failure mileage 59,839.

NHTSA ID

11504440

Incident

Oct 15, 2022

Mileage

59,839 mi

The driver and passenger side sliding doors tend to not open or close correctly sometimes you have to manually pull them open or they do not completely close and you have to bump the back end of it to close right

NHTSA ID

11495404

Incident

Aug 16, 2022

ON SATURDAY AUGUST 29, 2020 I WAS DRIVING IN MY 2002 FORD WINDSTAR DOWN A ROAD THAT WAS UNDER CONSTRUCTION. THE SPEED LIMIT OF THE ROAD IS 35 MPH AND THERE IS A CURRENT BUMP IN THE ROAD AT AN ASPHALT ELEVATION CHANGE. AS SOON AS I WENT OVER THE BUMP IT WAS OBVIOUS THAT SOMETHING WAS SEVERELY WRONG WITH THE VEHICLE. THERE WAS A LOUD "BANG" AND THE VEHICLE BEGAN VIBRATING WILDLY AND MAKING SEVERE NOISES. IT WAS OBVIOUS THAT SOMETHING SIGNIFICANT HAD OCCURRED IN THE REAR OF THE VEHICLE. FORTUNATELY I WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULL ONTO A SIDE STREET SHORTLY THEREAFTER. I EXITED THE VEHICLE AND IMMEDIATELY NOTICED THE REAR DRIVER-SIDE WHEEL WAS ANGLED INTO THE BODY OF THE VAN. UPON FURTHER INVESTIGATION, PEERING UNDER THE VEHICLE IT WAS OBVIOUS THAT THE ACTUAL CAUSE WAS THAT THE VEHICLE'S REAR AXLE HAD FRACTURED NEARLY COMPLETELY THROUGH (SEE PICTURES). IN THIS CONDITION BOTH REAR TIRES COLLAPSED INTO THE VEHICLE FRAME. UPON FURTHER INVESTIGATION I DISCOVERED THAT THERE HAD ALREADY BEEN RECALLS RELATED TO THE REAR AXLE ON THIS VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL FORD DEALERSHIP FOR INSPECTION. AFTER THE INSPECTION, I WAS INFORMED THAT THE PREVIOUS RECALL FOR THE VEHICLE TO INSTALL BRACKETS ON THE AXLE HAD BEEN PERFORMED IN DEC 2010 AND THAT THEY HAD BEEN INSTALLED CORRECTLY. DUE TO THIS, FORD'S POSITION WAS THAT THE RECALL WAS DONE ACCORDING TO SPECIFICATIONS RELATED TO THE RECALLS AND REFUSED TO ACCEPT RESPONSIBILITY FOR THIS SAFETY FAILURE ON THEIR VEHICLE. I TRIED TO CONTEND THAT THE INTENT OF THE RECALL WAS TO PREVENT THE AXLE FROM FRACTURING, WHICH OBVIOUSLY THEIR PREVIOUS RECALL "FIX" DIDN'T APPROPRIATELY ACCOMPLISH. IT WAS A FRIGHTENING EXPERIENCE TO HAVE AN AXLE FRACTURE WHILE DRIVING MY VEHICLE, AND FORD'S PREVIOUS RECALL "FIX" FAILED TO CORRECT THE PROBLEM MAKING THE VEHICLE A HAZARD TO DRIVE.

NHTSA ID

11352877

Incident

Aug 29, 2020

Mileage

160,500 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT WHILE STOPPED, THE CONTACT HEARD AN UNKNOWN PART DETACH FROM THE VEHICLE. THE CONTACT STATED THAT THE STEERING WHEEL THEN BECAME DIFFICULT TO TURN. THE VEHICLE WAS TOWED TO THE RESIDENCE. AN INDEPENDENT MECHANIC WAS CONTACTED BY PHONE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V385000 (SUSPENSION) AND 11V030000 STRUCTURE). THE VEHICLE WAS TAKEN TO METRO FORD CHICAGO (6455 S. WESTERN AVE, CHICAGO, IL 60636, (773)776-7600, TO HAVE THE RECALL REPAIRS PERFORMED. THE CONTACT WAS INFORMED THAT AN UNKNOWN BUSHING NEEDED TO BE REPLACED PRIOR TO THE RECALL REPAIR BEING PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 144,000.

NHTSA ID

11322732

Incident

Aug 30, 2019

Mileage

144,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT NOTICED THAT THERE WAS WATER ENTERING INTO THE VEHICLE FROM THE FRONT WINDSHIELD. IN ADDITION, THE TRIM BY THE FRONT WINDSHIELD AND FRONT FRAME ON THE PASSENGER SIDE WERE RUSTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000. THE VIN WAS NOT PROVIDED.

NHTSA ID

11266730

Incident

Oct 1, 2018

Mileage

125,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. WHILE DRIVING 40 MPH, THE REAR OF THE VEHICLE BEGAN VEERING TO THE RIGHT AND LEFT. THE CONTACT TEMPORARILY LOST CONTROL OF THE VEHICLE, BUT MANAGED TO PULL OVER TO THE SIDE OF THE ROAD. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHO QUICKLY DIAGNOSED THAT THE REAR AXLE WAS RUSTED AND FRACTURED IN HALF. THE CONTACT TOOK THE VEHICLE TO DORIAN FORD (35900 GRATIOT AVE, CLINTON TWP, MI 48035, (586) 792-4100) IN 2016 FOR AN UNKNOWN RECALL REPAIR REGARDING THE BRACKETS FOR THE REAR AXLE. THE DEALER CONFIRMED THAT THEY INSPECTED THE VEHICLE AND PASSED IT ON FEBRUARY 9, 2016. THE DEALER REFERRED THE CONTACT TO THE MANUFACTURER, BUT THEY WERE ONLY CONCERNED THAT THE VEHICLE WAS NO LONGER COVERED BY A WARRANTY AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 113,643. *BF CONSUMER STATED DORIAN FORD DID A RECALL INSPECTION ON FEB 9 2016 AND CERTIFIED THAT THE VEHICLE WAS SAFE CONCERNING THE AXEL. THE MILEAGE AT TIME OF REPLACEMENT IS 113,643. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

NHTSA ID

11182242

Incident

Feb 22, 2019

Mileage

113,643 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE SUBFRAME WAS RUSTED OUT. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11098802

Incident

May 8, 2018

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. WHILE DRIVING AT AN UNKNOWN SPEED, THE REAR AXLE FRACTURED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BEAU TOWNSEND FORD LINCOLN (1020 W NATIONAL RD, VANDALIA, OH 45377, (937) 898-5841). THE DEALER DIAGNOSED THAT THE BRACKETS FAILED TO SECURE THE REAR AXLE, WHICH THEN CAUSED THE REAR AXLE TO PREMATURELY FRACTURE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V608000 (SUSPENSION). THE DEALER DID NOT REPAIR THE VEHICLE BECAUSE THE STATUTE TO RECEIVE THE RECALL REPAIR WAS EXPIRED. THE DEALER AND THE MANUFACTURER REFUSED TO COVER THE RECALL REPAIR. THE CONTACT WAS INFORMED TO REPLACE THE REAR AXLE DUE TO THE MIS-INSTALLATION OF THE BRACKETS. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V385000 (SUSPENSION), AND NHTSA ACTION NUMBERS: EA10007 (SUSPENSION AND STRUCTURE) AND PE10006 (SUSPENSION). THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11082129

Incident

Mar 17, 2018

RH BACK SIDE OF SUBFRAME, IS ROTTED/CORRODED SO BAD THAT THE METAL TORE ALL AROUND THE SUBFRAME BUSHING. TO WHERE IT IS NOT BEING HELD UP BY THE BUSHING ON THE RIGHT HAND LOWER/BACK IS NOT HOLDING UP THE FRONT SUBFRAME... NOW, THE VEHICLE IS MAKING A VERY LOUD POPPING NOISE WHEN DRIVING AND TURNING... AND WHEN TURNING FAST ENOUGH (MORE TURNING LEFT THEN RIGHT) CAN FEEL WHOLE FRONT END JERK LIKE ITS ABOUT TO GO THE OPPOSITE WAY THE VAN...REPLACED THE LEFT FRONT STRUT ASSEMBLY AND CONTROL ARM TO FIND OUT THAT DID NOT SOLVE THE PROBLEM. THEN AFTER REPAIRS AND LOOKING DEEPER.. NOTICED RIGHT FRONT SIDE, SAGGING ALMOST 2-4 INCHES LOWER THEN LEFT FRONT... THAT'S WHEN WE NOTICED THE SUBFRAME COMPLETELY BROKEN/RUSTED OFF FROM THE BODY BUSHING (ON THE FRONT RIGHT LOWER/REAR BUSHING)

NHTSA ID

11076340

Incident

Mar 1, 2018

THE SWEIGH BAR LINKS HAVE BEEN REPLACED TWICE. BREAKS AND ROSTERS TOO! THE TIRES ARE NEW WITH INLINEMENT AND ROTATION DONE! I HAVE WENT THROUGH SEVERAL SETS OF TIRES! THE VEHICLE JUST DOESN'T DRIVE CORRECTLY! THE VEHICLE IS ALSO MISSING WITH NO FOUND REASON AND WILL RANDOMLY DIE! IT FEELS VERY LOSE AND UNSAFE ON THE ROAD! THE COIL PACK, PLUGS AND PLUG WIRES REPLACED! ALL NEW FLUIDS INCLUDING ANTIFREEZE, BREAK FLUID, POWER STEERING FLUID, OIL AND TRANSMISSION FLUID! THE AIR FILTER AND OTHER FILTERS! NEW FUEL PUMP AND IT'S STILL NOT RIGHT! BREAK LIGHT COMES ON AND OFF AND EMERGENCY BREAK ISN'T SET NOR IS IT LOW ON FLUID! NEW BREAKS AND CALIBER AND ROTOR! SERIOUSLY HAVE INVESTED SLOT OF MONEY IN THIS VEHICLE! ALSO MOTOR FOR WINDOWS BEING REPLACED NOW! GAGE HAND WILL PERIODICALLY GO ALL THE WAY TO THE RIGHT THE AFTER A FEW SECONDS GO BACK TO NORMAL! THIS STARTED IN APRIL OF 2017 AND IS STILL CONTINUING

NHTSA ID

11046524

Incident

Nov 15, 2017

Mileage

150,000 mi

FORD HAD PUT THE BRACKETS ON THE REAR AXLE. THESE FAILED. REAR AXLE CRACKED. ALMOST CAUSING MY FAMILY TO CRASH INTO TREE

NHTSA ID

11006723

Incident

Jul 11, 2017

Mileage

117,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. IN 2010, THE DEALER REPAIRED THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 15V608000 (SUSPENSION) CONCERNING THE REINFORCEMENT BRACKETS. WHILE DRIVING APPROXIMATELY 65 MPH, THE REAR AXLE FRACTURED AND THE REAR DRIVER SIDE TIRE BLEW OUT. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS EXTENSIVE RUST AND CORROSION AND THE REAR AXLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

NHTSA ID

10981212

Incident

Sep 28, 2015

Mileage

110,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. WHILE DRIVING APPROXIMATELY 25 MPH, THE FRONT FRAME FRACTURED OR WAS RUSTED, WHICH CAUSED THE PASSENGER SIDE WHEEL TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTO REPAIR GARAGE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V385000 (SUSPENSION). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.

NHTSA ID

10939599

Incident

Dec 24, 2016

Mileage

81,000 mi

DRIVING ON HWY 49 DRIVING APPROXIMATELY 40 MPH WHEN I LOST CONTROL WITH MY CHILDREN IN THE CAR. LUCKILY WE CAME TO A STOP OFF THE HWY. I COULD SEE MY TIRE WAS ALMOST SIDEWAYS AND BLOWN. MY FINANCE PICKED US UP AND SAID THE AXLE HAD SNAPPED AND TOOK A PICTURE. IT IS SATURDAY AND I'M WITHOUT A CAR. I FOUND OUT THIS WAS RECALLED. I JUST WANT TO MAKE SURE FORD WILL FIX THE ISSUE AND IN A TIMELY MANNER SINCE I HAVE NO OTHER CAR.

NHTSA ID

10928050

Incident

Nov 24, 2016

Mileage

161,201 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V030000 (STRUCTURE). THE VEHICLE WAS REPAIRED; HOWEVER, THE VEHICLE FAILED THE ANNUAL SAFETY INSPECTION. THE SAFETY INSPECTOR DIAGNOSED THAT THE SUBFRAME AND BUSHINGS FRACTURED. THE VEHICLE WAS DRIVEN TO A COLLISION SHOP WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS CRACKED. THE VEHICLE WAS DELIVERED TO THE DEALER, BUT NOT DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. UPDATED 10/04/16*LJ *TR

NHTSA ID

10898166

Incident

Aug 15, 2016

Mileage

170,000 mi

HUSBAND WAS GOING TO WORK IN EARLY MORNING AND HAD JUST SLOWED AS HE EXITED HIGHWAY, WENT OVER FIRST SET OF RAILROAD TRACKS AT SPEED LIMIT, THEN THE FRONT END OF VAN RAISED INTO THE AIR ABOUT A FOOT THEN SLAMMED DOWN AS HE CROSSED THE SECOND SET OF TRACKS AND HE LOST CONTROL. HE HAD NO BRAKES OR STEERING AND THE VAN CRASHED INTO A CURB BEFORE STOPPING. IT NARROWLY MISSED GOING UNDER A SEMI-TRUCK. IT TOOK SEVERAL HOURS TO BE TOWED TO FORD DEALER AND MISSING AN UNPAID DAY OF WORK, OUR INSURANCE SECURED A RENTAL CAR SINCE FORD REFUSED TO DO SO. THE 2002 WINDSTAR HAD BEEN PREVIOUSLY REPAIRED UNDER THE 2011 REAR AXLE RECALL 10S13 AND SUBFRAME 11S16 PASSED INSPECTION AT THAT TIME, BUT BOTH APPEARED TO HAVE FAILED IN THIS INSTANCE. THIS FAILURE CAUSED OVER $3000 IN COLLATERAL DAMAGE TO THE STEERING AND EXHAUST SYSTEMS THAT FORD SAYS WILL BE OUR FINANCIAL RESPONSIBILITY IF IT CAN EVEN BE FIXED DUE TO MANY PARTS NO LONGER BEING PRODUCED.THOSE WOULD NEED TO BE FOUND THROUGH SALVAGE OR AFTERMARKET SOURCES. THEY HAVE ONLY OFFERED TO REPAIR THE FAILED SUBFRAME ISSUE AND POSSIBLY THE RECALLED REAR AXLE. WE RECENTLY LEARNED AFTER THIS ACCIDENT THAT THERE WAS A RECALL 15S27 ON THE PRIOR AXLE RECALL REPAIR FOR INCORRECTLY INSTALLED BRACKETS. WE RECEIVED NO NOTIFICATION OF THIS RECALL FROM LATE 2015 TO HAVE THE AXLE FIXED PROPERLY. FORD HAS OFFERED TO BUY BACK THE VAN FOR $1339, WHICH APPEARS TO BE SUBSTANTIALLY LESS THAN WHAT WAS OFFERED FOR BUY BACKS IN 2011 WHEN THE INITIAL RECALL WAS DONE. OUR VAN ALSO HAD ABOUT 40,000 FEWER MILES ON IT THAN VANS OF THE SAME AGE AND MAKE, BASED ON AN AVERAGE OF 15,000 MILES A YEAR. WE HAVE OWNED THIS VAN SINCE 2002 AND BEEN AT OUR SAME ADDRESS FOR 10 YEARS, SO OUR LACK OF NOTIFICATION ABOUT THIS LATEST RECALL IS UNACCEPTABLE. FORD APPEARS NEGLIGENT BOTH IN DEALING WITH A DANGEROUS STRUCTURAL ISSUE AND NOTIFYING OWNERS OF RECALLS TO FIX IT.

NHTSA ID

10894628

Incident

Jul 26, 2016

Mileage

145,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT WHILE AT AN INSPECTION LOCATION, THE MECHANIC DIAGNOSED THAT THE FRONT PASSENGER'S SIDE SUB FRAME HAD FRACTURED DUE TO CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V030000 (STRUCTURE). THE FAILURE MILEAGE WAS 40,000.

NHTSA ID

10839691

Incident

Feb 29, 2016

Mileage

40,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE HAD A FRONT END ALIGNMENT AND OTHER REPAIRS PERFORMED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUB FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. UPDATED 04/14/16*LJ THE CONSUMER STATED THE SUBFRAME WAS COMPLETED CORRODED. *JS

NHTSA ID

10824829

Incident

Nov 21, 2015

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE TIRE BEGAN TO RUB THE INNER FENDER WALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AXLE WAS FRACTURED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 11V030000 (STRUCTURE) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE AXLE SHOULD HAVE BEEN REPLACED INITIALLY UNDER THE RECALL AND NOT BRACKETED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. UPDATED 12/03/15*LJ UPDATED 12/09/15.*JB

NHTSA ID

10746731

Incident

Jul 16, 2015

Mileage

140,000 mi

THEY HAD A RECALL IN 2011 WHERE THEY PUT SUPPORT BRACKETS ON THE REAR AXLES. MINE DID HAVE THE BRACKETS PUT ON AND RIGHT BEHIND THE BRACKET THE AXLE STILL BROKE DRIVING DOWN THE STREET AT 40 MPH WHERE WE ALMOST HIT ANOTHER CAR WITH CHILDREN INSIDE HER AND MY VEHICLE. FORD SAID THE BRACKETS ARE ONLY WARRANTIED FOR 12 MONTHS. THESE VANS DO NOT NEED BRACKETS THEY NEED NEW AXLES. *TR

NHTSA ID

10715920

Incident

May 9, 2015

Mileage

85,000 mi

WHEN BRINGING MY WINDSTAR IN FOR AN ALIGNMENT IT WAS FOUND THAT THE SUBFRAME HAD ROTTED AND CRACKED NEAR THE CONTROL ARM. FORD HAD "COMPLETED" THE NECESSARY REPAIRS TO ADDRESS THIS ISSUE AND HAS STATED THAT THEY ARE NOT RESPONSIBLE FOR THE DAMAGE TO THE VEHICLE EVEN THOUGH IT WAS THE ORIGINAL REASON FOR THE RECALL. ACCORDING TO THE INFORMATION FROM THE ORIGINAL RECALL FORD WAS SUPPOSED TO REPLACE THE SUBFRAME HOWEVER SMALL BRACKETS WERE ADDED TO THE VAN INSTEAD. I DO NOT FEEL THAT THE RECALL WAS PROPERLY DONE BY FORD. *TR

NHTSA ID

10671268

Incident

Jan 9, 2015

Mileage

154,000 mi

TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE DRIVER HIT A BUMP IN THE ROAD AND THE VEHICLE MADE A CRACKING NOISE. UPON INSPECTION, IT WAS FOUND THAT THE PASSENGER REAR WHEEL WELL WAS DAMAGED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 166,000.

NHTSA ID

10627414

Incident

Aug 21, 2014

Mileage

166,000 mi