2019 Kia Niro PHEV

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The contact owns a 2019 Kia Niro PHEV. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer informed the contact to ship the vehicle to the United States for the repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11611750

Incident

Aug 30, 2024

When accelerating from a dead stop, sometimes the car makes a very loud 'clunk' noise and lurches forward. Similar to the feeling when someone drives a manual transmission and takes the clutch out too fast. The car eventually finds the first gear and keeps driving, but this problem happens daily. Maybe around 5-10% of the time after every stop. There are multiple similar complaints on the NHTSA website and on online forums. It is a well-documented issue.

NHTSA ID

11605641

Incident

Jul 30, 2024

My 2019 Kia Niro LX PHEV is or has recently been the subject of multiple including NHTSA Recall Number [XXX] and Service Action [XXX]. Despite coordinating repair of these defects with the University Kia dealership located at 5105 Durham Chapel Hill Blvd, Durham, NC 27707 (hereafter 'University Kia"), and taking my vehicle to University Kia for those repairs twice, University Kia has been unable or unwilling to repair the defects over a 4-month period. This delay has not been due to parts availability, as I have received multiple assurances that parts needed to repair the defects were available. After three separate service appointments, University Kia has been unable to address these defects, and my vehicle remains in an unsafe condition. P.S.: The numbers on the prior page of the form where I can nominally report these issues (888-327-4236 & 800-424-9153) don't seem to be working. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11579063

Incident

Mar 23, 2024

12 volt battery will suddenly and without warning loose capacity to power the vehicle operating controls and displays including remote key access, start sequence using push button start, and traction battery charging through charging port. While parked and connected to a charging station vehicle ‘died’ in place. This occurred within 10 minutes of last use of remote key to unlock doors, open doors, place shopping bags, close doors, and use driver door push button feature to relock doors. Outside air temperature was mid 20’s Fahrenheit. Traction battery was fully depleted per dashboard miles available display as vehicle driven 20 plus miles using hybrid vehicle mode just prior to parking at charging station. Vehicle was removed from charging station connection and 1.5 hours later jump started using connection under hood. After start was driven just under 4 miles to home garage where plugged into 110 volt home charger. Multimeter on 12 volt system after recharge of traction battery read over 12 volts. Appears that control system for maintaining charge on 12 volt system using traction battery has a flaw that fails to detect 12 volt battery condition and react correctly. While this occurred this time while vehicle stopped and shutoff there is potential for such to occur while vehicle in a roadway at highway speeds causing vehicle to loose all power as 12 volt system powers all operating logic. As a practicing engineer over 50 years and college instructor of engineering for about 40 years it appears that there is a software error in assuring 12 volt system intact and a failure of the software to identify potential problem, notify operator, provide a manual reboot of operating system before 12 volt system reaches failure level if it ever did. Unlike alternator equipped vehicles that show failure of alternator no such given on hybrid.

NHTSA ID

11571634

Incident

Jan 17, 2024

This complaint references the open recall with the Kia reference SC276 and the NHTSA reference of 23V534. Kia has not been able to provide me with repair despite a notice from them stating a remedy is available, and appears Kia may be sending out faulty notices. I first received notice in July/August, 2023 that this recall was in process but remedy was not available. This week, I recieved a letter dated December 29, 2023 that explicitly states remedy is available (attachments will be added). However, the NHTSA website, the Kia recall website, and my local Kia dealer all as of today (01/04/24) say that remedy still is not available. I have attempted to call Kia customer care at the number on the letter, but every attempt has resulted in their system hanging up on me before I could reach anyone.

NHTSA ID

11563593

Incident

Jan 4, 2024

On 7-31-2022 while traveling on the freeway the gas engine shut down, HEV triangle came on and the information center on the car displayed "turn off car restart" on this trip it happened three times. I took the car to the dealer and they had it for a month and could not get it to act up. On 5-5-2023 it did it again twice, I called the dealer and they did not have a loaner car, they said they would let me know when they do. On the 6-30-2023 it did it eleven times. I called the dealer and they checked the car into service a mouth later 7-2023. The car has been at the dealer since then, now it is 12-2023. The dealer has not been able to get it to act up. I call KIA customer service and they told me they would not do the recall unless the dealer can repeat the problem. When this happens, I have only a limited amount of room to get the car off the road. This problem has only happened on freeways and the mountain pass with limited pull outs. This exposes me and any passenger's to a rear end collision. I feel the manufacture is playing roullet with me and my passenger's lives. All my dealer paper work is in my car a two hour trip at Sunset KIA 3317 Auburn way N Auburn WA 98002

NHTSA ID

11559989

Incident

May 5, 2022

Recall letter from KIA states "WARNING: You may experience illumination of the HEV warning light. If this occurs, pull over to a safe location and contact Kia Roadside Assistance ... to request to have your vehicle towed to the nearest authorized Kia dealership as soon as possible." This implies that the car is not safely driveable if the HEV warning light illuminates. My HEV warning light illuminated, but neither of two local Kia dealerships is willing to take responsibility since the "remedy is not available" from Kia. This means I have lost the safe use of my car for an indefinite period without any compensation from Kia.

NHTSA ID

11559774

Incident

Dec 12, 2023

My car sometimes lurches when I am moving from a stopped position. This is dangerous as it causes the car to hesitate when I am sometimes pulling out across traffic for a left turn. It is especially frequent when I am on a slight incline. It feels like it might have something to do with the transmission shifting from the EV mode. I have read about other people having the same problem with this car on online forums but there have been no recalls and they have the same trouble getting their dealerships to fix it. I took my car to the dealership multiple times, and they were able to reproduce the issue and thought it was initially something to do with calibrating the computers. It seemed to temporarily "fix" it so I picked it back up, just to have the same problem a week later. Since it happens sporadically, it has been difficult to get the dealership to fix the issue as sometimes they are unable to reproduce the issue.

NHTSA ID

11552928

Incident

Mar 17, 2023

TECHNICAL SERVICE BULLETIN: INFOTAINMENT SOFTWARE UPDATE PROCEDURE - This bulletin provides information on the process for downloading infotainment software updates and preparing USB for installation on applicable Kia vehicles. The software downloads and USB preparation process is similar across all supported platforms; however, in‑vehicle installation procedures vary by head unit type.

PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)

TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: KIA CONNECT MODEM RESET (SA611) - This bulletin outlines the procedure for resetting the modem in certain 2016-2025MY Kia vehicles listed on page 3 that are equipped with Kia Connect Services. The affected vehicles may encounter the following issues: remote Start/Climate Control function not working, vehicle Status on the Kia Access App not updating, connected routing not functioning properly.

This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.

TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR - ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.