2001 GMC Safari

IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.

AFTER RUNNING ERRANDS, VEHICLE WOULD NOT RESTART. TIME IN BETWEEN ERRANDS 2 HOURS. OUTSIDE TEMP 95. HAD TO WAIT 15 - 30 MINUTES IN HOT VEHICLE TRYING TO START VEHICLE EVERY 20-30 SECONDS. PROBLEM WITH PASSLOCK/PASSKEY SECURITY SYSTEM AS LISTED ON VARIOUS WEB SITES. CHECKED WITH PERSONAL OBD II & CAN SCAN TOOL AND FOUND NO DTC'S. THIS PROBLEM IS BECOMING MORE CONSTANT AND OCCUPANT SAFETY IS A MAJOR CONCERN. *TR

NHTSA ID

10618144

Incident

Jul 31, 2014

Mileage

84,300 mi

AFTER RUNNING ERRANDS, VEHICLE WOULD NOT RESTART. BRAKE & ABS INDICATOR LIT. WAIT 15- 30 MINUTES AND VEHICLE MAY RESTART. INDEPENDENT RESEARCH FOUND THAT THIS IS A WELL KNOWN PROBLEM. NOTED: PASSLOCK/PASSKEY SECURITY SYSTEM INTERMITTENT FAILURE. *TR

NHTSA ID

10618133

Incident

Jul 2, 2014

Mileage

84,300 mi

AFTER FUELING, COULD NOT RESTART VEHICLE. DASH LIGHTS. HAD TO WAIT 15 - 30 MINUTES UNTIL I WAS ABLE START VEHICLE. BATTERY 4 MONTHS OLD, INTERMITTENT ONGOING PROBLEM. INDEPENDENT RESEARCH DISCOVERED VIA WEB SEARCH LIST PROBLEM WITH "IGNITION PASSLOCK/PASSKEY SECURITY SYSTEM". THIS IS A MANUFACTURING DEFECT THAT MY LOCAL GM DEALER WILL NOT ADDRESS OR FIX. ESTIMATED CONSUMER REPAIR COST OVER $1000,00. *TR

NHTSA ID

10618129

Incident

Jul 29, 2014

Mileage

84,300 mi

AT TIMES VEHICLE WILL NOT START UNTIL THE STEERING COLUMN SHIFT LEVER IS MOVED. ALL POWER IS UP, TURN KEY AND NO RESPONSE. DEPRESS BRAKE PEDAL AND MOVE SHIFT LEVER FROM P TO D3 MAY CAUSE STARTER TO WORK. TOLD BY AAA DRIVER THAT THIS IS A COMMON PROBLEM. *TR

NHTSA ID

10593090

Incident

May 19, 2014

Mileage

81,500 mi

AT SLOW SPEEDS THE ABS ACTIVATES AND THE VEHICLE IS HARD TO STOP. THE SIERRA VAN USES THE SAME COMPONENTS AS THE TRUCKS THAT WERE RECALLED BY 05V379000 ON 8/3/05. THE PROBLEM IS THE SAME WITH DIRTY SPEED SENSORS. *KB

NHTSA ID

10419790

Incident

Aug 12, 2011

Mileage

84,300 mi

TL*THE CONTACT OWNS A 2001 GMC SAFARI. THE CONTACT STATED THAT THE VEHICLE VIBRATES, BACKFIRES, AND FAILS TO START WHEN COLD. HE HAS NOT TAKEN THE VEHICLE TO A DEALER. NHTSA SERVICE BULLETIN NUMBER 03-06-04-041 WAS REFERENCED. THE CURRENT MILEAGE WAS 94,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 03-04-08 *BF WHEN THE VEHICLE DID START, IT WOULD RUN ROUGH AND THEN STALL. UPDATED

NHTSA ID

10215966

Incident

Aug 26, 2005

Mileage

50,000 mi

DT*: THE CONTACT STATED THE VEHICLE'S ANTI LOCK BRAKING SYSTEM SENSORS WERE FAULTY AND ACTIVATED ON DRY PAVEMENT AT A SPEED OF LOWER THAN 8 MPH. THERE WERE NO WARNING SIGNAL TO INDICATE A FAILURE. THE FAILURE OCCURRED UNDER NORMAL BRAKING. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC WHO ADVISED FILING A COMPLAINT WITH THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION. THE MANUFACTURER HAS NOT BEEN NOTIFIED YET BY THE CONTACT.

NHTSA ID

10163305

Incident

Jun 5, 2006

Mileage

69,000 mi

PASSENGER SIDE POWER WINDOW GOES PART WAY DOWN, WILL NOT GO OUT - INTERMITTENT PROBLEM INCREASED TO PERMANENT PROBLEM. NOW GOES DOWN MAYBE 1/2 INCH, ONLY GOES UP 1/32 INCH AT A TIME. HAS BEEN REPAIRED TWICE, NEEDS REPAIR AGAIN. I PURCHASED THE VEHICLE USED IN 6/03, NOT LONG AFTER THAT, PROBLEM SURFACED IN INCREASING REGULARITY. WHEN I HAD PROBLEM REPAIRED BY DEALER IN 1/04, I WAS TOLD THIS HAD BEEN REPAIRED BEFORE. ITEMS REPAIRED / REPLACED, WERE: 1314WSC95 - ELECTRICAL MISC. PO45391 - MOTOR PO45386 - ACTUATOR SEVERAL RIVETS. THE REPAIR FACILITY DESCRIBED THE WINDOW PROBLEM AS "BINDING", AND A ALSO FOUND THAT THE DOOR LOCK WAS NOT ACTIVATING PROPERLY DUE TO A DOOR LOCK MECHANISM PROBLEM (THE ACTUATOR) AS HAVING AN "INTERNAL SHORT". THE REPAIR OF 1/04 WAS GOOD FOR ABOUT 14 MONTHS (DEALER REFUSED TO WARRANT WORK), WHEN IN 3/05, THE PROBLEM HAD GRADUALLY RETURNED. WHEN I ASKED THE DEALER IF THIS WAS A COMMON PROBLEM, HE SAID IT WAS NOT. I RECENTLY DECIDED TO LOOK INTO THE PROBLEM AS I AM ABOUT TO HAVE IT REPAIRED AGAIN, AND SEE THAT THE PASSENGER WINDOWS ON GMC VANS HAVE BEEN A PROBLEM FOR A LONG TIME. I BELIEVE THE MALFUNCTIONING WINDOW IS A HAZARD, AS IT CREATES A DANGEROUS SITUATION FOR THE DRIVER WHEN DISTRACTED BY A MALFUNCTIONING WINDOW, WHICH IS USED TO PROTECT THE VEHICLES OCCUPANTS FROM WEATHER, SMOKE, DUST AND DIRT, WIND AND EVEN POTENTIAL CRIMINALS. MY ATTENTION HAS BEEN DRAWN AWAY FROM THE NORMAL HAZARDS OF URBAN AND HIGHWAY DRIVING BY THE DISTRACTION OF A MALFUNCTIONING WINDOW. WHY HAS THIS BEEN ALLOWED TO BE A PROLIFIC PROBLEM FOR SO LONG? I WONDER JUST HOW MANY COMPLAINTS YOU HAVE RECEIVED ON THIS ISSUE? DOES SOMEONE HAVE TO ACTUALLY DIE BEFORE YOU TAKE ACTION? *NM

NHTSA ID

10163169

Incident

Mar 1, 2006

Mileage

84,537 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.