2022 GMC Sierra 1500 Engine Problems

Vehicle has been maintained at GM authorized dealership according to manufacturer recommendations. 6.2L recall was performed as recommended by manufacturer at approximately 25k miles. Engine failed at 36000 miles. The failure created a safety situation where vehicle suddenly lost propulsion power on the interstate. GM replaced the engine with a remanufactured engine. Vehicle was out of service for approximately 90 days. My family has lost confidence in the vehicle and unfortunately because of the now known issues with this engine the vehicle has lost significant value, making it nearly impossible to trade the vehicle in for something reliable.

NHTSA ID

11766321

Incident

Jul 20, 2026

At around 1,500 miles the truck reduced power. I was able to drive it to the dealership. The dealership reported the lifters had failed and it would be 5-6 months to repair because of the parts shortage.

NHTSA ID

11764642

Incident

Feb 13, 2022

While driving down the street pulling a trailer the engine stopped. I was able to get it to the side of the road. I called the GMC dealer and they dispatched a wrecker. No prior warnings, just a check engine light right before it failed and lost momentum. This is the second of three new trucks from GMC with engine failure, 1st was lifters, and the other two were bearing locked up. All maintenance was performed by the Dealership on all three trucks

NHTSA ID

11764641

Incident

Mar 29, 2023

No warning. It’s been replaced by Gm and a week later now it’s in the shop again because it’s acting up.

NHTSA ID

11763868

Incident

Feb 1, 2026

I purchased said vehicle with a little over 76,000 miles on XXX from NW Chevrolet, [XXX]. Dealership service the engine on XXX and remained on their lot until it was sold. While driving home, I smelled gas fumes coming into the cabin and the engine was misfiring causing slight hesitation in motor acceleration while adjusting to speed limits and climbing hills. I told management at the dealership about these issues on XXX. My vehicle is currently in the shop to fix the fuel injection system, spark plugs, grounding issues as of XXX to fix the dealerships mistake costing more out of pocket expense. Management will not do anything about it because it was sold (As Is) without a warranty which I refused to purchase through finance and interest charges on a car loan. I purchased a 4-year warranty through Endurance on XXX with a 30 day wait period before filing a claim. GM is letting their dealerships advertise and sell problem vehicles with known motor issues to consumers while marking up the sale price. Vehicles should never be sold until GM fixes all motor defects before advertising to the consumer. The consumer is at serious financial risk when getting an auto loan paying on a broken vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11763367

Incident

Sep 4, 2026

P2101 Reduced Engine Power Idle instabilitystruggling to idle correctly, hunting/surging slightly, and possibly going into reduced-power protection mode. While driving engine reducing power, struggles then surges forward. Ive taken it to GMC however the techs say they have to experience the situation themselves and are unable to diagnose

NHTSA ID

11762547

Incident

May 31, 2022

engine failure

NHTSA ID

11761681

Incident

Sep 1, 2026

The contact owns a 2022 GMC Sierra 1500. The contact stated that while driving approximately 65 MPH, the transmission shifted to neutral(N), and the contact was unable to control the vehicle. The vehicle was coasted to the side of the road, and the transmission failed shift into park(P), reverse(R), or drive(D). The message "Conditions no Longer Exist for Driving," was displayed on the screen. The vehicle was towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The contact was informed that the nuts were welded to the engine, causing a failure with the engine overheating. The failure also occurred while driving 65 MPH, and the transmission shifted into neutral with the same message displayed on the screen. The vehicle was towed back to the dealer, and it was diagnosed with engine failure. The contact stated that the engine was replaced. The dealer informed the manufacturer of the failure. The failure mileage was approximately 34,000.

NHTSA ID

11761210

Incident

Feb 1, 2024

Mileage

34,000 mi

I just had to put my 4th engine in my 22 Sierra at4 with the 6.2 V8. I currently have 103k miles

NHTSA ID

11761156

Incident

Aug 5, 2026

The contact owns a 2022 GMC Sierra 1500. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); the vehicle was inspected, and the engine oil was replaced with a higher viscosity oil. The contact stated that later while operating the vehicle, the engine was knocking, and the vehicle was taken back to the dealer to be diagnosed. The contact was informed that there were metal shavings inside the engine oil, and the engine was replaced. The manufacturer was notified of the failure. The failure mileage was 22,700.

NHTSA ID

11760944

Incident

Aug 31, 2024

Mileage

22,700 mi

The contact owns a 2022 GMC Sierra 1500. The contact had experienced several catastrophic failures with the engine and transmission. The contact stated that while driving 40 MPH, the vehicle shut off without warning, and lost power. The vehicle was towed to a dealer for an engine replacement. On another occasion while driving 65 MPH, the vehicle shut off without warning and the wheels locked up. The vehicle was towed to GMC of Rochester (4646 E Frontage Rd, Rochester, MN 55901), where a second engine failure was diagnosed and the vehicle was repaired under an extended warranty. Upon retrieving the vehicle, the vehicle was hesitating while depressing the accelerator pedal, with the messages "Reduced Engine Power" and "Check Engine" displayed. While attempting to reverse(R) into a driveway, the vehicle became immobile. The vehicle was towed to Red Wing Chevrolet (2500 US-61, Red Wing, MN 55066), and the technician diagnosed the vehicle with total transmission failure. The contact was informed that there was heavy metal debris inside the transmission pan. The manufacturer was notified of the failure but declined to assist. The vehicle remained with the dealer. The failure mileage was 12,000.

NHTSA ID

11760940

Incident

Apr 1, 2023

Mileage

12,000 mi

My truck has the same issues for the transmission and engine problems I have taken it to 4 dealerships and they all say the same thing. The first one I spent about 3 hours there and they changed the 20 oil to the 40 oil and said that will fix the issues but it hasn't i called GMC to report this and they sent me to the others but they said it's been looked at and I know one of them didn't do anything to see the issue.Gmc called the other day and I told them I will let the engine locked up or the transmission keep doing the same thing and they'll have to fix the issue then.I do have 109000 miles on it but thus issue has been going on for 4 years they said I have 150000 miles for the issue but I do t think that is right.I paid them cash money for the truck when I bought it

NHTSA ID

11760765

Incident

Aug 30, 2026

I bought this truck from a dealer at the end of july 2026 and it only had 27k miles on it. I got the carfax and saw all the times of service and checked that this truck was inspected and went to the new oil type, filter and cap. It also was showing it had the special warranty due to recall. So i assumed everything was good to go and the truck was relaicle. Not even 18 days later and less than 800 miles I broke down mid drive. I was traveling at 45 mph and lost all power and almost caused an accident trying to get over and parked safely. There was no warning light or indication of it breaking down or having a mechanical issue. It went to the dealer and they diagnosed it as complete engine failure due the issue GM is having currently. They did order a new motor and it took two weeks to get in but they are in the process of the engine swap as we speak. I am sure i will get more details this week....but I am concerned now amd honestly wish I wouldnt have bought this truck considering I am seeing reports of new motor swaps having catastrophic engine failure two or three times. So at this point im in limbo waiting for the new install and hopefully it doesnt fail again

NHTSA ID

11760720

Incident

Aug 14, 2026

Early this year the crankshaft seized while driving. The engine was promptly replaced and I carried on my way. Then 7k miles later, the replacement engine that GM sent also blew up and was a total replacement. Hopefully the third engine lasts longer.

NHTSA ID

11760660

Incident

Jul 28, 2026

The lifters stuck and it ruined the cam shaft. This was repaired and then when driving home, the engine seized and started smoking. The engine was then diagnosed with complete failure and it had to be replaced. The engine had been upgraded a year or two earlier to the 0W-40.

NHTSA ID

11760507

Incident

Jan 1, 2026

The vehicle’s engine suffered a catastrophic failure and locked up while in operation. The engine is still installed in the vehicle and is available for inspection upon request. The engine suddenly locked up while I was driving, causing the vehicle to lose power and become disabled in traffic. I was forced to get the vehicle out of the flow of traffic and have it towed to a safe location. The sudden engine failure created a significant safety risk to me and other motorists, particularly because the failure occurred while the vehicle was being driven. Yes. Integrity Buick GMC in Chattanooga inspected the vehicle and confirmed that the engine had locked up. Only the dealer. No.

NHTSA ID

11759685

Incident

Aug 15, 2026

Had a prior recall a few months back on my truck in reference to the engine. My truck didn’t have an engine issue such as check engine light etc etc etc which required attention. So they only changed the oil to a different velocity. On Sunday afternoon August 23, 2026 while driving on Interstate 20 near Longview, Texas the truck shut off. I had to get it towed to the Chevy dealership (Peltier Chevy in Tyler, Texas).

NHTSA ID

11759625

Incident

Aug 23, 2026

I got the vehicle with 60,000 miles 8,000 miles in vehicle gave me problems gave me a check engine light code p0300 then took it to get inspected then was told it was the fly wheel then it’s started knocking vehicle is currently not being droven because of the fly wheel

NHTSA ID

11758900

Incident

Aug 19, 2026

The oil recall on my truck has been completed, but the low oil light still comes on. They changed the weight of the oil stated that it didn’t fall Under the engine replacement recall. All that was done was a new oil cap and change weight of oil. Did not solve anything.

NHTSA ID

11758828

Incident

Aug 22, 2026

While traveling northbound on the I 10 freeway my vehicle wouldn’t accelerate once pulled over to the shoulder the vehicle completely lost all acceleration and shut off. The vehicle smelled like burning plastic and would not restart. The dealership’s reporting engine fail.

NHTSA ID

11758757

Incident

Aug 19, 2026

engine was replaced by Classic GMC in Katy/Houston, TX in dec 2025 under L87 recall. My wife was driving and was stopped on an off-ramp but still in the traffic lane. It started with a light knock that i thought i heard the day before, but then died on freeway within maybe 15 miles of her driving. Unknown if it knocked louder, but wife says she never heard anything until it died and check engine light came on and engine would not restart. Required tow to GMC dealer. They diagnosed and took 2-3 weeks to source and replace the engine. In july 2026, started hearing very similar noise - this time apparently the water pump seized. Heard noise and got home within about 10 miles. Checked under hood and drive belt was significantly frayed and knocking/metallic noise was intense. Towed to Classic GMC. Not covered under any warranty - my replacement engine did not include a new pump. Cost $1700 at Classic GMC - they said it had no relation to the engine replacement or labor done in December. Unrelated, but icing on the cake - less than 2 hours and 10 miles of picking it up from service, lots of warnings about lane keep, adaptive cruise control, and park sense started going off. Returned to same shop the next day and *poof* the camera and processor that runs all those systems was somehow fried. Unrelated of course. $1200 a but they claimed GM graciously offered to “split the cost with me 50/50” since I just paid so much for the water pump. Picked up from service and traded vehicle in with 2 days.

NHTSA ID

11758649

Incident

Jul 26, 2026

The engine was producing a strange noise while driving and subsequently shut off. The vehicle was towed to a GMC dealership where an inspection/testing was performed. Ultimately, I was told the entire engine needed to be replaced.

NHTSA ID

11758601

Incident

Dec 2, 2025

Vehicle was traveling at 65 mph on a busy highway when vehicle engine stopped. A message on the dash appeared indicating to driver to shift to neutral and try to restart engine. As vehicle was quickly loosing speed it was decided to coast to the side of road to avoid someone running into vehicle causing multiple cars to crash. After stopping vehicle, an attempt was made to start vehicle. Engine would not turn over. Vehicle was towed to dealership. The following day I was informed that the engine needed replacement.

NHTSA ID

11758326

Incident

Aug 3, 2026

I was driving to work on 7/20/26 and my vehicle loss engine propulsion , engine failure and unable to restart vehicle and shift gears.

NHTSA ID

11755472

Incident

Jul 20, 2026

I Purchased the vehicle on May 29, 2026 and it stated the 6.2 liter engine recall had been fixed and that I have extended special coverage for the exact issue of the recall until 150008 miles on this vehicle. On July 14, 2026 the vehicle was being driven and stalled out at a traffic light and restarted, yet within a quarter mile it stalled again at the next traffic light and became completely disabled, it would not even allow a shift into nuetral, so I had it towed less than 100 feet into the Walmart on Loudon Road in Concord, NH 03301 parking lot. On July 23, 2026 I was able to get the batter charged and attach a code scanner which showed one code (P0016). Pursuant to Recall N252494001 (which had allegedly been repaired, likely with the bandaid fix of thicker oil) any 6.2 liter GM truck with the loss of propulsion needs to be plugged into a scanner and if code P0016 is present, engine replacement is needed. Specifically noted to the recall is Special coverage N252494003 which provides the coverage to 150,008 miles on this vehicle is directly related to the recall. At the time of loss of propulsion the vehicle had 99,195 miles present on the odometer. The following day July 24, 2026 I had the vehicle towed to Banks Chevrolet GMC in Concord NH, after the vehicle arrived, I spoke with the service department, provided them with the recall paperwork and printout of the special coverage uner the vin as well as a photo of the odometer and my scanner displayining one code P0016. They then informed me it would take them until August 24, 2026 to "diagnose" the vehicle. The recall is clear it just needs a code scan if disabled. I have contacted GM and informed them of the need for a loaner as the vehicle is a vehicle utilized for business. I have since been told they will try to look at it earlier and no loaner will be offered but I "may" be able to be reimbusred $44.00 a day for a rental. There are no rentals for that price that can tow over 9500 pounds. It is unnacceptable.

NHTSA ID

11753262

Incident

Jul 14, 2026