2000 Isuzu Rodeo

On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.

DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.

EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH

NHTSA ID

11398023

Incident

Feb 24, 2021

Mileage

130,000 mi

TL* THE CONTACT OWNED A 2000 ISUZU RODEO. WHILE DRIVING 25 MPH, THE CONTACT BECAME DISTRACTED AND CROSSED THE YELLOW LANE LINES. IN AN ATTEMPT TO AVOID AN ONCOMING VEHICLE, THE CONTACT JERKED THE VEHICLE TO THE SIDE AND CAUSED THE VEHICLE TO ROLLOVER. THE VEHICLE CRASHED INTO THREE TREES AND ROLLED OFF A CLIFF. IN ADDITION, THE CONTACT STATED THAT THE SEAT BELT FAILED TO RETRACT AND CAUSED THE CONTACT TO BE THROWN AROUND INSIDE THE VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A FRACTURED STERNUM, A CONCUSSION, AND INJURIES TO THE RIGHT KNEE THAT REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE FAILURE MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10967588

Incident

Mar 9, 2014

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2000 ISUZU RODEO. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD AN UNUSUAL NOISE AND NOTICED THAT THE FRONT BODY FRAME WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.

NHTSA ID

10959044

Incident

Feb 28, 2017

Mileage

151,000 mi

TL* THE CONTACT OWNS A 2000 ISUZU RODEO. WHILE DRIVING BETWEEN 35-40 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE, WHICH RESULTED IN A SIDE IMPACT COLLISION. THE FAILURE OCCURRED WITHOUT WARNING. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT DUE TO SEVERE FRAME CORROSION, THE FRAME DETACHED AND STRUCK THE REAR DRIVER WHEEL, WHICH ULTIMATELY CAUSED THE CRASH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000. ...UPDATED 03/08/17 *BF

NHTSA ID

10947748

Incident

Jan 25, 2017

Mileage

125,000 mi

TL* THE CONTACT OWNS A 2000 ISUZU RODEO. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE, THE TECHNICIAN DIAGNOSED THAT THE SUBFRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN A VOLUNTARY MANUFACTURER'S RECALL; HOWEVER, THE MANUFACTURER STATED THAT IT HAD EXPIRED. THE FAILURE MILEAGE WAS 213,000.

NHTSA ID

10919042

Incident

Oct 3, 2016

Mileage

213,000 mi

I BOUGHT MY 2000 RODEO NEW AND IT CURRENTLY HAS 37000 ACTUAL MILES. I RECENTLY SAW RUST IN THE DRIVEWAY. I TOOK THIS CAR TO A HONDA BODY SHOP TO SEE THE UNDERBODY. BEFORE PUTTING IT ON THE LIFT THEY SAW THAT THE FRAME WAS EXCESSIVELY RUSTED. ONCE IN THE AIR THEY LOOKED AT THE WHOLE UNDERSIDE AND SAID THAT THE FRAME AND THE LOWER CONTROL ARM WERE HOLED WITH RUST. I ASKED IF ANY OF THIS WAS REPAIRABLE.THEY SAID THEY WOULD NOT DO THE WORK BECAUSE THEY WOULD NOT ASSUME THE LIABILITY OF A SERIOUS ACCIDENT. THIS VEHICLE HAD THE FIXES PRESCRIBED BY CAMPAIGN 10V-436 SB 10-11-S002A COMPLETED AT SELLERS TRUCK CENTER IN FARMINGTON HILLS, MI ON SEPTEMBER 9, 2011. THIS ADDRESSED THE REAR SUSPENSION BUT OBVIOUSLY THE CORROSION WAS SO PERVASIVE THAT THIS CAMPAIGN WAS JUST A BAND-AID. AS I READ THE VARIOUS COMPLAINTS ON THIS SITE I STRONGLY AGREE THAT THESE CARS ARE A SAFETY HAZARD AND SHOULD BE BOUGHT BACK BY ISUZU AND TAKEN OFF THE ROAD. LIKE MANY OTHERS I HAVE SIDELINED MINE AND BEEN FORCED TO BUY ANOTHER CAR TO REPLACE IT WAY BEFORE IT WAS NECESSARY. IRONICALLY, THIS CAR IS IN ALMOST PRISTINE CONDITION FROM THE BODY UP. I HAVE CONTACTED ISUZU AND RECEIVED A LETTER IN RETURN IN WHICH THEY ASSERT THAT THEY DID EVERYTHING THEY HAD TO AND THAT THE ORIGINAL RECALL DID NOT REQUIRE MORE THAN DEALING WITH THE REAR SUSPENSION AND THEREFORE I WAS OUT OF LUCK. IN THE LETTER THEY SAID I COULD CALL FOR MORE INFORMATION. I DID AND THEY OFFERED TO 'REDO THE PROCEDURES OF THE ORIGINAL RECALL.' WHEN I POINTED OUT THAT I HAVE A CAR THAT IS UNSAFE TO DRIVE AND THAT THE FACILITY THEY WANTED IT TAKEN TO IS AN HOUR AND A HALF AWAY THEIR COMMENT WAS 'NO ONE SAID YOU HAD TO DRIVE IT. YOU COULD TRAILER IT.' THIS ISN'T A GOOD ALTERNATIVE EITHER ESPECIALLY SINCE I HAVE A HONDA DEALER LESS THAN TWO MILES FROM MY HOUSE AND THE HONDA PASSPORT SUFFERED ALL THE SAME

NHTSA ID

10905061

Incident

Aug 10, 2016

Mileage

37,000 mi

TL* THE CONTACT OWNS A 2000 ISUZU RODEO. WHILE THE VEHICLE WAS BEING SERVICED FOR ROUTINE MAINTENANCE, THE CONTACT WAS INFORMED BY THE MECHANIC THAT THE VEHICLE HAD EXCESSIVE CORROSION TO THE SUBFRAME. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE AND COULD NOT BE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

NHTSA ID

10763703

Incident

Sep 11, 2015

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2000 ISUZU RODEO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE VEERED TO THE LEFT INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 10V436000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000.

NHTSA ID

10763497

Incident

Sep 11, 2015

Mileage

102,000 mi

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.

The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find equivalent of similar products (when available) from Loctite and Permatex.

The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely for information tracking purposes and future contact reference.

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.