Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 305 NHTSA owner-reported complaints for the 2003 Kia Sorento. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 305 · page 1 of 13
For some reason, KIA has halted production of the Air Bag Clock Spring mechanism for 2003 Kia Sorento's EX with cruise control. In my opinion, this was a vital component of the Air Bag safety system for any vehicle. So why the halt in the production of this vital part. Kia part #93490-3E160. Maybe the NHTSA can get an answer to this. I'm sure I not the only one driving a 2003 with the Air Bag light illuminated.
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE VEHICLE STALLED AND LOST MOTIVE POWER WHILE DRIVING THE CONTACT WAS CONCERNED FOR HIS SAFETY WHEN THE VEHICLE STALL THE CONTACT WAS CONCERNED THAT IT WAS RELATED TO THE FUEL SYSTEM WHILE DRIVING AT APPROXIMATELY 60 MPH, THE SPUTTERED AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS WHERE THE FUEL PUMP WAS REPLACED, A TUNE UP WAS PERFORMED, THE CAMSHAFT SENSOR, AND TIMING BELT WAS ALSO REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED WAS CONCERNED THAT THE FUEL SYSTEM WAS THE CAUSE OF THE FAILURE. LAKESHORE KIA, 330 E HOWZE BEACH RD #2, SLIDELL, LA 70461, (888) 220-8645, WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED NOR INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
TL* THE CONTACT OWNED A 2003 KIA SORENTO. WHILE DRIVING AT 60 MPH, THE CONTACT STATED THAT SMOKE CAME FROM OUT OF THE VENTS. THE CONTACT PULLED OVER ON THE SHOULDER AND EXITED THE VEHICLE. THERE WERE SPARKS COMING FROM THE ENGINE AND THE VEHICLE CAUGHT ON FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOTALED AND TOWED AWAY. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. TH VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2003 KIA SORRENTO. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO MENTIONED THAT A 'SNOW' WARNING LIGHT ILLUMINATED AS WELL. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 202,699.
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE RPMS WOULD NOT GO OVER 4,000 AND SMOKE APPEARED FROM THE ENGINE. THE CONTACT STATED THAT THE SPEED WOULD NOT EXCEED 40 MPH AND THE ENGINE WAS DRAINING THE OIL. THE VEHICLE WAS TAKEN TO PEAK KIA (5077 S WADSWORTH BLVD, LITTLETON, CO 80123, (303) 904-7800) WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED AN OIL CHANGE. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO CALL THE DEALER. THE FAILURE MILEAGE WAS 56,300. *DT
WHEN PUMPING GAS THERE IS A SUDDEN SPEWING OF GASOLINE OUT OF THE TANK AND ALL OVER ME. I MANAGED SEVERAL TIMES TO GET A FEW GALLONS IN BY PUMPING SLOWLY BUT THE NEXT DAY THE GAS GAGE READS EMPTY AND HAS ACTUALLY RUN OUT OF GAS SEVERAL TIMES! SO NOT ONLY AM I HAVING A PROBLEM PUTTING GAS IN, IT IS IMMEDIATELY DRAINING OR LEAKING OUT!
AFTER PURCHASING CAR FROM PRIVATE SELLER I DISCOVERED THAT WHEN TRYING TO PUMP GAS, MY FUEL SPRAYS BACK OUT ALL OVER MYSELF, MY VEHICLE, AND THE GROUND. HAVE EVEN HAD IT SPRAY INTO MY EYES. DID RESEARCH AND SAW THAT THIS IS A VERY COMMON OCCURRENCE FOR THIS YEAR/MAKE/MODEL. I BELIEVE ITS A FIRE AND SAFETY HAZARD AND SHOULD HAVE BEEN RECALLED YEARS AGO!
TAKATA RECALL. MY CAR WILL NOT PASS INSPECTION DUE TO A PROBLEM WITH ONE OF THE AIRBAGS. THE CAR HASN'T BEEN IN AN ACCIDENT BUT THE AIRBAG LIGHT IS ON AND I'M TOLD IT WILL NOT INFLATE. I WAS TOLD TO CHECK FOR RECALLS.
TAKATA RECALL THE CRANKSHAFT PULLEY BOLT KEEPS COMING LOSE AND THIS CAUSES THE STEERING WHEEL TO BECOME STIFF. THIS HAPPENED IN THE MIDDLE OF TRAFFIC AND HAD TO GET IT TOWED TO A FRIENDS HOUSE. CURRENTLY THE CAR IS NOT DRIVEABLE FOR OVER TWO WEEKS.
MY 2003 KIA SORENTO DRIVES FOR 15 MINUTES AND STALLS OUT. I WAIT 5 MIN AND IT'LL START AND DRIVE FOR A BLOCK OR 2AND CONTINUES TO THAT UNTIL I GET IT TOWED HOME
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 65 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER AND CRANKSHAFT BOLT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVERAL TIMES. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
ENGINE CRANK SHAFT HAS BROKEN FOUR TIME , AIR COMPRESSER TWO TIME
RUST AND CORROSION REAR AXLE BRACKET AND TRAILING ARM MOUNT. REAR AXLE BRACKET BROKE AT HIGHWAY SPEEDS.
THE 2003 KIA SORENTO HAS A PROBLEM WITH EXTENSIVE FRAME RUSTING, TO THE POINT WHERE SOME OWNERS HAVE HAD THE SUSPENSION DETACH FROM THE FRAME. ONE OWNER IN PARTICULAR HAS HAD ISSUES WITH THE GAS TANK NEEDING TO BE REPLACED, AND KIA MOTORS REFUSES TO DO ANYTHING ABOUT THE PROBLEM. THEY BUILT THE CAR, SOLD IT TO PEOPLE, AND WHEN CONSUMERS HAVE COMPLAINTS ABOUT THEIR VEHICLE, THEY (KIA) SAYS THAT THEY'RE NOT RESPONSIBLE. YOU NEED TO EXAMINE THIS, BECAUSE PEOPLE COULD GET KILLED BY OPERATING AN UNSAFE VEHICLE. DO SOMETHING ABOUT THIS NOW, BEFORE IT BECOMES THE NEXT PINTO. MAKE KIA FIX THE [XXX] VEHICLES NOW!!! PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
VEHICLE BROKE DOWN IN TRAFFIC. FROZE UP,STALLED. LOSS OF STEERING. HAD IT TOWED TO SHOP & WAS TOLD THE CRANK SHAFT SENSOR & RELATED PARTS TO THE CRANK SHAFT HAD TO BE REPLACED. COST FOR TOWING & REPAIRS WERE OVER $700.
WHILE FUELING UP THE SORENTO, THE FUEL SPIT OUT EVERY TIME EVEN WHILE FUELING AT SLOW SPEEDS. VERY FRUSTRATING , AND DANGEROUS, ESPECIALLY WHEN THE FUEL GETS ON MY SKIN & CLOTHES, THE VEHICLE, AND AT TIMES LEAVES A HUGE PUDDLE ON THE GROUND WHICH COULD BE A FIRE HAZARD. THE DEALERSHIP WAS CONTACTED AND WILL NOT HELP ME EVEN THOUGH THERE WAS A RECALL ISSUED FOR THE FUEL FILTER, WHICH I MENTIONED.
WHEN I PUMP GAS INTO MY CAR, THE FUEL SPITS BACK OUT AT ME. I HAVE TO PUMP REAL SLOW FOR THIS NOT TO HAPPEN. THIS IS DANGEROUS, GAS GETS ON MY HANDS AND CAR,I HAVE TO CARRY SOAP AND WATER TO WASH THIS OFF OF MY CAR. I CALLED ABOUT THIS AND WAS TOLD BECAUSE MY CAR VIN # WAS NOT ON THE THEIR LIST THERE WAS NOTHING THEY COULD DO FOR ME
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE DECELERATED AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. IN ADDITION, WHEN THE CONTACT INSERTED FUEL IN THE VEHICLE, FUEL SPEWED OUT THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
TAKATA RECALL...REAR SUSPENSION ALWAYS ROTS OUT. THE SUB FRAME IS BAD.
WHILE UNDER MOTION ON HIGHWAY AT 65+ MPH, LOST POWER STEERING DUE TO CRANK SHAFT BOLT AND PULLEY FAILURE, RESULTING IN COMPLETE LOSS OF ACCESSORY FUNCTIONS.
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHEN REFUELING THE VEHICLE, FUEL EJECTED OUT OF THE REFUELING HOLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 101,300.
AIR BAGS COIL SPRING HAS BEEN REPLACED 4 TIMES. THE AIR BAG WARNING LIGHT IS ALWAYS ON AND KIA REFUSES TO FIX THE PROBLEM. I DON'T KNOW IF THE AIR BAGS WILL DEPLOY IN CASE OF A ACCIDENT. THIS IS BEEN A PROBLEM FROM THE DAY I PURCHASE THE CAR. I DON'T KNOW THE MAKER OF THE AIR BAG SISTEM.
EVERY TIME I HAVE TO FILL THE GAS TANK ON MY KIA SORENTO 2003 IT SHOOTS BACK THE GASOLINE LIKE A PROYECTILE. IT TAKES AN ETERNITY TO FILL THE GAS TANK IF YOU DON'T WANT TO HAVE GAS ALL OVER YOU. I HAVE EVEN BEING KICKED OUT OF SOME SERVICE STATIONS BECAUSE SPILING SO MUCH GAS IS A HAZARD. IS THERE ANY SAFETY RECALL FOR THIS PROBLEM? I HAVE NOT HEARD A WORD FROM KIA.
THE DRIVER DOOR CANNOT BE OPENED FROM INSIDE OR OUTSIDE. I UNDERSTAND THIS IS A COMMON PROBLEM WITH KIA SORENTOS.
WHILE DRIVING I HEARD A CLUNK AND A THE CAR BEGAN ROLLING SIDE TO SIDE. I LIMPED TO A MECHANIC AND WAS TOLD THAT THE FRAME WHERE THE SUSPENSION AND ALL PARTS CONNECT WAS RUSTED OUT. FRAME REPAIR SAID THIS CAN NOT BE FIXED AS THE FRAME IS RUSTED OUT. WHERE THE STABILIZER AND SUSPENSION CONNECTS. TEH CAR ONLY HAS 149,OOO MILES AND IS IN NORTH CAROLINA. I HAVE READ OTHER REPORTS OF A RUSTED OUT SUPPORT FRAME ON THIS SITE. WILL THE MANUFACTURER REPLACE THIS FRAME.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .