2011 Honda CR-V Body & structure Problems

Catastrophic rust damage to the rear trailing arm and its mounting point, where the metal has completely rotted through and fractured

NHTSA ID

11735350

Incident

May 2, 2026

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure). The contact stated that while attempting to register the vehicle, the vehicle failed the State Inspection due to frame corrosion. The vehicle was taken to a dealer, where it was diagnosed with severe frame corrosion, and the failure was beyond repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue approximately five times, but the contact had not yet received a call back after approximately two months. The failure mileage was approximately 121,000.

NHTSA ID

11693631

Incident

Jul 15, 2025

Mileage

121,000 mi

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer where it was confirmed that the rear subframe was severely rusted. The dealer confirmed that parts were not yet available and that the vehicle was not safe to be driven. The contact was further advised by the dealer to no longer drive the vehicle until the recall parts were available. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 124,651. Parts distribution disconnect.

NHTSA ID

11593942

Incident

Jun 7, 2024

Mileage

124,651 mi

The contact owns a 2011 Honda CR-V. The contact stated that the dealer had installed a support brace on the vehicle under NHTSA Campaign Number: 23V228000 (Structure). The contact stated that after the recall repair was performed on the vehicle, the vehicle was bouncing off the road surface while driving over uneven or bumpy road surfaces, nearly causing him to lose control of the vehicle. The dealer and the manufacturer were notified of the failure, but no assistance was provided. The failure mileage was approximately 92,000.

NHTSA ID

11580402

Incident

May 26, 2023

Mileage

92,000 mi

The contact owns a 2011 Honda CR-V. The contact stated while driving approximately 30-40 MPH, the vehicle inadvertently veered to the opposite lane of the road, causing the front driver's side to crash into an embarkment. The air bags did not deploy. The contact stated that he hit his left knee and sustained severe pain that lasted a long time. The contact received medical assistance. No police report was filed. The vehicle was towed to the residence. The contact stated that while inspecting the vehicle, he noticed that the frame was fractured. The contact later received notification of NHTSA Campaign Number: 23V228000 (Structure), which he related to the failure. The manufacturer was notified of the failure and a case was opened. The dealer was then contacted and notified of the failure. The failure mileage was approximately 200,432.

NHTSA ID

11578482

Incident

Sep 20, 2022

Mileage

200,432 mi

The contact owns a 2011 Honda CR-V. The contact stated that upon taking the vehicle into an independent mechanic, he was informed that a support bracket on the sub frame was not installed correctly. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V228000 (Structure), and the VIN was included, and the repair was already completed. The manufacturer was not notified of the failure. The failure mileage was 96,000.

NHTSA ID

11577573

Incident

Mar 15, 2024

Mileage

96,000 mi

There appears to be a defect in the body part of vehicle. Please note that I have uploaded pictures of the Rhea body of the vehicle to show where the defect is protruding from the vehicle.

NHTSA ID

11575764

Incident

Feb 1, 2024

See attached document for complaint

NHTSA ID

11570001

Incident

Jun 8, 2023

Drivers side door lock is stuck and will not open. I had to crawl out of the passenger door to exit the vehicle. After exiting the car I tried locking and unlocking the car using the fab. Once the doors were locked none of the doors would open using the fab even though the fab was visibly working. I had to call AAA to come unlock the car. I can unlock all of the doors from the inside except for the drivers door. If I lock my car I will be locked out out of it, so my vehicle is now not secure. This is the first time this has happened.

NHTSA ID

11561171

Incident

Dec 20, 2023

I have always known that after entering the vehicle and beginning a trip, all four doors and hatch would automatically lock and stay locked until a passenger unlocked one of the doors. But sometime this past weekend, I began noticing that the vehicle would try to relock all doors EVERY time the vehicle accelerated after idling, which is quite often. When I pointed this out to my teenager in the front passenger seat, she noticed that the door behind the driver's seat was not locking during each attempt. She tried to lock all doors from her door, but that one would not lock. Then I tried to lock all doors from my door, but that one would not lock. When we returned home, I tried to lock all doors from my key fob, but that one would not lock. I also tried to lock that one manually with my hand, but it won't lock. This is a safety issue for multiple reasons. For one, I don't want that door to accidentally open while the car is in motion. But secondly, I currently don't feel safe parking my car anywhere outside of my garage if anyone can currently open that door.

NHTSA ID

11560974

Incident

Dec 18, 2023

IT SEEMS ALL DOOR LOCKS ARE BUZZING AND HAVE DIFFICULTY OPENING/CLOSING. IT HAPPENS DURING UNLOCKING AND LOCKING OF DOORS USING EITHER THE REMOTE KEY OR REGULAR KEY. ALSO MAKES BUZZING NOISE WHEN RUNNING THE 1ST 0-10MPH (FROM MOST FULL STOP). IT SEEMS TO HAPPEN MORE OFTEN ON THE DRIVER AND RIGHT PASSENGER DOORS. BOUGHT THIS USED CAR IN MID-2023.

NHTSA ID

11560853

Incident

Jul 19, 2023

The contact owns a 2011 Honda CR-V. The contact stated while driving 60 MPH, the rear driver's side wheel, the lower control arm, and the axle detached, causing the contact to almost lose control of the vehicle. The contact was able to veer to the side of the road. The vehicle was towed to the residence. The dealer was notified of the failure and informed the contact that the VIN was not included in a recall. The contact later received notification of NHTSA Campaign Number: 23V228000 (Structure) and contacted the manufacturer for the recall repair. The manufacturer advised the contact to tow the vehicle to the dealer. The vehicle was towed to the local dealer, where a regional field inspector from Honda determined that the vehicle was beyond repair due to severe frame corrosion. The manufacturer opened a case. The contact stated that the recall remedy also involved buying back the vehicle if the vehicle was beyond repair; however, the contact had not received a call back from the manufacturer since April 2023. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 115,000. Parts distribution disconnect.

NHTSA ID

11557225

Incident

Nov 28, 2021

Mileage

115,000 mi

Received recall notice from Honda, attempted to make an appointment in May 2023 with Lia Honda in Enfield. Lia Honda failed to return multiple calls and set up an appointment, telling me “We will call you when we have the parts for this recall”. Once it reached September, I called a Honda dealership and repair center in Manchester and have an appointment with them in November 2023. This is completely unacceptable as the recall states that failure to make this appointment can cause the operator to lose control of the vehicle and crash.

NHTSA ID

11554090

Incident

May 25, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11553258

Incident

Nov 2, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11549141

Incident

Oct 10, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11548477

Incident

Mar 30, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11539887

Incident

Mar 30, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11537834

Incident

Aug 11, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11536543

Incident

Aug 4, 2023

I was sent a recall notice fora SAFETY DEFECT that the rear frame that can deteriorate and trailing arm can fall off. I called the Honda of ILLINOIS dealer In Springfield Illinois to schedule an appointment for the recall and was told I would be put on a Waiting list and they only schedule 2 of these recalls per week. This vehicle is the only mode of transportation, and is driven on the highway to and from a nearby city 40 minutes away on a daily basis. There are children being transported in this vehicle and I am concerned for their safety. I called as soon as I received the recall notice in May and have yet to hear back from them as to when It can be repaired. This is a safety issue and I feel needs addressed . (update) they returned the call as I was typing this note and they tell me "there is quite a few people ahead of me that have this recall" This is unacceptable to have to wait over 60 days for a recall repair that is a safety issue!

NHTSA ID

11532799

Incident

May 8, 2023

I received an open recall notice via email on 1 May 2023 for my 2011 Honda CR-V. The notice stated that my vehicle was added to the open recall on 9 Apr 2023. My vehicle has been housed in the state of Virginia since August 2016 (7 years) that is affected by the recall NHTSA campaign number: 23V228, Honda code for recall: XDZ. Our family is active duty military and our vehicles are registered in the state of residence other than Virginia as required by law. I believe my 2011 Honda CR-V is affected by the recall and fear for my and my family's safety. For an unknown reason, the recall was removed from my vehicle. I contacted Honda Customer Service on 14 July 2023, requested Honda to escalate my concern, and I have been assigned a Honda case number by representative Jaslyn.

NHTSA ID

11532213

Incident

May 1, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11531422

Incident

Jul 10, 2023

The contact owns a 2011 Honda CR-V. The contact received notification of NHTSA Campaign Number: 23V228000 (Structure) and the vehicle was taken to the dealer for the recall repair; however, the dealer determined that the vehicle could not be repaired due to the extensive corrosion. The contact stated that the manufacturer was notified and offered to repurchase the vehicle; however, the repurchasing offer was less than the market value. The contact stated that the manufacturer failed to honor the recall obligations. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle was undrivable. The failure mileage was approximately 143,000. Parts distribution disconnect.

NHTSA ID

11528364

Incident

May 9, 2023

Mileage

143,000 mi

The car is subject to a safety recall. I have contacted 2 Honda dealers to inspect this car. They will not schedule an inspection because the parts to repair it are on back order. The national Honda rep has told me not to drive the car and that the dealers should give me a loaner since the car will either need to be repaired or totally scrapped. The dealers will not even look at the car until they have the parts and I have explained that it is possible that the car will NOT be reparable--in which case Honda will buy it back from me. I think they are refusing to inspect the car because they don't want to give anyone a loaner while waiting for the back ordered parts. I've asked the national HOnda people to contact the local dealers to explain the correct process for dealing with this recall but they say they don't have any control over independently owned Honda dealers.

NHTSA ID

11528047

Incident

Jun 10, 2023

I was driving down a road on the way to take my son to his swim team training. I got about f 5 min away from our home and I felt a large clunk, almost as if I ran something over that was large. I had difficulty steering my vehicle, had a loud weird noise coming from the vehicle, and pulled over. I inspected the vehicle outside, I hit nothing. wheels looked fine. I popped open the hood and started to inspect, it was getting dark so it was difficult to see. I found that the engine mount bolts had sheared clean off of the engine, causing the engine to drop, cracking the engine bracket and the engine almost falling out of the vehicle onto the ground. It it was not for the cross member below it may have completely fallen out.. the vehicle had to be towed as it was not drivable at this point. I had the vehicle towed to Schlossmanns Honda in Greenfield WI for repair. Currently my vehicle is at a Honda dealer being inspected for corrosion as I live in the rust belt and there is a recall for corrosion on this vehicle.

NHTSA ID

11525392

Incident

Jun 5, 2023