2021 Jeep Grand Cherokee Fuel system Problems

Electronic Throttle Control warning light comes on upon starting vehicle while extended crank occurs. When starting car, the push to start feature will not turn over and continuously cranks multiple times. Issue is intermittent- never know when it will happen which makes it difficult to replicate at service center. Took car into 2 mechanics on separate occasions and finally to the Jeep dealership for service. Because issue couldn’t be duplicated- nothing was done. However, recently while driving, same extended crank pattern noise and unstable/rough propulsion occurred while driving on the highway. Same Electronic throttle control warning light came on along with the check engine light. Also cruise control and the auto On Off feature became disabled. I scheduled service with my mechanic as soon as possible and they found the stored code was related to Technical Service Bulletin 2014-004-25 REV.B. This bulletin lists the symptoms I described yet the dealership did not perform the fuel pressure Test and Replace Fuel Pressure Regulator. I called the dealership to schedule warranty service for this TBS and they gave me difficulty acknowledging the TSB was issued for my make/model/year and scheduling a service appt. I spent the last few hours reading all of the complaints on NHTSA for 2021 Jeep Grand Cherokee and it is alarming how many of the complaint are for this specific issue. It is dangerous for anyone on the road to be driving in a vehicle you can’t rely on to propel you forward when you press the gas or stall due to faulty fuel pressure regulator amid traffic. An investigation should be done. Furthermore, in reviewing other recalls, I found this is a recurrent issue for Jeep. It appears they’ve been various safety recalls issued for this in the past for vehicles made from 2011-2020. How they haven’t addressed it in new models is appalling. For owners of the vehicle, it’s difficult to have any leverage with dealership since it is not easy to replicate on demand.

NHTSA ID

11754729

Incident

Oct 30, 2025

While driving, the vehicle experienced a sudden, unexpected engine stall and complete loss of propulsion due to a premature failure of the in-tank electric fuel pump. This failure occurred at only 37,000 miles, which is well below the expected lifespan of a major fuel system component. A sudden loss of engine power while operating at speed poses an immediate safety hazard, increasing the risk of a rear-end collision or leaving the vehicle stranded in active traffic. The fuel pump had to be replaced immediately to restore the vehicle to a safe operating condition. The original failed component was replaced by an independent repair facility, and all itemized repair orders and proof-of-payment receipts have been retained. I am logging this complaint to urge NHTSA to investigate a potential manufacturing defect in 2021 Jeep Grand Cherokee fuel delivery systems.

NHTSA ID

11750460

Incident

Jun 11, 2026

I was driving my car and the car shut off at 30 mph. It completely stopped and the steering wheel locked up. Started flashing start/stop and told me to put it in park. Glad no one got hurt and hope it doesn’t do it again.

NHTSA ID

11725887

Incident

Mar 20, 2026

Fuel pump loosing prime it cracks either in housing or hose internal to the tank and it causes it to loose prime. Long Crank Times/No Start And stall and rough idling at stoplights and upon acceleration. Issue was confirmed and reproduced by independent service center.

NHTSA ID

11725092

Incident

Feb 26, 2026

Hesitates to start

NHTSA ID

11721089

Incident

Oct 24, 2025

The 2021 Jeep grand cherokee I owned had problem when I started the vehicle It would not start and had to do it again and again to restart which damaged the starter and batteries I suffered a big monetary loss when I traded this car as Chrysler and Stellantis refused to acknowledge the recall of the fuel pump relay

NHTSA ID

11710214

Incident

Sep 4, 2025

THE ISSUE IS IN STARTING THE VEHICLE. WHEN I PUSH THE START BUTTON, THE VEHICLE STARTS, BUT THE ENGINE CONTINUES TO TURN WITHOUT STOPPING AND TURNING OVER. I THEN PUSH THE START BUTTON AGAIN TO TURN OFF THE ENGINE AND MAKE ANOTHER ATTEMPT, AND THEN IT WILL START NORMALLY. THIS HAS HAPPENED SEVERAL TIMES IN THE LAST FEW WEEKS. ALSO, SOMETIMES WHEN YOU PUSH THE START BUTTON, NOTHING HAPPENS, AND THE VEHICLE WILL NOT START. IT TAKES A SECOND ATTEMPT TO START NORMALLY

NHTSA ID

11699713

Incident

Oct 23, 2025

Engine died twice on busy freeway and needed to be towed to a shop. Shop verified the fuel pump was working. There is most likely a problem with the fuel pump relay.

NHTSA ID

11698833

Incident

Oct 1, 2025

The vehicle does not start each time you attempt to start it. Randomly, with no specific conditions to replicate, you will start the vehicle and the starter will engage, but the vehicle will not start. The push button start will time out, you attempt to start the vehicle again, and it starts. This, from my research, is a known issue with 2016-2020ish Jeeps, with a fault in the Fuel Pump Relay, with the easiest fix to remote start your vehicle each and ever time you start it. This happens several times per week. I contacted the dealership we purchased the vehicle from, and our local Jeep service department. They were familiar with this issue, acknowledged its a pretty big problem, but because it is not a recall for Jeeps, there is nothing they can do except for me to bring it in and pay for all of the fixes for a known production issue.

NHTSA ID

11697289

Incident

Nov 3, 2025

Known common problem with 2021 Jeep Grand Cherokees, fuel pump issues. Vehicle fails to start when push button is pressed. After several attempts vehicle will start. These issue happens hundreds of times per year. Vehicle will stall while driving intermittently. Manufacture and NHTSA is well aware if this issue, as it has been documented hundreds and likley thousands of times by dealer ships across the US.

NHTSA ID

11695933

Incident

Dec 1, 2023

First gear knocks hard in to gear,this happ en on uphills,cluster and the speed meter and the in infotainment screen has go pitch black,loss of power under acceleration and collapsing all the system of the car.

NHTSA ID

11695665

Incident

Oct 9, 2025

There is a delay in my car starting when I push the start button. When doing some research online to see what the possible issue might be I found that other cars with the same make/model/year had this issue and was apart of a recall for the fuel pump relay.

NHTSA ID

11692129

Incident

Oct 7, 2025

My 2021 Jeep Grand Cherokee will not start / turn over and if it did the car will shut off. This has been happening for the past week or so. I took it to my local Jeep dealership today and they are stating that both the fuel pump and the water pump need to be replaced. They also stated that the fuel pump recall does not apply to my vin. In addition to my fuel pump needing to be replaced, my water pump has failed too. It is severely leaking water. My Jeep is only 4 years old with barely 70,000 mi and is experiencing severe safety issues. I cannot drive it as it could shut down unexpectedly while I am driving thereby posing a major safety risk.

NHTSA ID

11690530

Incident

Sep 23, 2025

Electric start is cranking but engine takes up to 10 seconds or longer to turn over. This happens from cold start and even the stop start when in drive at a stop sign or stop light. It is either an issue with fuel injection/fuel pump or something else as it is not a battery issue just replaced them to be sure or a starter issue.

NHTSA ID

11686325

Incident

Jul 1, 2023

Jeep's engine turned off while driving, was able to coast and use the brakes to come to a full stop. The engine turned off while driving in a tunnel in the mountains; it was very unsafe. There was no shoulder to pull off to, no extra space to walk around the car, with only 1 other lane available for all the backed-up traffic behind me; CDOT had to tow me out of the tunnel, where I then had to wait on the side of the highway for AAA. There were no warning signs, lights or messages prior to the failure. Had to be towed to the Jeep dealership, where the fuel pump was replaced. There have been recalls on this part for other Jeeps, but my VIN did not show that this was a recall for this specific yr /model.

NHTSA ID

11684306

Incident

Jul 25, 2025

When starting car, the push to start feature will not turn over and continuously cranks multiple times. The entire fuse box was replaced because the dealer told me that was the issue. The car is a 2021 Jeep Grand Cherokee Laredo. Numerous people online said they were forced to replace the fuel pump? Although Faulkner Buick in Trevose told me that there’s nothing wrong with my fuel pump. I can’t keep getting charged for repairs that are not necessary. Could this be a faulty part? that so many people have the same issue? Could you please investigate this as I just bought the car a month ago And it’s been at the dealer three times already. Thank you.

NHTSA ID

11682761

Incident

Aug 15, 2025

The fuel pump and then in turn, the auxiliary pump failed. The car would keep turning over a lot before it started. The engine would stop in the middle of travel. This put us in risk as we travelled down the freeway. We took it to the dealership for inspection, and they found a defective fuel pump. There were no warning lights, messages when this occurred.

NHTSA ID

11681527

Incident

Aug 11, 2025

On May 17, 2025, my vehicle suddenly shut down in heavy traffic on a major NYC highway (no shoulder), creating a hazardous situation. There was no warning or alert before the engine shut off completely. I was unable to restart the car, and the gear shifter was locked. The brake pedal also became unresponsive temporarily. After some time, the brake unlocked, but the ignition remained inactive and the vehicle was immobilized. The car had to be removed by emergency tow and later diagnosed by a Jeep dealer. The root cause was determined to be failure of the fuel pump(s). Additionally, a blown fuse in the Power Distribution Center (PDC) was discovered. The dealer replaced both fuel pumps under warranty. Jeep has refused to acknowledge this as a safety issue or reimburse emergency expenses despite full documentation. This is a serious safety issue, especially since: There was no prior warning Vehicle failure occurred in heavy traffic Driver was stranded in a live lane The issue appears related to core electrical/fuel systems I have identified over 20 similar complaints from Jeep owners of their cars also shutting down in traffic, often without warning. These have been shared on owner forums and consumer boards. I believe this indicates there is a wider pattern that may indicate a safety defect.

NHTSA ID

11669596

Incident

May 17, 2025

The car keeps dying while I’m driving and saying “shift to park” and then slamming on the brakes and dying. The card is 4 years old with 44k miles. I had to sit on the side of the road in 93 degree heat in Florida while pregnant and waiting on a tow truck. How has someone not died because of this? I’ve seen SEVERAL posts of people saying the same thing happened to theirs. It’s SO unsafe.

NHTSA ID

11669356

Incident

Jun 22, 2025

I bought the Jeep Grand Cherokee Limited in 2021. Since I bought it I have had one problem after another with this SUV. This is the list of repairs on my car since 2021... and Jeep has done nothing to compensate for my troubles. I feel like I got a lemon of a car and I would never purchase another jeep again. We have maintained the car and have records of all oil changes and tire rotation and all necessary maintance that should have been done on the car. July 31 2024... evaporator core fixed car leaking all over AC fixed... jeep couldn't find problem then finally did. Oct. 4 2024.. new radiator... car leaking all over... once again hard time finding problem March 26, 2024... two new batteries installed car hard time starting... was not problem cause March 27, 2024.. same problem brought back and now I need a fuel pump ( car had burning smell and I was driving it because they could not diagnose the problem )and because they made we wait a week to get it checked out they said there could be more damage to car not sure. Fuel pump should last 100,000 miles.. my car has 68, 000.00 In the three and half years with this car I have had one safety problem after another and I am upset I travel to help my elderly parents on Long Island and each time I am afraid something is going to go wrong with this car. I am so very upset on how the performance of a three year old car is running. I feel people need to know that Jeep is not a reliable brand of car. I am so upset and feel that my car is not reliable and safe for driving long distances and short distances. Thank you for listening to my story. I appreciate you letting others now how my experience with Jeep has been. Thank you

NHTSA ID

11651448

Incident

Mar 26, 2025

Vehicle quit running while driving was going about 5 miles an hour just shut down tried to restart cranks but will not start no safety issues We had to call a tow truck and have vehicle towed to dealer has about 24,000 miles on it. It sounds like a fuel pump issue. Valley motor city Jeep in Cuyahoga Falls, Ohio, 330-937-9481 where the vehicle is being repaired called me Friday 9/6/24 and said they ordered a fuel pump I talked to Christy, the service writer she said parts will be in next week. does Chrysler have any recalls on this?

NHTSA ID

11613637

Incident

Sep 5, 2024

I have a 2021 Jeep Grand Cherokee that has 8506 miles on it, I am the original owner. 7 months ago I was in the neighborhood, and it started hesitating, and the engine stopped, no warning lights nothing, after waiting I started it back up and drove home, and it has been fine until last Saturday. Saturday we were at a busy red light in the turn lane, light turned green I turned, car shut off no warning lights nothing. I was stuck in the middle of traffic and could not move the car. The jeep was towed to the shop, premature fuel pump failure. My problem with this is it could have gotten me killed or my children. Two weeks outside the warranty and I am out an extra 2000.00, because unless your car is dead, or it is a recall the jeep dealership always sends the car back saying they can not find anything wrong, extremely dangerous situation to be put in, I am just grateful I was not on the highway when it happened the second time.

NHTSA ID

11608399

Incident

Aug 10, 2024

The contact owns a 2021 Jeep Grand Cherokee. The contact stated that after refueling the vehicle, the vehicle failed to restart immediately. The vehicle was able to restart after several attempts. The vehicle was taken to the dealer, where it was determined that the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

NHTSA ID

11602275

Incident

Jul 12, 2024

Mileage

30,000 mi

Driving down an interstate at 70 mph, suddenly the car hesitated a couple of times and the engine stopped. I coasted to the side of the road. No warning lights. I am now sitting on the side of an interstate with 18 wheelers flying by and I am miles away from a town. Two and a half hours later we were towed to a jeep dealer. They performed a diagnostic with results being failure of fuel pump and wiring (intelligent power ipac). Dealership made repairs. I feel our safety was at risk because there was 1. No warning/ 2. Possibility of being unable to get off the road in this situation/ 3. Sitting on a busy interstate, waiting for help. In checking online I found more people complaining about the same thing happening to them, so I feel this is not an isolated incident.

NHTSA ID

11595829

Incident

Jun 17, 2024

I was driving approximately 55 MPH on the highway when my vehicle suddenly lost all acceleration. I received an alert on the dash and a chime - the alert stated "Shift to P to Start" - with no other warnings and no CEL or Check Engine light. Pressing the gas, even to the floor, did nothing. I was forced to brake the car to a stop on the shoulder, shut off the engine, and restart the vehicle. Afterwards, I experienced some slight hesitation which resolved, and then was able to drive the rest of the trip without issues. Having the vehicle lose all power on the highway without warning is a serious safety issue.

NHTSA ID

11591529

Incident

May 29, 2024