2019 Hyundai Santa Fe Xl

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

On September 22, 2026, my 2019 Hyundai Santa Fe XL experienced a sudden engine stall while I was stopped at a traffic light. The engine unexpectedly lost power, the steering wheel became extremely difficult to turn and appeared to lock, and the oil pressure, battery, and check engine warning lights illuminated. After restarting the vehicle, I noticed an abnormal clicking or knocking sound coming from the engine. On September 23, 2026, my wife experienced a similar incident while operating the same vehicle. These incidents created serious safety concerns. Unexpected engine stalling and loss of steering assistance could result in a collision, especially in moving traffic, placing drivers, passengers, and surrounding motorists at risk. An independent repair facility initially diagnosed engine failure. Hyundai subsequently inspected the vehicle but denied engine repair assistance, citing alleged maintenance neglect based on a gap in the vehicle's maintenance history that occurred approximately three years before I purchased it. The service manager also indicated that sludge buildup within the engine was associated with combustion-related problems occurring as the engine began failing. Prior to the initial incident, I had not observed warning lights indicating an imminent engine failure. The warning lights appeared during the initial loss-of-power event, followed by abnormal engine noise. The vehicle remains inoperable and has not been repaired. It is available for further inspection upon request, subject to coordinating access to its location. I am requesting that NHTSA document and evaluate these incidents as a potential vehicle safety defect involving unexpected engine stalling and loss of steering assistance.

NHTSA ID

11772079

Incident

Sep 23, 2026

The contact owns a 2019 Hyundai Santa Fe XL. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. The vehicle was driven to the shoulder of the road, and the contact listened for the abnormal sound. The abnormal sound was persistent. The vehicle was driven to the residence. The contact stated that the check engine warning light was illuminated, and the engine seized. The vehicle was towed to an independent mechanic, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. In addition, the contact stated that a year prior, an unknown recall notification was received for a special engine warranty program. The vehicle was taken to the dealer, where it was diagnosed with a timing chain failure. The contact was informed that the timing chain needed to be replaced. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 80,000.

NHTSA ID

11732932

Incident

Apr 1, 2026

Mileage

80,000 mi

Check engine light came on and then vehicle stalled took to shop and said the engine was needing to be replaced. Looked into issue and seen multiple issues with this engine and happening to a lot of Hyundai engines where vehicles need to get complete new engines

NHTSA ID

11730319

Incident

Apr 8, 2026

Our vehicle had 145,000 miles and all maintenance and repairs performed at Hyundai dealerships. Joseph Airport Hyundai in Vandalia, Ohio replaced the timing chain at a cost of $3500. After replacing the timing chain our vehicle began consuming large amounts of oil (9 quarts over 5000 miles). The dealership has tried several repairs and the vehicle still continues to consume the same amount of oil. We now have 160,000 miles on the vehicle and need to always carry a 5 quart container of oil so it doesn't run low. This never happened until we had the timing chain replaced.

NHTSA ID

11700732

Incident

Mar 24, 2025

Two bolts flew out of the CCVT system, blowing a hole in the valve cover and destroying all the timing components. Because of the issue, all oil spilled from the car. The other two bolts in the system were bent as well. I was driving the vehicle when this happened and could’ve been seriously hurt. I now need a new engine.

NHTSA ID

11697217

Incident

Oct 10, 2025

On [XXX], the check engine light came on in my 2019 Hyundai Santa Fe XL. The dealership diagnosed a complete engine failure requiring full replacement. The vehicle has only 54,000 miles. The dealer submitted a warranty claim to Hyundai, but Hyundai denied it because I could not provide receipts for every oil change, despite the fact that the vehicle has been responsibly maintained. An appeal to Hyundai’s goodwill department was also denied. This sudden and premature engine failure poses a serious safety risk. Engines from this generation (Lambda II / GDI family) are known to suffer from rod bearing failure, oil consumption, and sudden seizure. If this failure had occurred at highway speed, it could have led to loss of power, stalling, or an accident. Numerous owners have reported similar engine failures in 2016–2019 Santa Fe models at relatively low mileage, and Hyundai has already issued recalls and warranty extensions for related engines. This indicates a potential widespread defect that may not be adequately addressed. Requested Action: I am asking NHTSA to investigate Hyundai’s engine failures in the 2019 Santa Fe XL, review Hyundai’s denial of warranty coverage for vehicles experiencing these failures, and consider expanding existing recalls/warranty extensions to include this model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11691250

Incident

Sep 22, 2025

The contact owns a 2019 Hyundai Santa Fe XL. The contact stated that while driving at approximately 65 MPH, there was an abnormally loud sound coming from the engine compartment, with the check engine warning light illuminated. Upon inspection, the contact discovered oil leaking from the vehicle. The vehicle was taken to the dealer, where it was diagnosed, and determined that the rod bearings had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 91,000

NHTSA ID

11690937

Incident

Oct 2, 2025

Mileage

91,000 mi

The contact owns a 2019 Hyundai Santa Fe XL. The contact stated that there were intermittent, but constant electrical failures with the vehicle. The contact stated that the doors unintendedly locked and unlocked. Additionally, the contact was unable to upload the software updates for the vehicle or connect the vehicle to the Emergency 9-1-1 system through the cell phone. The contact stated that the check engine warning light was intermittently illuminated. The contact had taken the vehicle to a local dealer to be diagnosed; however, the dealer was unable to find an electrical or computer failure. The vehicle was not repaired. The manufacturer was informed of the failure but was unable to assist the contact. The contact believed that the computer system had been compromised. The failure mileage was approximately 75,000.

NHTSA ID

11690312

Incident

Dec 9, 2024

Mileage

75,000 mi

Certain Santa Fe and Santa Fe XL (NC) vehicles may exhibit underbody corrosion due to road salt usage. As a preventative measure, this bulletin provides the procedure to apply a cavity wax coating to internal surfaces of underbody components, and an undercoating spray to exterior surfaces of specified underbody components.

Some Hyundai vehicles may be equipped with a parking distance warning (PDW) sensor(s) that may trigger various DTCs and display warning messages on the instrument cluster, resulting in the PDW sensor(s) failing to detect nearby objects or triggering multiple false alarms. This condition may be a result of external damage to the PDW sensor membrane or sensor cover from rock chips or road debris, a collision, or previous vehicle repairs or modifications.

Certain Palisade (LX2) and Santa Fe (NC) vehicles equipped with Lambda II 6-cylinder engines may exhibit higher-than-expected engine oil consumption. This bulletin outlines the combustion chamber cleaning procedure for vehicles diagnosed with this condition. All internal combustion engines consume some engine oil during normal operation, depending on driving conditions and mileage, and this procedure should only be performed when deemed necessary based on inspection and diagnosis of the vehicle as outlined in TSB 26-EM-015H, Engine Oil Consumption – Inspection & Repair Guidelines, or the latest revision.

Certain vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin provides the inspection and repair procedures for vehicles exhibiting this condition. All internal combustion engines consume engine oil as part of normal engine operation. Oil consumption rates may vary based on mileage, operating conditions, driving habits, and maintenance history. Hyundai recommends following the prescribed maintenance schedule and periodically checking the engine oil level using the dipstick to maintain proper engine oil level.

Certain vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.

Some vehicles listed below may exhibit an intermittent airbag warning light and DTC(s) B1763 (OCS ECU Defect), and/or B1764 (OCS Mat Defect) may be stored. Hyundai is extending the warranty coverage of the sensor for the Occupant Classification System (OCS) / Occupant Detection System (ODS) to 18 years/unlimited mileage from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. Refer to the warranty and parts information outlilned in this bulletin. This bulletin contains the procedure to inspect for the airbag warning light and DTC(s), replace the OCS (ODS) unit or wire harness, reset the OCS (ODS), and initialize the power seat module (if applicable). This TSB also contains the procedure to replace the OCS (ODS) mat if DTCs exist after replacement of the OCS (ODS) wire harness.