2021 Honda CR-V Hybrid

The Office of Defects Investigation (ODI) has received 48 Vehicle Owner Questionnaire (VOQ) reports and some Early Warning Reporting (EWR) field reports alleging intermittent loss of motive power in Model Year (MY) 2020–2022 Honda CR-V Hybrid vehicles.  These incidents are alleged to occur without warning at highway speeds and are accompanied by a flashing check engine light immediately before the loss of motive power occurs.  Motive power can be restored by turning the ignition off and back on.  However, this action also clears the check engine light and any fault codes that were set.  The fault’s intermittent nature, combined with the lack of fault codes, often results in many visits to repair facilities yielding no repairs. Honda indicated it was unaware of any related complaint or repair trends. ODI is opening this Preliminary Evaluation (PE) to determine the scope and severity of the alleged fault and to fully assess the possible safety consequences. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles.  The reports allege that activation of the AEB system occurs while driving with no apparent obstruction in the vehicle's forward path, resulting in sudden vehicle deceleration. Honda indicated that they were aware of a total of X,XXX reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and alleges that some customers possibly had an inadequate understanding of the CMBS and its limitations.  However, many consumer complaints allege that Honda dealerships were unable to reproduce the condition or state that they were informed that this is considered normal CMBS operation. To date, ODI has received a total of 1,294 consumer complaints of inadvertent activation of CMBS in 2017-2022 Honda CR-V and 2018-2022 Honda Accord vehicles. A total of 31 complaints alleged a crash and 50 alleged an injury.  The Total column in the Failure Report Summary removes duplicate reports and shows the total number of reports with unique VINs from all Manufacturer, ODI, and EWR data sources.  In some cases, there were multiple reports associated with a particular vehicle in which recurring failures were alleged.  In total, there were X,XXX reports, 93 injury incidents and 47 crashes involving vehicles with unique VINs that may relate to the alleged defect. PE22-003 has been upgraded to an Engineering Analysis to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. The scope has been expanded to include assessment of model year 2020-2022 Honda CR-V and Accord vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

August 13, 2026- Driver was traveling on Route 30 West approaching the Reeceville Exit. Driver attempted to pass a tractor trailer. As car accelerated to pass tractor trail, engine light flashed and car lost the ability to accelerate. As driver lost ability to power the car, he allowed truck to pass him and then coasted into right lane and eventually off to the side of the highway. Car had a half tank of gas at the time of incident. Safety of driver at risk as car was traveling approx. 61 mph in order to pass another vehicle. Suddenly, power lost in car as car was passing truck and driver had to maneuver car from passing lane into right lane and eventually come to a stop on side of road. Honda was contacted since this occured before. It was taken in on Monday August 17th.

NHTSA ID

11763066

Incident

Aug 13, 2026

2021 CR-V Hybrid, approximately 103,000 miles. Multiple incidents of loss of propulsion at highway speed with engine shaking and a flashing MIL. Cycling the ignition restores normal operation, and the codes disappear. I have had it scanned, and no errors show up. Spark plugs and ignition coils have been replaced. The vehicle has also displayed an engine high-temperature/reduce-acceleration warning. This can be in relation to NHTSA Preliminary Evaluation PE25016 that has been documented by other owners.

NHTSA ID

11761715

Incident

Jun 2, 2026

I am a senior citizen who bought a brand new 2021 Honda CRV hybrid in 2022. I used the vehicle mainly for driving around town in city driving. I ensured that my vehicle received all the necessary scheduled maintenance at either the dealership I bought the vehicle,(Pacific Honda, [XXX];phone [XXX]) or a certified Honda dealership. I have complete maintenance records at the Honda dealership for the entire life onf the vehicle. In early XXX I received a warning light on my dash concerning the engine and immediately took the vehicle into the Honda dealership to have it looked at. I was told I had a blown headgasket and the repairs would be approximately $7,000.00 dollars. The mechanic then told me that this was a common problem with this vehicle due to the engine Honda put in the car. The mechanic advised me to contactHonda to see if they would assist me with the cost due to the fact that this was a manufacturing problem and I did nothing to cause the issue and there is nothing I could have done differently to have avoided this issue. I called and Honda told me there was nothing they could do for me since the car was out of warranty. I bought the vehicle in August of 2021 and repair was done XXX. I was treated very poorly at the Honda dealership and lost trust in their tech team. On XXX I received another warning light on my dash. I took my vehicle to Mossy Honda in [XXX] to have it looked at due to the fact I did not trust Pacific Honda. They did a multi point inspection and told me that my Rear differential was bad and had to be replaced for approximately $5,500.00 dollars. I had the work done. When I picked up the vehicle after the repair the tech told me that the Rear differential was completely bad and that there were metal flakes throughout the Rear Differential. He told me that if I had not brought it in when I did the car could have had a catastrophic lockup or seizure! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11759190

Incident

Jul 6, 2026

Manufacturer Dealer Diagnostic confirmed that Head Gasket is leaking on cylinder 1 and that this is a known issue. Vehicle just 3 months and barely 2000 miles out of new car warranty. Manufacturer fails to cover repair at 100% Power Loss while driving on the freeway on 2 separate occasions. Engine did not provide power in response to accelerator pedal, car slows down w/o control. Incident 1 traveling 65 mph Hwy [XXX] in [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755481

Incident

Jul 31, 2026

The vehicle experienced a premature failure of the head gasket; it was blown at 130,000 miles. I was close to home when I received a dash alert stating not to accelerate as the engine was nearing a critically high temperature. If I had not been able to get home so quickly, my safety may have been compromised as my car could have overheated forcing me to pull over on the shoulder of a busy bridge. My local dealership inspected the vehicle and has quoted me nearly $4,500 for the repair, despite it appearing as this is a known issue with this particular engine.

NHTSA ID

11688230

Incident

Sep 15, 2025

Brittle / torn top black windshield seal gasket tendency to fog / moisture / rain/water penetration inside the car . Also decolorize all black plastic side panels

NHTSA ID

11681067

Incident

Apr 1, 2025

While traveling northwest at 37 mph, the automatic brake system engaged jolting the driver. The camera shows no objects in front of but there were two vehicles traveling southeast in the opposite lane prior to the brakes applying. There were shadows from trees. If there was a vehicle behind, and the driver did not react fast enough, this would have been a rearend collision. This is the third time that the automatic brake system engaged for no reason since we have owned this vehicle (Dec 2021) and each time it has been reported to the NTSB. In the past two cases, there were no vehicles or shadows from trees, since we were in the desert. The previous two times, the vehicle was inspected by the dealership with no defect noted (under warranty). There were no dashboard warning notices indicating an issue. The vehicle will be resubmitted to a dealership for inspection for this third incident (not under warranty).

NHTSA ID

11679427

Incident

Aug 8, 2025

Traveling on 4 lane highway at 65 mph on slight upgrade-check engine light started flashing and vehicle started to shudder slightly and went into "limp" mode I think. Started to slow down with NO power. Turned on emergency flashers and was able to pull over without incident, although it was close to causing an accident with a tractor trailer. I shut the vehicle down and after 10 minutes, started it again> I was able to drive home another 45 miles without incident. This happened a week ago and so far it hasn't happened again.

NHTSA ID

11679040

Incident

Aug 1, 2025

Dealer Message - Under certain conditions, the cylinder head gasket effectiveness may be reduced which may cause vehicles to experience overheating, coolant loss, misfire, and/or DTCs P0300 through P0304 stored.

Service Bulletin - Under certain conditions, the cylinder head gasket effectiveness may be reduced which may cause vehicles to experience overheating, coolant loss, misfire and/or DTCs P0300 thru P0304 stored.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2021 CR-V FHEVs with a customer complaint of an oil leak coming from the passenger side transmission/differential oil seal. The leak may also be found during normal service or an oil change. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to you attempting a repair of any kind.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2021 CR-V FHEVs with a customer complaint of an oil leak coming from the passenger side transmission/differential oil seal. The leak may also be found during normal service or an oil change. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to you attempting a repair of any kind.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2021 CR-V FHEVs with a customer complaint of an oil leak coming from the passenger side transmission/differential oil seal. The leak may also be found during normal service or an oil change. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to you attempting a repair of any kind.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2021 CR-V FHEVs with a customer complaint of an oil leak coming from the passenger side transmission/differential oil seal. The leak may also be found during normal service or an oil change. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to you attempting a repair of any kind.