2004 Hyundai Santa Fe Fuel system Problems

This was a recall for hundai santa fe vehicles from 2001-2006. For unknown reasons I was not aware of recall. It was for 15 years or 150 miles. It is a danger as my car leaks gas. I am at 135,000 miles. But my car is a 2004. I purchased the vehicle in the last 2 years. I believe the recall should extend till the repair is complete for the reasons as follows. 1. it can explode. 2. it is a polluter 3. Hyundai acknowledges it as faulty equipment. 4. Corporations must be resonsible or they are irresponsible. 5. Cars are expensive they must maintain as least minimum safety requirements.

NHTSA ID

11420393

Incident

Jun 10, 2021

BOUGHT AN USED 2004 SANTA FE IN AUGUST FROM A DEALER. TWO WEEKS AGO I STARTED NOTICING A STRONG SMELL OF GAS AROUND MY VEHICLE AND LAST WEEK I BEGAN SEEING A SMALL DISCOLORED AREA ON THE CEMENT IN THE GARAGE. MOM CHECKED MY VEHICLE AND FOUND THAT THE MY FUEL TANK IS LEAKING. THE DISCOLORATION OF THE CEMENT UNDER MY VEHICLE IS IN FACT LEAKING GAS. TANK IS CORRODED AND I WILL NEED A NEW TANK INSTALLED.

NHTSA ID

11271416

Incident

Oct 27, 2019

Mileage

133,673 mi

VEHICLE FUEL TANK IS ROTTED AND LEAKING FUEL. CALL HYUNDAI AND THEY SAY ITS COVERED UNDER EXTENDED WARRANTY FOR 15 YEARS OR 150000 MILES. I AM OVER ON MILEAGE. THEY SAY NOT COVERED. WHAT DOES MILEAGE HAVE TO DO WITH CORROSION?

NHTSA ID

11133468

Incident

Oct 5, 2018

Mileage

180,050 mi

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE THE VEHICLE WAS PARKED, THERE WAS AN ABNORMAL ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. THE CONTACT NOTICED FUEL LEAKING AND THAT THE CHECK ENGINE INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (COLUMBIA HYUNDAI, 10981 MONTGOMERY RD, CINCINNATI, OH 45249, (513) 489-2000) WHERE IT WAS DIAGNOSED THAT THE COIL SPRING AND FUEL TANK NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS 15 YEARS OLD AND EXCEEDED THE MILEAGE TO BE INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 198,000.

NHTSA ID

11084734

Incident

Jan 1, 2018

Mileage

198,000 mi

BROUGHT VEHICLE IN TO SHOP FOR FRONT END NOISE. FOUND NEEDED FRONT BRAKES, PADS, ROTOR, CALIPER. REPAIRED THE ITEMS.THE SHOP ALSO NOTICED AND STATED "HAS A FUEL LEAK AT THE TANK (SHOULD BE A RECALL"). I DON'T FIND ANY RECALL HERE. ANY SUGGESTIONS? I'M NOT MAKING A COMPLAINT, JUST NEED TO KNOW IF THIS IS A RECALL. THANK YOU. *TR

NHTSA ID

10948919

Incident

Dec 20, 2016

Mileage

71,417 mi

CATALYST CONVERTER CALIFORNIA

NHTSA ID

10948145

Incident

Jan 23, 2016

IT DON'T WORK RITE WHEN I LET THE CAR WARM UP AND THEN PUT MY FEET ON THE BRAKES IT SOUND LIKE IT DON'T WANTED TO GIVE GAS I SMELL GAS BUT I DON'T SEE ANY ON THE GROUND THE END TAKE IS ALL MESS UP THE AIR BAGS DO NOT GO OFF IT STAY ON AND I KEEP EVERYTHING UP TO THE CAR JUST DON'T ACT RITE

NHTSA ID

10934928

Incident

Dec 10, 2016

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE THE VEHICLE WAS PARKED OR BEING DRIVEN, THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. IN ADDITION, THERE WAS FUEL LEAKING FROM THE REAR OF THE VEHICLE. AN INDEPENDENT MECHANIC STATED THAT FUEL WAS LEAKING FROM THE SEAM OF THE FUEL TANK AND THE FUEL TANK NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 138,900.

NHTSA ID

10925982

Incident

Oct 29, 2016

Mileage

138,900 mi

MY SANTA FE STAY OVER NITE, INSIDE MY GARAGE AND I NOTICE VERY STRONG ODOR OF GASOLINE EVERY TIME I OPEN MY GARAGE AND AFTER I LOOK UNDER, I SPOT A DROP OF GASOLINE ON THE PASSENGER SIDE BETWEEN A PLASTIC COVER AND THE FUEL TANK, WHILE IS PARK OVER NITE, WHILE I AM DRIVING I AM AFRAID THAT SOMETHING HAPPEN, LIKE PEOPLE THROWING CIGARETTE BUT AND CUT MY CAR ON FLAME. AFTER I READ OTHER PEOPLE RECENT COMPLAINTS I DECIDE TO STOP USING MY SANTA FE, I THINK THIS IS A DEFECT FROM HYUNDAI TO CREATE A FUEL TANK THAT HOLDS WATER AND SALT BETWEEN THE TANK AND THE COVER. *TR

NHTSA ID

10918148

Incident

Sep 20, 2016

Mileage

173,000 mi

WHEN CAR PARKED SMELL OF GASOLINE, LOOKED UNDER CAR ON DRIVE SIDE OF TANK HAS TINY DROP OFF FUEL COME FROM PLASTIC COVER OF TANK AND A DROP ON GROUND LOOKS IT WAS SPREAD BY CONTINUOUS SLOW WEEPING WHEN PARKED, DRAW FOR A WHILE CAME BACK PARKED WENT BACK AND CHECK UNDER SAME SPOT TINY DROP ON GROUND COMING FROM PLASTIC COVER DRAIN HOLE, DID NOT SEEM LOOSE MUCH GAS, PARK OVER WEEKEND FOUND DRIP SMELL AND THE DRY SPOT SEEMED ABOUT ONE FOOT IN DIAMETER AND STRONG ODOR WHEN GO NEAR BACK OF CAR, NOTICED THIS AT PARKED VEHICLE, OVER NIGHT PARKED THE SPOT IS ABOUT 6 INCHES DRIED WET ABOUT 1 INCH EVERY DAY LAST FEW WEEKS. FUEL SMELL NOTICED ALL THE TIME MAY BE 6 SIX MONTHS NOW DID NOT KNOW WHERE OR WHOSE CAR IT WAS COMING, WHEN LOOKED UNDER ON DRIVER SIDE BEFORE REAR WHEEL ABOUT 1 FOOT INWARD SAW A WET SPOT ABOUT 1 INCH, DRAW BACK CHECKED IT WAS GAS SPOT AROUND DRIED IMPRESSION WAS ABOUT FOOT THIS WAS IN MORNING AFTER OVER NIGHT PARKING, I OPEN ACCESS UNDER THE REAR DRIVER SIDE OF SEAT CAN NOT FIND ANY LEAK FROM FUEL PUMP OR TUBES I AM GOING TO CHECK ON OTHER ACCESS HOLE BUT THAT IS ON PASSENGER SIDE, LEAK IS UNDER DRIVER SIDE OF THE TANK PLASTIC COVER DRAIN HOLE.

NHTSA ID

10903545

Incident

Aug 20, 2016

Mileage

140,000 mi

COMPLAINT HYUNDAI MOTOR AMERICA HAS ADMITTED DESIGN/PRODUCT DEFECTS WITH SIX YEARS (2001-06) OF THEIR SANTA FE FUEL TANKS VIA AN EXTENDED WARRANTY NOTIFICATION ISSUED 2016/Q1. THIS COMPLAINT CONCERNS HYUNDAI'S PRODUCT LIABILITY AND WARRANTY, WITH UNDERSTANDING PRECEDENT HAS BEEN ESTABLISHED WITH OTHER HYUNDAI PRODUCT DEFECTS AND RECALL/WARRANTY RESOLUTIONS VIA THE FRONT SPRING COIL CORROSION RECALL IN 'SALT BELT STATES'. DESIRED RESOLUTION HYUNDAI MOTOR AMERICA TO PROVIDE WARRANTY COVERAGE FOR MY SPECIFIC VEHICLE PER SCOPE DESCRIBED WITHIN THE EXTENDED WARRANTY NOTIFICATION. I WOULD SIMPLY LIKE TO HAVE EXTENDED WARRANTY SERVICE COMPLETED AT MY LOCAL HYUNDAI DEALERSHIP.

NHTSA ID

10899021

Incident

Aug 31, 2004

A STRONG ODOR OF GASOLINE WAS NOTICEABLE UPON ENTERING MY GARAGE. FURTHER INSPECTION REVEALED GAS LEAKING FROM MY '04 HYUNDAI SANTA FE. THE SERVICE STATION DETERMINED THAT A FUEL TANK AND CENTER HEAT SHIELDING REPLACEMENT WAS NECESSARY AS BOTH WERE DEFECTIVE, LEAKING FUEL, AND POSED A VERY HIGH RISK OF DANGER. NEEDLESS TO SAY, I WAS STUCK PAYING A VERY HEFTY BILL TO THE REPAIR CENTER RATHER THAN WORRYING ABOUT BLOWING UP MYSELF, MY PASSENGERS, OR MY HOUSE. I SEE THAT THERE HAVE BEEN OTHER COMPLAINTS ABOUT THE SAME PROBLEM WITH THIS MAKE AND MODEL OF HYUNDAI.

NHTSA ID

10845592

Incident

Aug 26, 2014

Mileage

115,000 mi

CAR STALLS WITHOUT WARNING WHILE DRIVING. FIRST OCCURRENCE WAS OVER A YEAR AGO. I WAS DRIVING DOWN I5 GOING 70 MPH WHEN THE CAR SUDDENLY DIED. I LOST MY POWER STEERING AND BRAKES. I MANAGED TO COAST TO THE NEXT EXIT. IT STARTED AFTER SITTING A FEW MINUTES. AND I WAS ABLE TO MAKE IT HOME. I'VE RECEIVED CODES FOR CAMSHAFT SENSOR, MISFIRES, LOW CATALYST. I'VE CHANGED THE CAM AND CRANK SENSORS, COILS, SPARK PLUGS, TIMING BELT AND ASSEMBLY, FUEL PRESSURE REGULATOR AND FUEL PUMP OVER THE PAST YEAR. STILL HAVING THE ISSUE. CAR DRIVES FANTASTIC FOR ABOUT 10 MILES AND STALLS OUT. AFTER WAITING ABOUT 5 MIN. IT CAN BE DRIVEN FOR ANOTHER FEW MILES BEFORE STALLING OUT AGAIN. CHECK ENGINE LIGHT DOES NOT TURN ON WHEN IT STALLS NOW. VERY DANGEROUS WHEN TRYING TO DRIVE IN TOWN OR ATTEMPTING TO MERGE INTO TRAFFIC. YOU NEVER KNOW WHEN IT WILL STALL OUT.

NHTSA ID

10825883

Incident

Oct 11, 2014

Mileage

102,000 mi

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTE FE. AFTER THE VEHICLE WAS REFUELED, THE CONTACT NOTICED FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

NHTSA ID

10825326

Incident

Feb 8, 2016

Mileage

180,000 mi

WHEN I PUT GAS IN MY CAR IT WILL NOT START AFTERWARD. FIRST IT STARTED ONLY WHEN MY CAR WAS TURNED OFF. WHEN I LEFT MY CAR RUNNING IT WAS OK. NOW IT TURNS OFF WHEN MY CAR IS RUNNING ALSO. THE MECHANIC SAID, IT MAY BE A BAD FUEL PUMP, COST $350 TO REPLACE, BUT CAN'T GUARANTEE THIS WILL FIX THE ISSUE. I SEE I AM NOT THE ONLY ONE WITH THIS ISSUE. WHY IS THIS NOT A RECALL?? I GOOGLE IT AND THERE ARE SO MANY PEOPLE WITH SAME PROBLEM. ALSO WITH THE CAR ACCELERATING BY ITSELF. I THOUGHT I WAS CRAZY. I SEE NOW THAT OTHERS ARE HAVING THIS PROBLEM AS WELL. EVERYONE SAID I IMAGINED IT. WHY IS THIS NOT A RECALL?

NHTSA ID

10807296

Incident

Nov 28, 2015

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. IMMEDIATELY AFTER REFUELING THE VEHICLE, IT WOULD SUDDENLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE PURGE VALVE FAILED AND THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 92,000.

NHTSA ID

10786932

Incident

Sep 1, 2015

Mileage

92,000 mi

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT IMMEDIATELY AFTER REFUELING THE VEHICLE, IT WOULD SUDDENLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE PURGE VALVE AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 92,000.

NHTSA ID

10786610

Incident

Dec 30, 2014

Mileage

92,000 mi

I SMELLED GAS RECENTLY WHEN OPENING AND GETTING INTO MY 2004 SANTA FE. I TOOK IT TO A CAR REPAIR SHOP. THEY INSPECTED IT AND FOUND RUST HOLES IN THE GAS TANK WHICH GAS WAS LEAKING OUT OF! I CAN'T IMAGINE THE HOW TERRIBLE AN EVENT COULD HAVE OCCURRED IF THE LEAKING GAS HAD EXPLODED WHEN I STARTED THE CAR OR BEEN CLOSE TO AN OPEN FLAME WITH THE CAR WHEN IT WAS LEAKING. I HAVE OWNED MANY CARS IN MY LIFE AND HAVE NEVER HAD A FUEL TANK RUST OUT. I THINK THE NHTSA NEEDS TO TAKE A VERY CLOSE LOOK AT THIS PROBLEM AND POSSIBLY ISSUE A RECALL ON THE GAS TANKS OF SANTA FES AND OTHER VEHICLES THEY MANUFACTURE THAT USE THE SAME GAS TANK.

NHTSA ID

10779206

Incident

Oct 1, 2015

Mileage

148,750 mi

I BROUGHT THE VEHICLE IN FOR AN OIL CHANGE. THE GENTLEMAN SAID THAT THE FUEL TANK HAS A RUST HOLE IN IT AND IS LEAKING FUEL. THIS IS CAUSED BY A PLASTIC COVER THAT RETAINS SALT AND MOISTURE AND CAUSES THE TANK TO RUST. *TR

NHTSA ID

10640779

Incident

Oct 2, 2014

THE VEHICLE HAD A STRONG SENT OF GASOLINE WHEN PARKED. THE VEHICLE WAS TAKEN TO THE MECHANIC, I WAS INFORMED THAT IT WAS A GAS LEAK AND THE GAS TANK HAD TO BE REPLACED. AFTER THE GAS TANK WAS REPLACED, THE MECHANIC INFORMED ME THAT THE TANK HAD RUSTED AND THAT WAS THE REASON FOR THE LEAK. HE SHOWED ME THE GAS TANK AND THERE WAS EXTENSIVE RUST ON IT. THERE WAS A PLASTIC PART UNDER THE TANK THAT RETAINED WATER AND ROAD SALT AND CAUSED THE TANK TO PREMATURELY RUST. THERE IS NO REASON FOR A VEHICLE THAT IS GARAGED AND WASHED REGULARLY TO HAVE A RUSTED OUT GAS TANK. CLEARLY, THERE IS A DESIGN FLAW THAT ALLOWED THE PLASTIC PART UNDER THE TANK TO COLLECT WATER AND RUST. *TR

NHTSA ID

10633155

Incident

Sep 1, 2014

Mileage

107,000 mi

THERE IS A STRONG SMELL OF GASOLINE COMING FROM MY VEHICLE - IT CONSUMES BOTH THE INTERIOR AND THE AROUND THE ENTIRE EXTERIOR OF THE VEHICLE. LOOKING AT ALL OF THE COMPLAINTS, THIS IS NOT THE FIRST TIME THIS HAS HAPPENED. WHY ISN'T THERE A RECALL?? HYUNDAI - ARE YOU DOING ANYTHING TO HELP YOUR CUSTOMERS????? *TR

NHTSA ID

10607248

Incident

Jun 26, 2014

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK WAS CRACK AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 97,000.

NHTSA ID

10597401

Incident

Jun 1, 2014

Mileage

97,000 mi

DIES IN THE MIDDLE IF ROAD! ALMOST DIE. ALL THE TIME!!!!!! DIES IN THE MIDDLE IF ROAD! ALL THE TIME!!!ALMOST DIED. *TR

NHTSA ID

10596553

Incident

Apr 13, 2011

Mileage

20,000 mi

GAS TANK LEAK NEAR THE EXHAUST SYSTEM. CAUSE BELIEVED TO BE DUE TO A DESIGN FLAW. THE BOTTOM OF TANK WAS COVERED BY A POLY SHELL. THE SHELL TRAPPED MOISTURE AND SALT, ETC. BETWEEN BOTTOM OF METAL TANK AND POLY SHELL. THIS SET UP A CORROSION ENVIRONMENT AND RESULTED IN LEAK. NEW REPLACEMENT TANK FROM HYUNDAI DOES NOT HAVE THE POLY SHELL. NOTE: THE VEHICLE HAS NO RUST AND IS IN VERY GOOD CONDITION. *TR

NHTSA ID

10595262

Incident

Feb 14, 2014

Mileage

111,000 mi

AFTER PULLING INTO TRAFFIC, I LIFTED MY FOOT FROM THE ACCELERATOR WHEN I REACHED MY DESIRED SPEED. HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. I APPLIED THE BRAKE, AND THE ENGINE CONTINUED TO REV FOR 1 OR 2 SECONDS. THERE WAS NO ACCIDENT ON THIS OCCASION, BUT IT WAS TERRIFYING, AND I HAD MY CHILD IN THE VEHICLE. *TR

NHTSA ID

10593533

Incident

May 22, 2014

Mileage

116,000 mi