2007 GMC Silverado

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

I PURCHASED A NEW BANKS ELECTRONIC SPEED BRAKE PN 55445 WITH SELECTOR SWITCH, FIRMWARE REV. 555431-05-02, SERIAL # SAA40615284 AND INSTALLED IT ON OUR GMC 2500 HD PICKUP PER SUPPLIED INSTRUCTIONS. SHORTLY AFTER INSTALLATION IT BEGAN CAUSING THE ALLISON 6 SPEED AUTOMATIC TRANSMISSION TO RANDOMLY GO INTO NEUTRAL WHILE DRIVING ON THE HIGHWAY. I WOULD HAVE TO PULL TO THE SIDE OF THE ROAD AND STOP, PUT THE TRANSMISSION IN PARK AND BACK INTO DRIVE TO RESET THE PROBLEM AND RESUME DRIVING. THIS HAPPENED TWICE WHILE TOWING OUR 12,000 LB 5TH WHEEL RV. FORTUNATELY IT DID NOT OCCUR WHILE GOING DOWN A STEEP GRADE WHERE ENGINE BRAKING WAS REQUIRED TO CONTROL SPEED. IF IT HAD OCCURRED UNDER THOSE CIRCUMSTANCES, IT COULD HAVE BEEN A LIFE THREATENING SITUATION. I REMOVED THE BANKS ELECTRONIC SPEED BRAKE FROM THE TRUCK AND THE PROBLEM NO LONGER OCCURRED. CLEARLY THIS PRODUCT CREATED A SERIOUS SAFETY ISSUE.

NHTSA ID

10860455

Incident

Jun 15, 2015

Mileage

24,000 mi

2007 GMC SILVERADO. CONSUMER WRITES IN REGARDS TO REPLACEMENT PARTS NOT AVAILABLE TO REPAIR PASSENGER AIRBAG INFLATOR RECALL NOTICE. *SMD THE COSUMER RECEIVED A RECALL NOTICE IN JULY 2015. *JB

NHTSA ID

10851598

Incident

Jul 1, 2015

TL*THE CONTACT OWNS A 2007 GMC SILVERADO. THE CONTACT TOOK THE VEHICLE TO AN AUTO GARAGE FOR AN OIL CHANGE AND TIRE ROTATION AND WAS INFORMED THAT BOTH FRONT DISCS, THE BRAKE LINING, AND ROTORS WERE WORN. HE TOOK THE VEHICLE TO THE DEALER IN NOVEMBER OF 2007 FOR INSPECTION AND FELT THAT THIS FAILURE SHOULD HAVE BEEN DETECTED AT THAT TIME. THE FAILURE AND CURRENT MILEAGES WERE 5,500.

NHTSA ID

10232900

Incident

Jul 1, 2008

Mileage

5,500 mi

GENERAL MOTORS: INTERMITTENT MIL/SES/ DTC P2138 WITH REDUCED ENGINE POWER (REPAIR INSTRUMENT PANEL (IP) TO BODY HARNESS CONNECTOR). 2005-08 GM PASSENGERS CARS/LIGHT DUTY TRUCKS (INCL. SATURNS). *PE UPDATED 11/5/10. *PE UPDATED 4/4/11. *PE UPDATED 2/3/16. *PE

GM: ON SOME TRUCK MODELS THERE IS SOME FRAME CORROSION. *RM UPDATED ON 5/2/2012. *KB

GM/HUMMER/SAAB: INTERMITTENT ILLUMINATION OF MIL, SERVICE LAMPS, SERVICE MESSAGES, OR DTC SET BY VARIOUS CONTROL MODULES-DIAGNOSING AND REPAIRING FRETTING CORROSION (DISCONNECT AFFECTED CONNECTOR AND APPLY DIELECTRIC LUBRICANT). *PE UPDATED 3/26/10. *PE UPDATED 6/6/11. *PE UPDATED 3/12/12. *PE

GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE