RoadVitals

1992 GMC Safari

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
59
Latest Aug 9, 2006
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest May 19, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
6
3 injuries, 0 deaths reported

Overview

Our database contains 59 NHTSA owner-reported complaints for the 1992 GMC Safari, most frequently naming the brakes, suspension and electrical categories. 3 safety recalls have been issued covering this model year; and 10 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes2845.9%
  • Suspension1118.0%
  • Electrical58.2%
  • Seat belts46.6%
  • Interior & seats34.9%
  • Transmission23.3%
  • Driver assistance23.3%
  • Other / unspecified23.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06E043000

FUEL SYSTEM, GASOLINE

May 19, 2006
88,303 units potentially affected
The defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
The risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov
06E041000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

May 18, 2006
7,800 units potentially affected
The defect: CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
The risk: A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
The remedy: R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
R&B, INC.View on NHTSA.gov
93V119000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

Aug 2, 1993
341,364 units potentially affected
The defect: SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
The risk: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
The remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
GENERAL MOTORS CORP.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 59
Suspension
Filed Aug 9, 2006

DT*: THE CONTACT STATED THE VEHICLE'S FRONT SUSPENSION DROPPED ONTO THE FRONT TIRES WHILE THE VEHICLE WAS PARKED AND NOT IN USE. THE CONTACT ATTEMPTED TO REPLACE THE SHOCKS TO RESOLVE THE ISSUE BUT THE SHOCKS DID NOT RESOLVE THE PROBLEM. THE DEALER WAS NOT CONTACTED. THERE WAS NOTHING THAT LED UP TO THE OCCURRENCE.

NHTSA ID
10165082
Incident
Aug 7, 2006
Mileage
130,000 mi
Interior & seats
Filed Aug 8, 2005

AS FOR EVENTS LEADING UP TO THE FAILURE, I AM NOT AWARE OF ANY. I OPENED THE DOOR OF MY VAN AND FOUND THE SMELL OF MELTING PLASTIC COMING OUT OF IT. AFTER FURTHER INSPECTION I FOUND THAT MY CIGARETTE LIGHTER, WHICH I USUALLY DON'T HAVE IN THE PLUG, BECAUSE I USE THE PLUG FOR TOO MANY OTHER THINGS HAS MELTED AND WAS STUCK INSIDE MY DASH. AFTER TAKING THAT PANEL OFF TO SEE IF I COULD GET THE LIGHTER OUT OF THE PLUG, I ATTEMPTED TO UNPLUG THE WIRES BUT WHILE DOING THIS THE SMALL AMOUNT OF THE PLUG THAT WAS STILL ATTACHED TO THE DASH BROKE FREE AND STARTED SPARKING. AT THIS POINT IT BLEW A FUSE SO I CUT THE WIRES JUST TO BE SAFE AND TAPED THEM SEPARATELY WITH ELECTRICAL TAPE. LATER THAT NIGHT I COULD SMELL ANOTHER BURNING TYPE SMELL BUT IT WASN'T UNTIL THE NEXT MORNING THAT I FIGURED OUT WHAT IT WAS. NOW WHENEVER I USE MY HEATER/AC THERE IS SMOKE THAT COMES OUT FROM BEHIND THAT INSTRUMENT PANEL. WHEN THE FUSE BLEW I LOST ALL THE INTERIOR LIGHTS AND I AM AFRAID THAT IF I REPLACE THE FUSE THAT THE CIGARETTE PLUG WILL START SPARKING AGAIN. SO AS IT STANDS NOW THE CIGARETTE LIGHTER IS GONE, I HAVE NO INTERIOR LIGHTS AND I CAN'T USE MY HEATER OR A/C. I DID KEEP THE LIGHTER THAT WAS ALL MELTED. *NM

NHTSA ID
10131869
Incident
Aug 4, 2005
Seat belts
Filed Oct 4, 2004

I HAVE A 1992 GMC SAFARI VAN. IT HAS NO ANCHOR SYSTEM FOR A CHILD SEAT AND GMC CUSTOMER SERVICE INDICATES NO REQUIREMENT FOR SUCH A SYSTEM. IT IS MY OPION THAT JUST LIKE OTHER VEHICLES THE VAN SHOULD HAVE AN ANCHOR SYSTEM FOR THE CHILD SEAT AND THE MANUFACTURER SHOULD BE REQUIRED TO SUPPLY SUCH A SYSTEM. *AK

NHTSA ID
10093562
Incident
Oct 4, 2004
Suspension
Filed Sep 17, 2004

WHILE WIFE AN FAMILY WERE IN VAN, PASSENGER SIDE TORSION BAR SNAPPED, SLAMMING RIGHT FRONT OF VEHICLE DOWN. AWD DIFFICULT TO CONTROL AND CAUSING FAMILY TO BECOME STRANDED. GM HAS DISCONTINUED REPLACEMENTS, A CONVERSION IS AVAILABLE FROM THEM FOR OVER $500.00 AND BOTH SIDES NEED TO BE REPLACED/MODIFIED. *AK

NHTSA ID
10091176
Incident
Sep 16, 2004
Mileage
54,800 mi
Suspension
Filed Aug 12, 2004

THE CONSUMER NOTICED THAT THE FRONT STABILIZER BAR SNAPPED IN TWO PLACES, CAUSING THE VEHICLE TO BECOME INOPERATIVE. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK *SC *JB

NHTSA ID
10081562
Incident
May 7, 2004
Mileage
171,000 mi
Brakes
Filed Apr 1, 2004

ABS SYSTEM FAILED. DEALER STATED THAT IT WAS NOT A SAFETY ISSUE, THEY STILL HAD BRAKES. *AK ABS FAILED WHEN CONSUMER PRESSED ON THE BRAKES TO AVOID COLLISION WITH ANOTHER VEHICLE. ABS LIGHT CAME ON AND STAYED ON. THE LOSS OF ABS WAS CAUSED BY THE FAILURE OF INTERNAL BRAKE MODULE. CONSUMER DECLINED REPLACEMENT BECAUSE WHEN HE WAS QUOTED BY THE DEALER OF THE EXPENSE FOR REPAIR, COST WAS $1300, AND WAS TOLD THAT VEHICLE WILL STILL HAVE THE SAME BRAKING CAPABILITY EVEN WITHOUT ABS. IN ADDITION, RECALL ON DIPSTICK, TO INDICATE TRANSMISSION RESEVOIR. IF DIPSTICK IS SHORTER, IT WOULD CAUSE TRANSMISSION TO SLIP. *LA

NHTSA ID
10059838
Incident
Feb 21, 2004
Mileage
68,500 mi
Brakes
Filed Mar 9, 2004

WHILE APPLYING THE BRAKES ABS LIGHT APPEARED ON THE DASHBOARD, AND REMAINS ON UNTIL THE VEHICLE WAS TURNED OFF. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC COULD NOT DUPLICATE OR RESOLVE THE PROBLEM. *AK

NHTSA ID
10061741
Incident
Mar 9, 2004
Brakes
Filed Feb 15, 2002

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID
758274
Incident
Jan 31, 2002

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIT-3665-A

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

GENERAL MOTORS: ON ALL 1988-2009 FULL SIZE CHEVROLET/GMC PICKUPS, UTILITIES AND VANS, THE BRAKE PEDAL WILL MOVE DOWN OR SELF APPLY DURING FULL LOCK TURNS OR NEAR FULL LOCK TURNS. CHEVROLET ASTRO AND GMC SAFARI VANS; HUMMER 2 ARE INCLUDED. *PE UPDATED 5/24/11. *PE

020730024A

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT

01667

VISIBILITY

WINDOW REGULATOR MOTOR DOES NOT FIT. *TT

990730016A

POWER TRAIN

DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT

96067A

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

SPECIAL POLICY ADJUSTMENT - LINEAR EXHAUST GAS RECIRCULATION SYSTEM. *TW

236111

ENGINE AND ENGINE COOLING:ENGINE

CPI ENGINE NOISE (INSTALL NEW GEARS/NEW MEM-CALS). *SD

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

GMC Safari by model year
YearComplaintsRecallsInvestigationsIssue Index
2005420—
2004520—
2003183048.6
2002253158.0
2001393154.3
2000682052.2
1999613050.8
1998895053.0
19971356157.3
19961396155.9
19951956261.9
19941192156.5
1993612052.5
1992Viewing593052.1
1991394465.3
1990354456.8
1989184159.1
1988736—
1987112656.6
1986725—
1985135—
1984001—
1983001—
1982001—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.