RoadVitals

2008 GMC C4500

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Sep 19, 2011
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jan 7, 2008
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2008 GMC C4500, most frequently naming the electrical and engine categories. 1 safety recall has been issued covering this model year; and 170 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Electrical150.0%
  • Engine150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
08E004000

EQUIPMENT ADAPTIVE/MOBILITY

Jan 7, 2008
250 units potentially affected
The defect: CERTAIN INTERMOTIVE WHEELCHAIR LIFT INTERLOCK, P/NO. ILIS605-H3 ILIS ACTIVATION KIT (INTERLOCK OPTION FOR GATEWAY 401) SOLD FOR USE AS AFTERMARKET FOR 2005 - 2008 CHEVY 560 (C4500 AND C5500 KODIAK) 6.6L DIESEL VEHICLES WHICH A PROTECTION DIODE WAS USED. THE DIODE CAN BE EXPOSED TO VOLTAGE SPIKES GREATER THAN WHAT IT CAN WITHSTAND. THE DIODE COULD FAIL, WHICH COULD PREVENT VEHICLE INTERLOCK OPERATION WHEN A WHEELCHAIR LIFT IS DEPLOYED.
The risk: SHOULD THE DIODE FAIL, IT WILL BE POSSIBLE TO MOVE THE VEHICLE WITH THE WHEELCHAIR DEPLOYED, WHICH COULD RESULT IN INJURY TO ANYONE USING THE LIFT.
The remedy: INTERMOTIVE WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS CAN CONTACT INTERMOTIVE TOLL-FREE AT 1-800-969-6080. THIS RECALL ONLY PERTAINS TO AFTERMARKET INTERMOTIVE WHEELCHAIR LIFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVRLOT AND GMC VEHICLES MANUFACTURED BY GENERAL MOTORS.
INTERMOTIVE VEHICLE CONTROLSManufacturer number ONP2007-02View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

ElectricalEngine
Filed Sep 19, 2011
Fire reported

AT APPROXIMATELY 2:15 PM ON 9/16/2011 THIS AMBULANCE WAS TRAVELING AT 55-60 MPH IN ROUTE BACK TO THE STATION AFTER DROPPING A PATIENT AT THE HOSPITAL, THE DRIVER REPORTS THAT THERE WAS A LOAD POP!; FOLLOWED BY A HISSING SOUND UNDER THE HOOD. AS HE PROCEEDED TO MOVE TO THE SHOULDER OF THE ROAD TO INVESTIGATE THE PROBLEM THE DRIVER OBSERVED WHITE SMOKE BILLOWING OUT THE BACK OF THE UNIT. BEFORE HE COULD GET STOPPED; THE WHITE SMOKE BEGAN ENTERING THE CAB THROUGH THE AC VENTS. HE PULLED OVER AND AS HE AND HIS EMT PARTNER EXITED THE VEHICLE THE FRONT END OF THE TRUCK ERUPTED IN FLAMES!!! THIS COULD HAVE BEEN A DISASTER HAD THERE BEEN A LIFE EMERGENCY IN THE PATIENT COMPARTMENT. ON 9/19, WE HAD THE UNIT INSPECTED BY THE SHERIFF'S OFFICE FORENSIC DIVISION. DURING THE FORENSIC INSPECTION IT WAS OBSERVED THAT THE RIGHT SIDE ALTERNATOR HAD SEIZED AND BROKEN IN HALF! WHEN THIS EVENT OCCURRED IT SEVERED THE THE AC COMPRESSOR LINES AND POSSIBLY OTHER LINES WITH FLAMMABLE FLUIDS AS THERE ARE PRESSURE AND RETURN LINES FOR ALL TYPES OF FLUIDS(FUEL, BRAKE FLUID, TRANSMISSION FLUID, POWER STEERING FLUID) LOCATED IN THE IMMEDIATE VICINITY OF THE ALTERNATOR. *KB

NHTSA ID
10426321
Incident
Sep 16, 2011

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

13598

New Vehicle Monitoring Programs Section in IVH

PIC5650M

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

PIP5601C

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

GMC C4500 by model year
YearComplaintsRecallsInvestigationsIssue Index
2009000—
2008Viewing110—
2007220—
2006421—
2005220—
2004100—
2003610—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.