RoadVitals

1994 Isuzu Rodeo

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
82
Latest Feb 7, 2012
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Latest Jul 17, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
2
1 currently open
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
7
13 injuries, 0 deaths reported

Overview

Our database contains 82 NHTSA owner-reported complaints for the 1994 Isuzu Rodeo, most frequently naming the electrical, engine and transmission categories. 5 safety recalls have been issued covering this model year; 2 NHTSA investigations name it; and 6 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

5 campaigns cover this model year

View all 5

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06E065000

EXTERIOR LIGHTING

Jul 17, 2006
3,593 units potentially affected
The defect: CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
The remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
AJ MOTORSPORTView on NHTSA.gov
02V281000

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Oct 15, 2002
14,449 units potentially affected
The defect: ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.
The risk: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.
The remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MID-DECEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.
ISUZU MOTORS LIMITEDView on NHTSA.gov
97V034001

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Mar 7, 1997
118,485 units potentially affected
The defect: AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.
The risk: THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.
The remedy: DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.
ISUZU MOTORS LIMITEDView on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

SQ96009OpenInvestigation

BRUSH/GRILLE GUARD CAMPAIGN

Opened Jan 10, 1996

ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.LOSS OF AN ITEM THIS SIZE WOULD HAVE SAFETY COSEQUENCES.THIS SQ IS OPENED TO LEARN MORE ABOUT THIS ISSUE.

UNKNOWN OR OTHER
RQ02009ClosedRecall Query

SEAT BELT LATCH FAILURES

Opened Apr 11, 2002
Closed Dec 17, 2002

TAKATA/NISSAN/ISUZU HAVE DETERMINED THAT DURING THE INITIAL RECALL CAMPAIGN (96V-170), SOME VEHICLES THAT CONTAIN DEFECTIVE SEAT BELT BUCKLES WERE INADVERTENTLY OMITTED FROM THE CAMPAIGN. NISSAN WILL RECALL 92,500 MY1994 PATHFINDER AND D21 PICKUP TRUCKS (02V-125).ISUZU WILL RECALL 13,831 MY1994/1995 RODEO, AMIGO, TF AND PICKUP TRUCKS (02V-281) .ISUZU IS ALSO RECALLING 618 MY 1994 HONDA PASSPORT VEHICLES UNDER RECALL 02V-281 (THE HONDA PASSPORT IS MANUFACTURED BY ISUZU FOR HONDA AND IS SIMILAR TO THE ISUZU RODEO VEHICLE). THIS INVESTIGATION IS CLOSED.

SEAT BELTS:FRONT:BUCKLE ASSEMBLYLed to recall 02V125000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 82
Body & structure
Filed Feb 7, 2012

TL* THE CONTACT OWNS A 1994 ISUZU RODEO. THE CONTACT STATED THAT THERE WAS SEVERE RUSTING ON THE BASE OF THE VEHICLE. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 150,000. THE VIN WAS UNAVAILABLE.

NHTSA ID
10447001
Incident
Feb 7, 2012
Mileage
150,000 mi
Engine
Filed Jul 11, 2011

TL* THE CONTACT OWNS A 1994 ISUZU RODEO. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE CAMSHAFT SEAL END PLUG NEEDED TO BE REPLACED. THE MECHANIC REFERRED THE CONTACT TO THE MANUFACTURER BECAUSE THERE WAS A RECALL FOR THE COMPONENT UNDER NHTSA CAMPAIGN ID NUMBER: 94V132000 (ENGINE AND ENGINE COOLING:ENGINE). THE MANUFACTURER STATED THE VEHICLE HAD PREVIOUS RECALL REPAIRS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 168,600 UPDATED 10/21/11 *BF THE CONSUMER STATED THE CAM SHAFT SEAL PLUG CAME OUT AGAIN CAUSING OIL TO LEAK ON THE EXHAUST, WHICH CAUSED SMOKE TO EMIT FROM THE VEHICLE. UPDATED 11/02/11

NHTSA ID
10411773
Incident
Jan 26, 2011
Mileage
168,600 mi
Fuel system
Filed Jun 9, 2010

STRONG FUEL ODOR INSIDE REAR OF VEHICLE FROM 1997 TO PRESENT. DEALER COULD NEVER LOCATE SOURCE. *TR

NHTSA ID
10335498
Incident
Mar 24, 1997
Mileage
30,000 mi
Driver assistance
Filed Jun 9, 2010

GAS PEDAL BECOMES STUCK AND ACCELERATION CONTINUES. ACCELERATOR CABLE FROM PEDAL TO THROTTLE IS BECOMES STUCK OFTEN. I HAVE TO SLAM ON THE GAS PEDAL MULTIPLE TIMES TO GET IT TO FREE UP. *TR

NHTSA ID
10335497
Incident
May 20, 2010
Mileage
73,000 mi
ElectricalTransmission
Filed Jun 9, 2010

AUTOMATIC TRANSMISSION WIRE HARNESS DETERIORATED DO TO EXCESSIVE HEAT, ROUTED TO CLOSE TO CATALYTIC CONVERTER CAUSING VEHICLE NOT TO SHIFT AND DISABLING BOTH TRANSMISSION WARNING LIGHTS. VEHICLE ONLY HAS 78K MILES ON IT AND WIRE COVERING/INSULATION SHOULD NOT BE LITERALLY BURNED AWAY WITH SUCH LOW MILES ON THE VEHICLE. *TR

NHTSA ID
10335495
Incident
Jun 7, 2010
Mileage
78,000 mi
Body & structure
Filed Mar 13, 2010

FRAME RUSTED THROUGH ,UNINSPECTABLE, MOUNTS ON FRAME ARE VERY WEAK. *TR

NHTSA ID
10319450
Incident
Mar 10, 2010
Mileage
145,000 mi
Engine
Filed Nov 19, 2008

TL*THE CONTACT OWNS A 1994 ISUZU RODEO. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN LEAKING OIL. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 94V132000 (ENGINE AND ENGINE COOLING:ENGINE). HE CALLED THE MANUFACTURER REGARDING THE RECALL AND WAS INFORMED THAT THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED ACCORDING TO THE RECALL. THE CONTACT STATED THAT HE HAS BEEN THE ONLY OWNER OF THE VEHICLE AND THE REPAIR WAS NEVER PERFORMED. THE MANUFACTURER WOULD NOT REPAIR THE FAILURE. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 158,000.

NHTSA ID
10249285
Incident
Nov 17, 2008
Mileage
158,000 mi
Tires & wheels
Filed Jun 13, 2008
Crash reported5 injuries reported

REAR DRIVERSIDE TIRE (BF GOODRICH RADIAL LONG TRAIL T/A) ON AN ISUZU RODEO RAPIDLY SEPARATED WHILE TRAVELING ON THE HIGHWAY. AS A RESULT, THE VEHICLE ROLLED OVER 1-1/4 TIMES. ROOF OF THE VEHICLE CAVED IN AS WELL AS THE WINDSHIELD CAUSING HEAD INJURIES TO ONE OCCUPANT OF 5 IN THE VEHICLE. ALL 5 OCCUPANTS SUSTAINED INJURIES AND 2 REQUIRED HOSPITALIZED. *TR

NHTSA ID
10230938
Incident
Mar 22, 2008

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

IB13-R-001G

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.

WB13-X-001B

EQUIPMENT

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form

WB13-X-001A

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.

0211S007

SEAT BELTS

TAKATA SEAT BELT SAFETY RECALL CAMPAIGN 02V281. *TT

SB9914S007

SEATS

INFORMATION REGARDING THE AVAILABILITY OF THE CHILD SEAT TETHER ANCHOR KIT. *TT

SB9505L002

POWER TRAIN:CLUTCH ASSEMBLY

UNKNOWN

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Isuzu Rodeo by model year
YearComplaintsRecallsInvestigationsIssue Index
2008100—
2004392148.3
2003163153.3
20021012359.0
20013894358.1
20002744258.6
19995505363.9
19984786566.6
19971181046.8
1996971047.9
19951762157.2
1994Viewing825258.4
1993342051.2
1992801155.3
1991422164.6
1990001—
1989000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.