2006 GMC Envoy Denali

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

TAKATA RECALL ? AIR RIDE SUSPENSION FAILURE, OVER INFLATION RESULTING IN A EXCESSIVE BOUNCING RIDE AND LOSS OF TRACTION ON OTHER SITES I SEE THAT THIS WAS A 92% COMPLAIN RATE

NHTSA ID

11110006

Incident

Jul 5, 2018

Mileage

155,000 mi

MY 2006 ENVOY DENALI'S LOW BEAM LIGHTS ARE CUTTING OUT ON ME AT NIGHT. I'VE READ SEVERAL CASES ON THE INTERNET THAT THERE WAS A RECALL ON THIS. I'M CONCERNED THAT THIS SITUATION MAY CAUSE AN ACCIDENT AT NIGHT UNEXPECTANY.

NHTSA ID

11075475

Incident

Feb 19, 2018

Mileage

189,000 mi

HEAT NOT BLOWING HOT LIKE PASSENDER SIDE

NHTSA ID

11045406

Incident

Oct 31, 2017

TL* THE CONTACT OWNS A 2006 GMC ENVOY DENALI. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND ALL THE WARNING INDICATORS ILLUMINATED. THE CONTACT MENTIONED THAT WHEN THE VEHICLE WOULD START, IT WOULD CUT OFF IMMEDIATELY. THE VEHICLE WAS TAKEN TO BETTEN BAKER CHEVROLET BUICK GMC (14120 NORTHLAND DR, BIG RAPIDS, MI 49307 (231) 629-4340) WHERE IT WAS DIAGNOSED THAT AN ELECTRICAL FAILURE WAS FOUND, BUT THE DEALER DID NOT KNOW THE EXACT CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 126,000.

NHTSA ID

11035701

Incident

Sep 23, 2017

Mileage

126,000 mi

MY HUSBAND AND I WERE TRAVELING WHEN THE VEHICLE SHUT OFF WITH NO WARNING AT ALL AND ALL THE DASH BOARD LIGHTS CAME ON. THE VEHICLE WOULD NOT RESTART BUT WOULD TURN. THIS HAPPENED SATURDAY 9/2/17 ON A COUNTRY HIGHWAY OUT IN NOWHERE . WE CALLED A TOW TRUCK. THANK GOD FOR CELLPHONES. ON 11/12/2016 HUB BEARINGS REPLACED. 11/15/16 MODULE AND CONNECTOR REPLACED AND FUEL LEVEL SENSORS AND RING REPLACED. THREE YEARS AGO A/C WENT OUT. REPLACED.

NHTSA ID

11021659

Incident

Sep 2, 2017

Mileage

90,447 mi

AT EVERY FILLUP WE CAN SMELL GAS LIKE THERE IS A FUEL LEAK. I HAD A SHOP DO A FOG TEST AND THEY CONFIRMED A LEAK "SOMEWHERE FROM THE TOP OF THE TANK". THE TANK WOULD NEED TO BE DROPPED TO VISUALLY INSPECT AT A COST OF $400-$500 JUST FOR THE DROPPING OF THE TANK. THEN THERE WOULD BE ADDED COSTS TO REPAIR WHATEVER IS CAUSING THE LEAK AND SMELL OF GAS. AFTER HEARING THAT I CAME HOME TO START MY SEARCHING FOR RECALLS & SAFETY NOTICES TO FIND THAT GM HAD A NOTICE ISSUED AS WELL AS THE NHTSA, BUT IT SEEMS THEY CUT THE YEAR OFF AT 2004 & 120,000 MILES. ACCORDING TO THE THREAD BELOW, IT APPEARS THIS WAS EXTENDED TO VEHICLE UNDER 150,000 MILES WHICH WE ARE WELL UNDER, BUT WE DON'T HAVE A 2002-2004 MODEL. THREAD - HTTP://FORUMS.TRAILVOY.COM/SHOWTHREAD.PHP?T=22530 VIN - [XXX] A VIN SEARCH FOR THIS ENVOY DIDN'T BRING UP THE FUEL LEAK ISSUES, BUT WE CAN SMELL GAS & CONFIRMED A LEAK EXISTS ON THE TOP OF THE TANK SOMEWHERE. WAS THIS PROBLEM EVER REPORTED FOR NEWER MODELS YET? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11020894

Incident

Aug 31, 2017

Mileage

108,000 mi

TAKATA RECALL, GAS GAUGE WILL ONLY SHOW EMPTY.

NHTSA ID

10966334

Incident

Jan 1, 2015

Mileage

820,000 mi

LOW BEAM HEADLIGHTS AND DAYTIME RUNNING LIGHTS HAVE BEGAN FAILING INTERMITTENTLY. VEHICLE WAS IN MOTION. LOW BEAMS FAILED ON AN UNLIGHTED INTERURBAN HIGHWAY AT NIGHT. SCARY! THEY STAYED OFF FOR ABOUT 5 MINUTES, AND THEN RETURNED TO OPERATION. DURING THIS TIME I WAS DRIVING, TRYING TO VACATE THE HIGHWAY, USING HIGH BEAMS AND FOG LAMPS. DTL FAILURE NOTICED WHEN ENTERING GARAGE. HEADLIGHT DELAY ALSO FAILS AT THESE TIMES. LOSING LIGHTS AT 45 MPH ON A DARKENED ROAD IS VERY UNSAFE. DEALER SERVICE DEPARTMENT SAYS PROBLEM MAY BE A LIGHT RELAY THAT IS KNOWN TO HAVE ISSUES.

NHTSA ID

10927503

Incident

Nov 18, 2016

Mileage

82,600 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.