Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 2014 GMC Sierra 1500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 72 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 72, in the owner's own words
The contact owns 2014 GMC Sierra 1500. The contact software modification done at a transmission shop, affected the Active Fuel Management not allowing diagnostic. The manufacturer was not notified of the failure. The approximate failure mileage was 210,000
6.2L Engine has well documneted problem with the valvetrane, I have had to fix it 2 times in 3 months. I have pictures and documents from servicing dealerships. Since my ownership, it has always been dealer-serviced. Unexpected catastrophic engine failure, which happened on a major interstate. GM service technicians know there is a valvetrane issue. This instance, the warning light came on under and overpass, and the truck coasted to a stop just past the end of the on-ramp. A GM (Chevrolet dealership currently has it) and a GMC dealership has serviced it since my ownership.
The contact owns a 2014 GMC Sierra 1500. The contact stated that while at a stop sign, the vehicle stalled. No warning lights were illuminated. The vehicle was towed back to the residence. A dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact researched and became aware of an undisclosed recall; however, the VIN was not under recall. The manufacturer was not notified of the failure. The failure mileage was approximately 81,000.
The vehicle experienced complete lifter failure on cylinder number 4 bending the intake valve push rod thus shutting down the cylinder. The vehicle has 167,000 miles and is well maintained. The vehicle gave no warning signs that there was a problem. Simply driving down the road, normal engine temperature, normal oil pressure, the check engine light comes on at the same time the engine begins to mis-fire. Pulling over to the side of the road, I could hear lifter noise from the right bank of the engine. The dealership (Ocean Crest Chevrolet/GMC Warrenton, Oregon) confirmed the damage. The mechanic and the service manager both state the damage is a direct result of the GM cylinder deactivation system, and every single one they have repaired has been cylinder number 4. They further stated that GM has recommended a lifter change when repairing the damage, in other words, the lifters that were installed when the engine was originally built are defective. This damage occurs on both the 5.3 and the 6.2 with cylinder deactivation, and according to the dealership, it begins with cylinder number 4. This problem has also been responsible for cam damage which results in total engine replacement/rebuild due to metal contaminating the oil.
Engine failed December 2024 at 140,274 miles. 2 cylinders failed due to lifter failure and had a total loss of power. Engine was replaced by a local shop.
hard shifting transmission and fluid smells burnt, shifts hard in the lower gears and reverse
Vehicle stalling at low speeds Oil pressure solenoid stuck fault and P0011 camshaft fault.
Truck completely shuts off at any speed going down the highway. Complete loss of power. Have to coast to side of road and restart vehicle.
The contact owns a 2014 GMC Sierra 1500. The contact stated that while driving on the highway at 55 MPH, the vehicle lost automotive power and the steering wheel became stiff. The contact stated that the vehicle decelerated to 20 MPH, with several unknown warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed, and the contact was informed that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 101,000.
The engine has 160,000 miles and just driving the camshaft and the lifters went out during normal driving. It showed no problems before hand. I’ve heard from multiple people that this is a big issue with the 6.2l gmc Sierra engines. The mechanic also stated it’s there biggest problem. The repair cost are $4,000 - $6000 dollars and the have to pull the whole engine and just fixing those two things. The cost of an engine is $7000 for a used with 100,000 miles and to me it would just happen again in around 60,000 miles or less. For a new engine non oem so an off brand it would cost $8,00 - $10,000 just for the engine. Almost as much as the truck cost not including the labor. This is completely unacceptable cost for repair for a common problem with this truck.
The contact owns a 2014 GMC Sierra 1500. The contact stated while driving 60 MPH, the check engine warning light illuminated. There was an abnormal knocking sound coming from the engine. The contact determined that the engine had seized. The contact stated that the failure was related to NHTSA Campaign Number 25V274000 (Engine and Engine Cooling). The vehicle was towed to the local dealer, where it was diagnosed and determined that the failure was due to the lifters, and there was low compression in the engine. The vehicle was not repaired. The vehicle was towed to an independent mechanic. The manufacturer was not contacted. The failure mileage was approximately 100,000.
I am the original owner of a 2014 GMC Sierra 1500 (VIN: [XXX] ) and began experiencing serious mechanical and electrical issues while the vehicle was still under warranty around 40,000 miles. These included engine RPM fluctuations at idle, vibrations under acceleration above 65 MPH, and intermittent misfiring — all symptoms that are now believed to be early indicators of defective lifters or valve train components. I also experienced repeated electrical failures including a rear turn signal malfunction due to melting/corroded taillight sockets, a thumping rear-end noise, differential knocking, and body panel issues (hood lifting at highway speeds). These were reported multiple times to authorized GMC dealers (Mike Haggerty GMC and Rizza GMC), but I was told there was no issue or no repairs were made. GM refused to assist when I escalated the issue in 2017 via a detailed email, despite all problems occurring within the warranty period. I’m now dealing with a persistent ticking sound from the engine and loss of power, which matches widespread reports of lifter failure in GM’s 5.3L/6.2L V8 engines. These failures pose both a mechanical and safety risk due to stalling, misfiring, and potential electrical fires (in my case, from a failed taillight socket). A class action lawsuit ([XXX], et al. v. General Motors LLC) has been filed regarding these known defects, yet GM has not issued a recall. I’m filing this complaint to add my case to the record and urge NHTSA to investigate these issues. I have full documentation of the original complaint and am willing to provide it upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Timing chain broke with no warning and seized engine. Complete engine failure. Engine had to be replaced. Engine was inspected and replaced by certified gm dealer.
I know this is a well known issue with these trucks. Have had issues with power steering not working at low speeds which they claim it’s do to low voltage. This has happened numerous times and then on May 3rd I went to back into my driveway off a busy state route with hills on each end of the road. Put my hazard lights on let three vehicles pass and then I turned the wheel and gave it gas soon as the truck got into the middle of the road it shut off. Everything stopped working no hazard lights for about 10seconds and then I had to put the truck into park turn ignition key off and then back on to restart the truck. Again this is all do to low voltage from what everyone else has said with the same issue. There are no warnings what so every even the voltage meter is fine and the truck doesn’t hesitate at all it’s like someone disconnected the battery. I’m sure there is a way for GM to reprogram the pc for the voltage drop. At least have something like radio go out or ac, heat other than the engine and entire electrical shutting off. Something like this is going to get someone killed and GM should be held accountable for these problems.
The contact owns a 2014 GMC Sierra 1500. The contact stated while driving 50 MPH, the passenger’s side headlight became inoperable. The contact stated that several unknown warning lights flashed on the instrument panel. The contact pulled over to inspect the vehicle and discovered that the water pump had failed. Despite the failure, the contact managed to drive the vehicle home. The next day upon starting the vehicle, the check engine warning light illuminated and both engine fans began to run at full capacity. The contact called the dealer and made an appointment for a diagnostic test. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 160,000.
Oil pressure pump failed to keep pressure despite regular maintenance.
The contact owns a 2014 GMC Sierra 1500. The contact stated while driving approximately 65 MPH, the vehicle lost motive power and shut off. The failure recurred on several occasions. There were no warning lights illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the failure was due to the oil pump, which had gone into low-pressure mode and shut down the engine. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed that the repairs were not covered under a recall. The manufacturer referred him to NHTSA. The approximate failure mileage was 186,000.
Engine lifters keep going bad. The frame is rotting like I have never seen. Body is rusting out for second time. Blows lights every month. Rain getting in headliner and under rear seat. Ac breaks every year. All around worst fucking vehicle I have ever owned. Gmc will not do anything about this. I'm tried
What component or system failed or malfunctioned, and is it available for inspection upon request? How was your safety or the safety of others put at risk?: The truck just stalls and dies without warning, all lights go off inside and outside and all power is lost. From digging on the internet, I found out the problem is due to one or more rusty/defective connection to ground which stops current from flowing and therefore stalls the vehicle and turns everything off. When the truck stalls, power steering and power assisted breaks are not available and this makes the truck very difficult to guide/stop for most people, making it a significant safety risk to occupants as well as others as the likelyhood of a collision increases significantly. In addition, since all electric accessories are disconnected, warning/flashing lights can not be turned on to advise others that the truck has stopped. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem is hard to reproduce because it happens at random times, it has happened to me at least 5 times in the last month or so. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO warning messages or other symptom.
My lifters bent and my valves collapsed. I have had the vehicle repaired twice. No engine light warning. Also in Nov of 2022 oil is leaking into my cylinders. Common problem on several GM forums.
Going under 15mph, applying the brake causes the pedal to become stiff and lock up and not work. This has caused me to almost hit someone in traffic. I immediately got off the road and got my vehicle to a safe location off the road . Communicating with a dealer today to confirm possible recall issue or potential repairs.
I had the a/c condensor and low pressure line replaced due to the cracked welds on condensor
The contact owns a 2014 GMC Sierra 1500. The contact stated that while her husband was driving approximately 65 MPH, the vehicle lost power steering functionality. The contact stated that an unknown warning light was illuminated and then disappeared. The contact stated that the loss of power steering functionality had increased over time. Additionally, the vehicle had started to stall at low speeds. The contact researched online and related the steering failure to NHTSA Campaign Number: 17V414000 (Steering). The contact noticed that the "Service Park Assist" light was illuminated when the vehicle stalled. The contact had taken the vehicle to a local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 215,000.
the catalytic converter failed at 110,000 miles and the brake boost hydraulics failed to work properly at 115,000. The electronic stability control started acting erratically at 115,000 miles also.
My truck recently had an engine lifter fail when pulling out onto a very busy road. When I accelerated hard into traffic my check engine came on and I suddenly lost most of the engine power and it went into limp mode. I was almost rear ended when my truck nearly came to a stop. I was told it is a defective/poor design of the cylinder deactivation system from the dealer. Ther is no fix but to replace with the same lifter part number which was done and it also failed again 4 days later in a similar situation turning onto a road into traffic. My truck is now back in the shop to have lifters replaced twice in one weeks time.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .