Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 308 NHTSA owner-reported complaints for the 2003 Hyundai Santa Fe. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 308 · page 1 of 13
The contact owns a 2003 Hyundai Santa Fe. The contact stated while driving 30 MPH, the ABS system activated, and there was an abnormal shuddering in the brake pedal. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ABS needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
The driver's side rear trailing arm lower broke again. Was driving all of a sudden felt it start fishtailing and pulled over and thank God I didn't crash
Bought a set of duralast gold wrists a801116 asks since the day i put them in i had to replace parts whole charging a problem that turned out to be from the wires. Cause it was causing arcing in every one of the cylinders.
The contact owns a 2003 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the passenger’s side front wheel detached without warning. The wheel bearing and hub were replaced by the owner. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not contacted nor informed of the failure. The approximate failure mileage was 190,000.
BROUGHT MY VEHICLE IN FOR A ALIGNMENT AND THEY DISCOVERED THE RUSTED AND CORRADIATED REAR LEFT TRAILING CONTROL ARM ON MY 2003 HYUNDAI SANTA FE, I BROUGHT TO DEALERSHIP AFTER THAT TO GET A RECALL AND THE TOLD ME THAT SINCE THE VEHICLE WAS BOUGHT IN ND AND THAT STATE IS NOT INCLUDED IN THE RECALL THEY WILL DECLINE THE WORK, EVEN THOU MINN. IS RIGHT NEXT DOOR LIKE I LIVE ABOUT 1 MILE TO MN THEY STILL WOULDN'T EXCEPT THE RECALL, IT IS OBVIOUS THE PART THAT IS ON RECALL FITS MY CAR, WHEN LOOKING ON THE RIGHT SIDE ARM THERE IS NO RUST OR CORROSION. THE DEALER STATES IT IS NOT SAFE TO DRIVE VEHICLE, BECAUSE THE ARM IS STARTING TO BEND ALSO. SO WHAT DO I DO NOW, IT WILL BE VERY COSTLY TO FIX,
THE SUBFRAME IS RUSTED THROUGH. IT WAS GARAGE KEPT AND DOESN'T EVEN HAVE 150,000 MILES ON IT.
MY VEHICLE CALLS FOR A SWAY BAR N LINK IT DOES NOT HAVE ONE OR A PLACE TO PUT ONE FOR THE REAR PASSENGER SIDE. WHEN I GO OVER A BUMP IT MAKES A REAL LOUD NOISE. I REPLACED BOTH SHOCKS. NOISE IS STILL THERE. THERE ARE 4 RECALLS ON THIS CAR. RECALL #03V030000, #14V435000,#09V123000,03V520000. IN MOTION *TR
REAR TRAILING ARM CORRODED AND BUSTED WHILE IN MOTION. CAUSED REAR END TO COLLAPSE AND FISHTAIL. PASSENGER SIDE SNAPPED, DRIVERS SIDE IS VERY CORRODED. JUST PURCHASED THIS CAR A COUPLE WEEKS AGO, HAD NO IDEA THESE PARTS WERE UNSTABLE.
THE REAR END OF MY SANTA FE HAS RUSTED THROUGH AND THE BACK WHEELS WILL NOT TRACK IN A STRAIGHT LINE. HYUNDAI HAD A RECALL NR 09V123000 IN 4/16/2009 TO FIX THIS EXACT PROBLEM BUT ACCORDING TO HYUNDAI CUSTOMER ASSISTANCE, THIS RECALL DOES NOT APPLY TO ME BECAUSE MY SANTA FE WASN'T PURCHASED OR REGISTERED IN A SPECIFIC STATE. MY GRANDSON WAS DRIVING THE CAR AND NEARLY WRECKED. HYUNDAI WOULDN'T EVEN OFFER A TOW INTO A DEALERSHIP TO INSPECT THE PROBLEM.
MICHELIN X RADIAL LT2 P225/70R16 101T TIRES WITH DOT NUMBERS AP4V 003X 2614, AP4V 003X 2714, AP4V 003X 2614,AND AP4V 003X 2114. ALL 4 TIRES INSTALLED 09/04/2014 @ 80,421 MILES. 08/31/2019 ODOMETER AT 97,528 MILES. 17,107 MILES ON 75,000 MILE WARRANTY TIRES. TIRE DRY ROT AND CRACKING FIRST NOTICED IN 2015 AND HAS PROGRESSED TO THE POINT WHERE A TIRE PROFESSIONAL HAS STATED THAT THE TIRES ARE NO LONGER SAFE TO DRIVE WITH ON 08/31/2019. THERE IS A NEED FOR A DETERMINATION ON WHAT SIZE OF SIDEWALL AND TREAD CRACKING THAT WILL CAUSE A SAFETY RISK AND WHEN A MANUFACTURER SHOULD RECALL AND REPLACE FOR THESE DEFECTS. I HAVE TIRES FROM THE SAME MANUFACTURER THAT ARE YEARS OLDER THAT HAVE BEEN EXPOSED TO THE SUN A LOT MORE THAT DO NOT HAVE DRY ROT CRACKING ON THE SIDEWALL OR IN THE TREAD.
SUB FRAME WAS REPLACED DUE TO HIDDEN ROTTING OF INTERNAL MOUNTING STRUCTURE SEPARATION OF SUSPENSION COMPONENTS, CAUSING POOR CONTROL OF VEHICLE AND TIRE WEAR IN AUG. 2013. UNDER BODY WAS EXPOSED TO CORROSIVE WATER IN JULY, 2017 ABOUT THREE YEARS AGO AND HAS TURNED THE STEEL TO " CRACKERS " RUST CONDITION AND MADE IT UNSAFE TO BE ROAD WORTHY DUE TO POSSIBLE SEPARATION OF SUB FRAME AT BODY MOUNTS.. ALL REPAIRS WHERE AT MY EXPENSE. I FOUND SOME RECALLS TO LATE ON THE COMPUTER. I`M IN THE PROCESS OF REPLACING THE UNIT. I KEPT ALL RECORDS OF REPAIRS AND MAINTENANCE SINCE I PURCHASED IT USED. THE POWER TRAIN IS IN GOOD RUNNING ORDER. I`M NOT TO COMPUTER SAVEY ! I HAVE A FAX MECHINE. THANK YOU.
IN LATE AUGUST MY CAR WAS DUE FOR INSPECTION, SO I DROVE IT TO MY MECHANIC WHO INFORMED ME THAT EVERYTHING WAS GOOD TO GO EXCEPT WHAT I BELIEVE WAS THE FRONT ROCKER ARM(COULD BE WRONG) WAS RUSTED BUT WAS DO FOR A FREE RECALL BECAUSE OF RUST ISSUES. HE INSTRUCTED ME TO TAKE IT TO THE DEALER AND HAVE IT DONE FOR FREE, AND HE KEPT TELLING ME NOT TO LET THEM TRICK ME INTO PAYING FOR IT LIKE DEALERS TEND TO DO, SO HE HIGHLIGHTED ON THE RECALL THE LINES WHICH READS "ALL PARTS AND PROCEDURES WILL BE DONE FREE OF CHARGE" SO I DRIVE TO THE DEALER AND THEY SAY IT SHOULDNT TAKE MORE THAN A COUPLE DAYS, BUT MONTHS STARTED GOING BY WITH NO WORD FROM THEM AND ANYTIME I CALLED TO CHECK UP ON THE CARS STATUS, THEY WOULD LIE TO ME AND SAY "THE PART JUST ARRIVED AND WE'RE WORKIN ON ITNOW" BUT THEY TOLD ME THIS LIKE 6 TIMES, SO I ASKED THEM TO RETURN THE CAR UNTIL PARTS ARRIVED, THEY REFUSED AND CLAIMED LEGAL REASONS. THEN THEY DID RANDOMLY CONTACT MY SICK MOTHER AND TRY TO GET HER TO PAY 2400 DOLLARS! BEFORE THEY WOULD BEGIN WORK, EXPLAINING THEY WOULD BREAK SO MUCH STUFF IN THE PROCESS THAT IT WOULD COST 2400 FOR THE FREE RECALL, BUT 2 MECHANICS INCLUDING THE 1 THAT SENT ME ASSURED ME THAT WAS A LIE, AND THAT THE ONLY THING THEY SHOULD HAVE TO TOUCH DURING THE PROCEDURE IS BOLTS. SO I CALL THEM BACK AND ASK WHATS GOING ON WITH MY CAR AND FINALLY SOMEONE COMES CLEAN SAYING THAT WHILE THEY HAD MY CAR, THEY STARTED HAVING PROBLEMS WITH THE TRANSMISSION, SO THEY START TELLING ME THEY NEED TO WORK ON MY TRANSMISSION BEFORE RELEASING THE CAR. I SAID NO, DONT WORRY ABOUT THE TRANSMISSION, ILL WILL HAVE MY GUY WORK ON THAT AFTER THE RECALL IS COMPLETE. BUT THEY REFUSED TO WORK ON THE RECALL UNLESS I PAID THEM. THEY ALSO REFUSED TO RELEASE THE CAR, THEN A FEW MONTHS LATER I RECEIVED A LETTER TELLING ME TO HAVE MY CAR TOWED, THEY R NOT FIXING IT. SO NOW THE CAR I DROVE THERE NO LONGER WORKS.
BREAKS LOCK UP WHILE DRIVING BAD SMELL CAR WONT MOVE
I CAN HEAR A STRONG RUBBING AGAINST THE TIRE WHEN I COME TO SLOW DOWN AND STOP
"TAKATA RECALL" MY DRIVER SIDE FRONT WHEEL FEELS LIKE IT'S GONNA FALL OFF ALL THE LUG NUTS ARE TIGHT
2003 HYUNDAI SANTA FE, 180K MILES, 2ND OWNER. CUSTOMER STATES: FUEL LEAKING FROM FUEL TANK ONTO GROUND; SAFETY CONCERN & FIRE HAZARD. UNABLE TO PARK IN GARAGE/DRIVEWAY. FUEL LIGHT ON; LOW FUEL LEVEL. FILLED WITH $7.00 IN GAS ($2.70/GAL). AFTER FUELING, FUEL GAUGE HASN'T MOVED. ADDED MORE FUEL & SET GAS STATION FUEL NOZZLE TO AUTO STOP WHEN FULL. GAUGE SAYS 3/4 TANK (NORMALLY WOULD READ FULL TANK).THEN DROVE 12 MILES NO ISSUES. PARKED ON RESIDENTIAL STREET FOR 1-2 DAYS. SEARCHED ONLINE FOUND 'WARRANTY EXTENSION' ON FUEL TANK. DRIVING TO CERTIFIED HYUNDAI DEALER, 15 MILES AWAY. DROVE 5 MILES ON INTERSTATE, LOSING POWER. PULLED OFF AT NEAREST EXIT, DIED WHILE DRIVING IN TRAFFIC, OVER INTERSTATE BRIDGE. OIL, BATTERY, CHECK ENGINE LIGHT, ETC. ON. CARS BEHIND ME MAD, HONKING, RUSH HOUR. GOT IT STARTED, NOWHERE SAFE TO PULL OVER, LANE IEADS ME TO INTERSTATE, NOW HEADED IN OPPOSITE DIRECTION TOWARDS HOME. LOST POWER, DIED AGAIN, <1 MILE FROM HOME ON EXIT RAMP. LET SIT 4-5 HRS. DARK;11PM. RESTARTED, DROVE FEW FEET, DIED. DARK OUTSIDE. PUT IN NEUTRAL, ROLL BACKWARDS, STEER ONTO SHOULDER FOR SAFETY. DOT/SHERIFF TAGGED CAR NEXT A.M. CALLED HYUNDAI CONSUMER AFFAIRS & WAS ADVISED TO TOW TO DEALER. I DID. HYUNDAI STATING OUTSIDE OF MILAGE ALLOWANCE & NOT COVERED. WHY IS THIS NOT A SAFETY RECALL? THIS IS A PUBLIC SAFETY HAZARD! EVEN WHEN PARKED! FUEL LEAKS/ISSUES PUT THE PUBLIC AT RISK! NOT SAFE PARKING IN MY GARAGE/DRIVEWAY, PUBLIC/RESIDENTIAL STREETS, NEIGHBORHOODS, SCHOOLS, BUSINESSES/RETAIL PROPERTIES, LET ALONE DRIVING. WHAT IF A CIGARETTE IS TOSSED BY A PASSERBY, ROLLS UNDER A LEAKING FUEL TANK & LEADS TO FIRE, DAMAGES, INJURIES AND/OR DEATH(S) TO THOSE IN/AROUND VEHICLE? THIS SHOULD BE TAKEN MORE SERIOUSLY! IT'S A PUBLIC SAFETY HAZARD! MILEAGE SHOULDN'T MATTER (SEE LEXUS RECALL, JUNE 2018; CBS NEWS). CUST=SINGLE MOM & FT COLLEGE STUDENT=THE STRUGGLE IS REAL. PLEASE ADVISE.
2003 HYUNDAI SANTA FE, 180K MILES, 2ND OWNER. MY VEHICLE IS LEAKING GAS FROM THE FUEL TANK ONTO THE GROUND. I CAN'T EVEN PARK MY VEHICLE IN MY GARAGE OR DRIVEWAY DUE TO THE POSSIBILITY THAT IT WILL CATCH ON FIRE. I SEARCHED ONLINE AND FOUND OUT THE VEHICLE WAS ONE THAT HAS HAD A WARRANTY EXTENSION ON THE FUEL TANK, WHICH IS 15 YEARS OR 150,000 MILES WHICHEVER COMES FIRST. MY FUEL LIGHT WAS ON INDICATING MY FUEL LEVEL WAS LOW. I LIVE 15 MILES AWAY FROM THE NEAREST HYUNDAI DEALER SO I WAS TAKING IT IN TO HAVE IT INSPECTED BY A CERTIFIED HYUNDAI DEALER. I FILLED UP MY TANK WITH $7.00 OF GAS ($2.70/GAL). AFTER FUELING I GOT INTO MY CAR AND STARTED THE CAR. I NOTICED THE FUEL GAUGE HAD NOT MOVED AFTER FUELING. I PROCEEDED TO FILL UP THE CAR UNTIL FULL. SINCE IT IS NOT SAFE BECAUSE I CAN SEE THE FILE LEAKING, I CANNOT PARK ON MY PROPERTY AND PARKED ON THE STREET, AS FAR AWAY FROM OTHER HOUSES. IT DID NOT FEEL SAFE ON A PUBLIC STREET, IN A RESIDENTIAL NEIGHBORHOOD, JUST SITTING THERE BECAUSE THE POSSIBILITY OF IT CATCHING ON FIRE AND EXPLODING IN FLAMES. WHAT IF A DRIVER FLICKED OUT A CIGARETTE AND IT ROLLED UNDER MY VEHICLE, CATCHING IT AND ANYTHING AROUND IT ON FIRE? I ATTEMPTED TO TAKE IT TO THE DEALERSHIP, AFTER FILLING IT WITH A FULL TANK OF GAS. WHILE DRIVING TO THE DEALERSHIP, THE VEHICLE STARTED LOOSING POWER. I PULLED OFF ONTO THE NEAREST EXIT AND IT DIED, OIL LIGHT, BATTERY LIGHT, CHECK ENGINE LIGHT CAME ON (ETC). CARS BEHIND ME WHERE HONKING DURING RUSH HOUR TRAFFIC. ABLE TO GET IT STARTED AGAIN AND DECIDED TO TRY TO GET HOME AGAIN. VEHICLE LOST POWER AGAIN & DIED, THIS TIME NOT RESTARTING, EVEN AFTER SITTING 12 HOURS. I CALLED A TOW TRUCK AND HAD IT TOWED TO THE DEALER. HYUNDAI IS STATING I AM OUTSIDE OF THE MILES ALLOWANCE. WHY IS THIS NOT A MANDATORY RECALL? THIS IS A PUBLIC SAFETY HAZARD' EVEN WHEN PARKED! TIME/MILEAGE SHOULDN'T MATTER. MANY OTHERS LIKE MINE.
CURRENTLY THERE IS A NOISE UP FRONT OF THE CAR AND IN THE REAR A FRIEND THAT WAS RIDING IN MY CAR INDICATED THAT IT MAY BE A SUSPENSION PROBLEM. HE ALSO NOTED THAT THERE WAS A CLASS ACTION SUIT WITH HYUNDAI ABOUT A SUBFRAME RUST CORROSION ISSUE. THE NOISE HAS BECOME QUITE NOTICEABLE HE BELIEVES MIGHT CERTAINLY BE RELATED
THE AIRBAG LIGHTS KEEP COMING ON - I AM NOW ON MY THIRD REPAIR TO FIX THIS ONGOING PROBLEM. I LIKELY NEED TO REPLACE THE AIRBAGS! SO COSTLY BUT IT IS A SAFETY ISSUE SO HOW CAN I NOT? THIS IS A KNOWN AND ONGOING ISSUE AND HYUNDAI SHOULD BE RESPONSIBLE AND COVER THIS DEFECT.
AIRBAG LIGHT REMAINS ON SO THIS IS A SAFETY ISSUE. WILL I HAVE TO PAY FOR THIS? I REALLY DON'T KNOW THE HISTORY OF THIS VEHICLE I NEVER RECEIVED A CAR FAX ON IT. THAT IS WHY I NEED TO KNOW IF THERE WERE ANY RECALLS ON THE AIRBAG WITH THE AIRBAG LIGHT REMAINS ON. I KNOW THIS MIGHT BE BECAUSE OF THE MODULE HAVING TO BE REPLACED.
WHILE DRIVING OR STOPPED THE VEHICLE WOULD ACCELERATE TO THE HIGHEST RATE OF SPEED, ON IT'S OWN, AND I HAD TO PUT IT IN NEUTRAL TO STOP AN ACCIDENT FROM HAPPENING. THIS HAPPENED MORE THAN ONCE, ALMOST FATALLY INJURING SEVERAL PEDESTRIANS. WE TOOK IT TO THE DEALER FOR REPAIR AND IT WAS SO UNSAFE DUE TO THE ACCELERATION PROBLEM THEY WOULDN'T EVEN DRIVE IT ! I HAD TO HAVE IT TOWED BACK AND FORTH TO THE DEALER TWICE BEFORE THEY COULD EVEN FIGURE OUT WHAT THE PROBLEM WAS. NOW THEY ARE SAYING IT IS THE THROTTLE BODY ASSEMBLY. $1,753.11 FOR A VEHICLE THAT WAS GARAGED AND ONLY DRIVEN IN THE WINTER. 53,567 MILES ON IT. FOR A PART THAT REGULATES YOUR SPEED? THIS IS NOT THE FIRST TIME THIS IS REPORTED - THERE WAS A CASE IN JAPAN WHERE PEOPLE ACTUALLY DIED - AFTER GOING TO COURT THEY SAID IT WAS DRIVER ERROR - STEPPING ON THE GAS INSTEAD OF THE BRAKE. I HIGHLY DOUBT IT NOW - THERE ARE MANY MORE CASES AND REPAIRS LIKE THIS ONE - SOMEONE NEEDS TO DO A LITTLE RESEARCH. I FOR ONE WOULD LIKE A LITTLE HELP - I'M 73 YEARS OLD AND BOUGHT THIS CAR NEW - IT'S ALWAYS BEEN TAKEN CARE OF - THE DEALER HAS THE RECORDS.
I WAS DRIVING AN I CAME YO A STOP AN BEGAN TO TURN UP A SIDE BLOCK WEN I HEARD SOMETHING LIKE IT WAS METAL IN MERSL SCRAPPING SO I IMMEDIATELY PULLED OVER AN HAD TO CALL MY MECHANIC TO COME SEE WHAT WAS THAT AWFUL NOISE HE LAYER SHOWD UP LIFTED MY CAR IN THE AIR WHICH HE FOUND A LOT OF CORROSION AN RUST AN MY LOWER ARM CONTROL AN SUB FRAME NEEDING TO BE REPLACED UNDERNEATH MY CAR THATS WHY MY STEERING WHEEL WAS FREEWHEELING
CAR HAS CLUNKING NOISE IN FRONT END. MECHANIC SAID IT'S THE SUBFRAME BUSHINGS GOING IN AND OUT OF THE SUBFRAME AND RECOMMENDED REPLACING SUBFRAME. SAID CAR IS "UNSAFE TO DRIVE IN THIS CONDITION." THERE IS A RECALL IN "SALT-BELT" STATES. NOT SURE IT THEY CONSIDER UTAH A SALT-BELT STATE, BUT SALT IS USED HERE EXTENSIVELY IN THE WINTER.
MY AIRBAGS WERE DEFECTIVE. I WAS IN A CAR ACCIDENT, AND THE AIRBAGS DID NOT DEPLOY. AFTER THE ACCIDENT, I WAS TAKEN TO THE HOSPITAL TO TREAT MULTIPLE BODILY INJURING, WHICH COULD HAVE BEEN PREVENTED IF THE AIRBAG HAD DEPLOYED. I WAS DRIVING IN TOWN WHEN THE ACCIDENT OCCURRED. I OVERSHOT A TURN AND HIT A POLL ON THE LEFT SIDE OF THE CAR. THE CAR FLIPPED AND WAS TOTALED. AGAIN, NO AIRBAGS WERE DEPLOYED. I HAVE INCLUDED PICTURES OF THE CAR AFTER THE ACCIDENT. MY MAIN CONCERN IS THE ISSUE WITH THE AIRBAGS. I FEEL AS THOUGH THESE SHOULD HAVE WORKED PROPERLY AND THAT I AM FORTUNATE ENOUGH THAT THE ACCIDENT WAS NOT ANY WORSE, AS MORE SERIOUS INJURIES COULD HAVE THEN OCCURRED. IF NEEDED, I HAVE MORE PICTURES; HOWEVER, DUE TO THE FILE SIZE ALLOWED, I HAVE LIMITED IT TO KEY PICTURE. PLEASE LET ME KNOW.
MY AIRBAGS WERE DEFECTIVE. I WAS IN A CAR ACCIDENT, AND THE AIRBAGS DID NOT DEPLOY. AFTER THE ACCIDENT, I WAS TAKEN TO THE HOSPITAL TO TREAT MULTIPLE BODILY INJURING, WHICH COULD HAVE BEEN PREVENTED IF THE AIRBAG HAD DEPLOYED. I WAS DRIVING IN TOWN WHEN THE ACCIDENT OCCURRED. I OVERSHOT A TURN AND HIT A POLL ON THE LEFT SIDE OF THE CAR. THE CAR FLIPPED AND WAS TOTALED. AGAIN, NO AIRBAGS WERE DEPLOYED. I HAVE INCLUDED PICTURES OF THE CAR AFTER THE ACCIDENT. MY MAIN CONCERN IS THE ISSUE WITH THE AIRBAGS. I FEEL AS THOUGH THESE SHOULD HAVE WORKED PROPERLY AND THAT I AM FORTUNATE ENOUGH THAT THE ACCIDENT WAS NOT ANY WORSE, AS MORE SERIOUS INJURIES COULD HAVE THEN OCCURRED.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .