2024 GMC Sierra 2500 Fuel system Problems

The vehicle experienced a loss of engine power accompanied by a check engine warning light and a “Reduced Acceleration”/reduced-power condition. The exact component causing the malfunction has not yet been determined. The vehicle and any affected components are available for inspection upon request. While driving the truck uphill toward our residence, the vehicle lost significant power and had difficulty maintaining acceleration. The truck stalled several times. The sudden loss of engine power while driving on an incline created a safety risk because the vehicle was unable to maintain normal acceleration and could potentially have stopped in traffic or created a hazard for other vehicles. The problem has not yet been confirmed or reproduced by a dealer or independent service center. The vehicle has experienced the problem while being driven, including the reduced-acceleration condition and multiple stalls. The vehicle will be inspected by a GMC dealer on Monday, September 28, 2026. The check-engine warning light illuminated, and the vehicle displayed a reduced-acceleration/reduced-power condition. The truck subsequently experienced significant loss of power while traveling uphill and stalled several times. These symptoms first appeared on September 14, 15, 22, and 23, 2026.

NHTSA ID

11766690

Incident

Sep 14, 2026

The contact owns 2024 GMC Sierra 2500. The contact stated that while driving 25 MPH and depressing the accelerator pedal, the vehicle decelerated and stopped independently. A dealer was contacted. The vehicle was taken to the dealer and was diagnosed with fuel pump driver control module failure. The contact was informed that the fuel pump driver control module needed to be replaced. The contact associated the failure with Technical Service Bulletin: 24-NA-139 (Fuel Pump Driver Control Module stalling or no-start conditions); however, the VIN was not included in the TSB. The manufacturer was notified of the failure, and informed the contact that the vehicle was under warranty. The failure mileage was 54,238.

NHTSA ID

11766384

Incident

Sep 14, 2026

Mileage

54,238 mi

The vehicle went into low power mode and said to pull over. As soon as that message appeared the next warning appeared and said to shift to neutral and pull over immediately and attempt to restart. The vehicle immediately shut off after second warning before having time to pull over from first message. I was able to pull most of the way off the road as the vehicle had shut off there was no power steering and had limited ability to steer the vehicle. This all happened without advance warning or any other warning that there was an issue while traveling at over 75mph. Vehicle would not restart and needed to be towed. Dealer stated it was a fule control module that was hard to get due to a recall. But that my vehicle was not part of that recall.

NHTSA ID

11724530

Incident

Mar 9, 2026

The contact owns a 2024 GMC Sierra 2500. The contact stated that the vehicle was idling roughly, and the RPM fluctuated between 500 and 1,000 RPM while idling. The check engine warning light was illuminated. Additionally, the contact stated that the fuel economy had decreased to 13 miles per gallon. The contact stated that upon scanning the vehicle, the contact retrieved DTC: P0606 and P062B. The contact related the failure to GM Campaign Number: N232415860 (Fuel Injector Flow Rate Compensation). The dealer was contacted and informed the contact that a fee would be charged for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,000.

NHTSA ID

11696287

Incident

Jul 29, 2025

Mileage

70,000 mi

The contact owns a 2024 GMC Sierra 2500. The contact stated that after parking and turning off the vehicle, the vehicle failed to restart. No warning light was illuminated. The vehicle was towed to the dealer for diagnostic testing, but no diagnostic trouble codes were retrieved. The dealer replaced the fuel pump module. No further information was available. The manufacturer was made aware of the failure and advised the contact to file a vehicle safety complaint with the NHTSA Hotline. The failure mileage was approximately 11,000.

NHTSA ID

11662578

Incident

May 13, 2025

Mileage

11,000 mi

Replaced the exhaust tail pipe tip past the DPF and warning light came on after miles of driving. Vehicle was locked up and only able to drive 55 Mph and there was a countdown to it dropping even lower. Dangerous to limit speed. This shouldn’t happen anyway with just changing out exhaust tailpipe. Very costly unnecessary repair

NHTSA ID

11649759

Incident

Mar 21, 2025

I leased this vehicle on May 17, 2024, expecting it to function as intended. Instead, within months, it suffered recurring and escalating failures that have rendered it unsafe and unusable. January 7, 2025, I brought the truck to Gates GMC for routine service and reported that it had lunged forward by approximately 2 to 2.5 feet while shifting into park. Additionally, it exhibited irregular acceleration and rough down shifting in lower gears. I also communicated the check engine light has come on and gone off on the dashboard over the past week a few times without receiving any information on the app. At this January 7th visit, GM performed Recall N242435631, supposedly addressing a known battery drain defect that caused total vehicle shutdowns. On January 24, 2025, I started the truck and was immediately overwhelmed by an intense chemical odor coming through the ventilation system. January 31 – February 1, 2025 – Erratic Engine Warning Lights & Diagnostic Failures On January 31, 2025, at 5:28 PM, on this key cycle the check engine light illuminated but failed to register in the GM app. On the next key cycle, the warning disappeared. The following morning, February 1, 2025, at 10:26 AM, the check engine light Appeared on the first key cycle before disappearing on the second key cycle. The onboard diagnostics system failed to log or retain these warnings. On February 7, 2025, the vehicle suffered a complete electrical failure. no electronic function whatsoever. Roadside Assistance attempted to jump-start the truck using a high-powered jump pack, but it remained inoperable. A ford super duty and jump pack were needed to force start the truck. February 10, 2025 the truck suffered another total electrical failure and required towing to Gates GMC. The app indicated the Brake System, Anti-Lock Braking System, Emissions System (Specifically the exhaust system), and Power Train requiring service. My truck is at Gates GMC and was drawing 90 milliamps opposed to 40

NHTSA ID

11642114

Incident

Jan 7, 2025

The contact owns a 2024 GMC Sierra 2500. The contact stated that while driving at various speeds, the two outside cabs were smoking. There was smoke detected near the fuel tank. The contact stated that there was an abnormal odor of diesel and DEF detected. There were no warning lights illuminated. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. While driving, there was a lot of smoke detected from the vehicle. The vehicle was taken back to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 100.

NHTSA ID

11611647

Incident

Jul 27, 2024

Mileage

100 mi