Owner-reported complaints naming the visibility system, filed with NHTSA
Data refreshed
Reports naming windshields, glass, wipers, defrosters and mirrors. Every record below is an owner-reported complaint about the 2004 Hyundai Santa Fe submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE SUNROOF DETACHED FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING AND MAKING A LEFT TURN, THE CONTACT HEARD A LOUD EXPLOSIVE NOISE. THE DRIVER SIDE DOOR WINDOW SHATTERED INTO PIECES WITHOUT IMPACT. THE VEHICLE WAS TAKEN TO A GLASS REPAIR CENTER WHERE THE DRIVER SIDE WINDOW WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,248. UPDATED 09/06/16*LJ *TR
THE LEFT (DRIVER SIDE) QUARTER PANEL GLASS (NON OPENING) DROPPED OUT OF THE CAR WHILE IT WAS SITTING STATIONARY IN THE DRIVEWAY. THE GLASS DID NOT BREAK WHEN IT DROPPED OUT, IT SIMPLE BECAME DETACHED FROM THE SEALANT AND CAR BODY. THIS QUARTER OF THE AUTO HAD BEEN INVOLVED IN AN ACCIDENT (HIT WHILE PARKED IN A HOSPITAL PARKING LOT.) APPROXIMATELY TWO YEARS AGO. REPAIR AT THAT TIME CONSISTED OF REPLACING THE LEFT REAR LIGHT BOX AND SOME MINOR BODYWORK PRIOR TO PAINTING. THERE HAS BEEN NO INDICATION OF AN ISSUE WITH THE WINDOW PRIOR TO IT'S FALLING OUT. *TR
SO MANY THINGS GOING WRONG BACK SEAT BELTS DON'T WORK, WASHER PUMP DON'T WORK TRIED TO ORDER PART FROM DEALER DO NOT HAVE ANY IN US THE CAMSHAFT SENSOR PIGTAIL DISINTEGRATED FROM BEING TO CLOSE TO THE ENGINE AND NO ONE SELLS THE PART HAVE TO BUY THE COMPLETE ENGINE WIRING KIT FOR ONE LITTLE PLASTIC PIECE THERE SHOULD BE A RECALL ON THIS I READ ONLINE THAT EVERYONE WITH THIS CAR HAD THE SAME PROBLEMS. *TR
2004 HYUNDAI SANTA FE DRIVER'S SIDE SUN VISOR BROKEN - HANGS IN FRONT OF DRIVER. INTERNET RESEARCH SHOWS THIS IS A VERY, VERY COMMON PROBLEM FOR ALL HYUNDAI MODELS FROM 2000 - 2010. *TR
WE OWN A 2004 HYUNDAI SANTE FE AND HAVE BEEN HAVING PROBLEMS WITH THE SUN VISORS. THE DRIVERS SIDE SUN VISOR HAS BROKEN TWICE. IT NO LONGER HAS ENOUGH FRICTION TO HOLD IT UP AND HANGS DOWN IN THE DRIVERS LINE OF SITE. THE FIRST OCCURRENCE WAS REPLACED UNDER WARRANTY. THE SECOND WAS OUT OF THE WARRANTY PERIOD, 70,000 MILES, AND REPLACEMENT PART IS A $170. THE DRIVERS VISOR BLOCKING THE DRIVERS VIEW IS SAFETY ISSUE. I BELIEVE THIS MAY BE A COMMON PROBLEM AFTER IT HAS HAPPENED TO OUR VEHICLE TWICE. AVAILABILITY OF USED PARTS IS SCARCE DUE TO SO MANY PROBLEMS AND I HAVE FOUND OTHER REMARKS ONLINE ABOUT THE SAME PROBLEMS. THESE VISORS SHOULD BE RECALLED AND REPLACED BY HYUNDAI. *TR
TL*THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING 20 MPH IN THE RAIN, THE PASSENGER SIDE WINDSHIELD WIPER SHUT OFF. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 39,995.
A ROCK HIT THE WINDSHIELD WHILE DRIVING ON THE HIGHWAY AND THE WINDSHIELD EXPLODED. THE DRIVER PULLED OVER, AND HAD THE VEHICLE TOWED TO THE DEALER. *AK THE DAMAGE WAS EXTENSIVE EVEN THOUGH THE OBJECT DID NOT COME THROUGH THE WINDSHIELD. THE IMPACT LITERALLY BROKE THE INSIDE OF THE WINDSHIELD APART AND CAUSED SHARDS OF GLASS AS WELL AS PULVERIZED (POWDER CONSISTENCY) GLASS TO STRIKE THE CONSUMERS WIFE IN THE FACE AS WELL AS SPRAYING GLASS THROUGHOUT THE VEHICLE. *SC *JB
CONSUMER NOTICED VEHICLE HEATER KNOB WAS LOOSE. WHILE TURNING HEAT ON HEATER IT DID NOT RESPOND. DEALERSHIP SERVICED VEHICLE.*AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .