2013 Kia Soul Engine Problems

The contact owns a 2013 Kia Soul. The contact stated that the check engine warning light was illuminated. The contact stated that there was a misfire in the engine. The contact associated the failure with NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was opened. The failure mileage was approximately 151,000.

NHTSA ID

11750744

Incident

Jul 9, 2026

Mileage

151,000 mi

Vehicle is experiencing rod-knock and engine performance issues along with a P0420 code for the catalytic converter. After using a diagnostic tool to retrieve code, a recall was present for the existing code, that explained the exact symptoms my car is experiencing. I have had the car since 2021 and have not received any notification regarding a recall for the engine; it was only after I ran a diagnostic check where I found out there was a past recall for the engine and catalytic converter (SC176). I called KIA customer service, and they explained that the vehicle did not receive the recall, however they could still not uphold the recall work because the vehicle is outside the warranty for the recall (Vehicle Odometer reads 150088), approximately 90 miles over warranty. Only indicator light that illuminated was the check engine light. The recall says the vehicle could overheat and is at risk of a fire hazard. I was not notified of any engine recall for the vehicle since I have owned the vehicle, and I am worried that my daily commuter will present a fire risk.

NHTSA ID

11745733

Incident

Jun 1, 2026

My vehicle engine failed on the interstate after getting KDS update on my vehicle and it is covered Kia Corporate and the franchise dealer are actively claiming they 'cannot share or access' the vehicle's electronic diagnostic data, despite the mandatory use of the connected Kia KDS tool, in an apparent attempt to obscure a documented safety defect and deny a class-action lifetime engine warranty. They have kept my car almost 2 months, won't give me a rental , only information is again them lying to me saying it's a blown head gasket, when I know in fact it will still run, but blow white smoke out of the tailpipe and run in limp mode but still will start and mine won't do anything at all.

NHTSA ID

11745621

Incident

May 5, 2026

Engine failure while driving . A bolt broke off the Rod end cap and was freely moving in the engine causing a rod knock sound and seized the engine. Almost causing an accident on the heavily populated road. Metal debris is present in oil pan . Piston is damaged as well.

NHTSA ID

11741146

Incident

May 15, 2026

The contact owns a 2013 Kia Soul. The contact stated that while driving at 50 MPH, the check engine light began to flash as the vehicle entered limp mode. The vehicle was taken to an independent mechanic where they discovered that oil had leaked onto the engine which caused her to lose over a quart of oil. The vehicle was then taken to a dealer where they diagnosed the vehicle with engine failure. The contact was informed that the vehicle would not be covered under warranty and was given an estimate for the repair. The manufacturer was also notified of the failure and the contact was informed that the vehicle was previously serviced under NHTSA Campaign Number: 19V120000(Engine, Engine and Cooling) and that they could not offer any additional assistance. The vehicle was not repaired. The failure mileage was approximately 175,000.

NHTSA ID

11740787

Incident

May 27, 2026

Mileage

175,000 mi

Problem. Engine control unit, ECU allowed catalytic converter overheat. Engine knocking and stalling. Engine monitor light came on while driving the car when it began to knock and stall while driving it. Can cause piston to break and.puncture the engine block, leaking oil into the hot exhaust and start a fire

NHTSA ID

11733708

Incident

Apr 16, 2026

The contact owns a 2013 Kia Soul. The contact stated that the vehicle spontaneously caught fire while parked unattended at 3 am. All the warning lights were illuminated prior to the failure, and the vehicle was undrivable. The contact had received the recall notification letter for NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). There were no reported injuries, police report, or crash. The fire department was called and extinguished the fire. The vehicle was towed to the scrap yard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 265,000.

NHTSA ID

11733591

Incident

Apr 8, 2026

Mileage

265,000 mi

I was on vacation driving the vehicle when the engine caught fire..There was kids in the car there was nothing wrong with the vehicle all of a sudden it just went boom and caught fire We were slowing down to get off the exit. I have no idea what all was effected I don't know much about cars to know what did or did not catch fire..

NHTSA ID

11730782

Incident

Apr 11, 2026

Rod went through the the back of the engine causing smoke and vehicle locked up.

NHTSA ID

11730016

Incident

Apr 6, 2026

On Feb. 11, 2026, while driving, the vehicle displayed a flashing check engine light and entered limp mode with major loss of power. A code reader recorded P1326. The vehicle was taken to an authorized Kia dealership for diagnosis and repair. After the dealership returned the vehicle to me, the same problem happened again within about 30 miles. The last repair order listed 142,352 miles, and the vehicle re-entered limp mode by 142,382 miles. I captured video of the flashing check engine light and a code-reader screenshot showing P1326 as the last trouble code. The malfunction appears related to the engine/engine management system and the vehicle is available for inspection. The safety risk is sudden reduced power and limp-mode operation while driving, which can make it difficult to maintain normal traffic speed or safely continue in traffic. This creates a safety concern if the event happens in traffic, during a turn, or while crossing an intersection. The problem has been reproduced more than once. A Kia dealership previously inspected the vehicle and returned it to me, but the problem recurred almost immediately after pickup. Kia corporate was notified in writing. The warning symptom was a flashing check engine light with limp mode. I am not continuing to drive the vehicle in this condition.

NHTSA ID

11725880

Incident

Mar 19, 2026

I bought a Kia Soul at 130k miles and by 140k or so it was dead. the engine started knocking and will no longer turn over. I did regular oil changes and usual maintenance. Within 2 days after knocking the engine refused to turn over. I was driving when it stopped working so at any time someone could have rear ended me and caused a traffic jam. The car was toed to a mechanic who said it was done for and if they needed the specifics they would have to tear down the engine. not going to pay 600 to find out my engine is gone when i already know the engine is gone. no warnings light or messages prior to failure. My vehicle experienced catastrophic engine failure consistent with well-documented defects in Kia GDI engines. Kia has acknowledged these defects through recalls, settlements, and extended warranties covering later model years. However, Kia has refused repair or good-faith assistance for my vehicle solely because my VIN is excluded, despite the engine design being materially identical to covered models. I contacted Kia Corporate directly, provided my VIN, and was assigned a case number. Kia informed me that: - My VIN is not eligible for recall or settlement relief - No good-faith repair would be offered - Denial was based on model year/VIN classification, not engine design or failure mode - I am not the original owner, which Kia cited as an additional reason for denial Why This Is Concerning: - The 2013 Kia Soul was equipped with the same GDI engine architecture later acknowledged as defective - Consumers are being denied relief based on administrative cutoffs rather than engineering reality - Kia continues to avoid responsibility for early-year vehicles that suffer identical failures - The cost of engine replacement far exceeds the vehicle’s value, leaving consumers with unrecoverable losses I am requesting - Review Kia’s handling of known GDI engine defects - Assess whether Kia’s exclusion of certain VINs constitutes an unfair

NHTSA ID

11715009

Incident

Aug 22, 2025

Put gas in it and out the blue would go pass 30 rpm we never had any issues with it I work on cars for a living I have spend over 3000 in new parts now I got it tow to Firestone they telling me it’s something wrong with my engine cylinder two and four not getting any power they told me it was bad bargin or piston I don’t know how it happens because we kept the car up to maintenance

NHTSA ID

11709637

Incident

Dec 8, 2025

Engine knocking

NHTSA ID

11709220

Incident

Dec 27, 2025

I was driving home from work and got about 5 miles and I see smoke and pulled over. I had it towed to repair shop and they said they found a hole in my engine block and a broken connecting rod. They told me I should take it to KIA as I only have 132,179 miles and that repair should be under warranty. I took it to Kia and they denied the repair due to a class action lawsuit and I did not qualify for that as a recall was missed KSDS update. I bought the car used in late 2019 and the last ower has since died. I was never notified of these updates.

NHTSA ID

11697728

Incident

Oct 28, 2025

The contact owns a 2013 Kia Soul. The contact stated that while driving at 45 MPH, the vehicle stalled and experienced a loss of automotive power, with the check engine warning light illuminated. The contact pulled over to the side of the road to restart the vehicle. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was advised that the catalytic converter and the engine were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 136,000.

NHTSA ID

11690775

Incident

Sep 1, 2025

Mileage

136,000 mi

RECALL FOR CATALIC CONVERTER UNDER MANUFACTOR WARRANTY , THEY CONTINUE NOT TO HONOR THE RECALL ON MY VECHILE AND THE RECALL WAS ON THE CATALIC CONVERTER

NHTSA ID

11688000

Incident

Sep 22, 2024

The contact owned a 2013 Kia Soul. The contact received notifications of NHTSA Campaign Numbers: 19V120000 (Engine, Engine and Engine Cooling) and NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while her son was driving at 60 MPH, an abnormal sound was heard coming from underneath the vehicle. The contact's son was able to pull over to the side of the road. No warning lights were illuminated. The contact stated her son exited the vehicle and noticed flames were emitting from underneath the vehicle. A passerby pulled over and helped the contact's son move the vehicle. The vehicle extinguished itself. No injuries were reported. The air bags did not deploy. The contact stated that her son called her, and she and the contact's brother went to the site of the accident. The contact's brother checked underneath the vehicle and picked off the pieces that were on the ground. The contact's brother noticed that a rod had detached and gone through the motor, which created a hole in the motor. The vehicle was towed to the dealer. The dealer confirmed that the bearing rod detached and damaged the engine. The dealer contacted the manufacturer and tried to order a new engine. However, KIA declined and advised the dealer not to repair the vehicle. The vehicle was towed to the residence. The vehicle remained at the residence unrepaired. Two months later, the contact sold the vehicle. The manufacturer was notified of the failure and offered no assistance. The insurance company was not notified. The failure mileage was unknown.

NHTSA ID

11680410

Incident

Aug 11, 2024

On [XXX] Jim Ellis Kia of Kennesaw performed Recall SC284 on my 2013 Kia Soul (VIN: [XXX] ), replacing the HECU fuse. The next day, [XXX], the vehicle lost acceleration while driving, produced a muffled engine sound, and became barely able to move forward, creating an unsafe driving condition. At no point did the check engine light illuminate, even though the vehicle was experiencing severe drivability issues. Prior to the recall, Kia’s own diagnostic (July 19, 2025) showed no catalytic converter or battery issues. An independent AAA diagnostic performed after the failure (July 21, 2025) ruled out pre-existing converter damage and linked the problem to the recall work. Despite this, the dealership denied responsibility and issued an unsupported estimate of $4,951.41 for catalytic converter replacement. The absence of a check engine light raises concerns that the recall work may have compromised the vehicle’s OBD-II diagnostic system, preventing detection of a safety defect. Furthermore, the evidence suggests that damage occurred to the catalytic converter while the vehicle was in Kia’s possession or as a direct result of the faulty installation of the recall fuse. This incident involves a safety risk, improper recall repair, and potential violation of federal recall law. I am requesting that NHTSA investigate the adequacy of Recall SC284 installation procedures and Kia’s handling of this case. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11678431

Incident

Jul 19, 2025

The contact owns a 2013 Kia Soul. The contact stated while driving at various speeds, there was an abnormal knocking sound coming from under the hood before the vehicle stalled. The vehicle was previously taken to a local independent mechanic, and it was determined that the catalytic converter needed to be replaced. The contact received notification of NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The vehicle was taken to a local dealer, where it was diagnosed and determined that the fuel injector needed to be replaced due to a misfire in cylinder #2. The vehicle was repaired out of pocket. The vehicle was also taken to a local AutoZone, where it was determined that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000.

NHTSA ID

11675003

Incident

Jan 15, 2024

Mileage

180,000 mi

First, my engine and oil light went on. Second, there began a loud prominent engine knock. I had it serviced for an oil change and after the oil change, the knock persisted and my car began to stall. Third, I took it to Midas for a diagnostic and they told me my engine is about to fail, that this is typical of Kia Soul engines, they said there are metal pieces of broken pistons in my engine and that my car will soon break down and to "pray" it doesn't happen on the road. I then drove my Kia Soul to secure a rental vehicle, but on the way my engine died in the middle of a busy intersection and I had just enough time to pull it to the bike path on the side of the road, passenger side still in the road. I then had it towed to a repair shop and paid for a second diagnostic, which aligned with the first diagnostic from Midas. I then received a recall letter from Kia Manufacturer that my specific vehicle had a safety recall from the NHSTA and to bring my car to the nearest Kia dealership for immediate repair, free of cost to me, upto engine replacement. I had my Kia Soul towed to Kia of New Port Richey, Florida and explained the recall letter. They have since done nothing in a week and said that I needed to have the first recall addressed to have this recall repair complete. Then, they said I needed to have my car registered to complete the repair. Then, they said I need to provide a maintenance record to complete this recall repair, and failure to do so will result in Kia refusing to complete my engine repair, in accordance with their recall letter I received. Therefore, I contacted the NHSTA.

NHTSA ID

11665948

Incident

Jun 3, 2025

The contact owns a 2013 Kia Soul. The contact received notification of NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was a knocking sound coming from the engine while driving at various speeds and while the vehicle was idling. The check engine warning light was illuminated. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the engine needed to be replaced. The dealer refused to replace the engine because the previous owner had not received an undisclosed service related to the KSDS completed. The manufacturer was made aware of the issue and confirmed that if the catalytic converter was damaged, the engine should be replaced. The manufacturer opened a case. The failure mileage was approximately 125,000. Parts distribution disconnect.

NHTSA ID

11662333

Incident

Feb 22, 2019

Mileage

125,000 mi

Problems with our 2013 Kia Soul! started [XXX] @ 78,388 miles. We took the car to Kia Country in Manteca for an oil change, when leaving the dealership white plumes of smoke where coming out of the exhaust. Took the car back to the dealership who told us not to worry about it, drive it on the freeway to burn it off. Returned to the dealership 4-7-21 @ 80,414 miles smoke is still coming out of the exhaust, Kia performed an oil consumption test, we were told to come back in a couple of months or 3,500 miles to check on the vehicle. 6-4-21 @ 81,737 miles took the car back for inspection, engine oil checked out ok, they couldn't find any issues. [XXX] @ 91,239 miles took the car to Kia Dublin, blue smoke was coming out of exhaust and car won't start. Tech performed tests they recommended to drive the car and wait for a check engine light to be active. They can't open a tech line if there is nothing wrong with the car and they can't duplicate the concern. [XXX] @ 124,770 miles took the car back to Kia Dublin, the car is shutting off at stop lights or at idle, won't go over 40 miles an hour. After being at the dealership for 4 days, spoke to Will on 4-16-25 states the engine needs to be replaced due to the connecting rods and pistons creating an engine failure, there is also an oil leak. There is a recall for the smaller 1.6L engine but not for our 2.0L engine, even though the issues are exactly the same. Will recommended calling Kia Customer Care for help. I called Kia Customer Care 4-17-25 and was given a case number. I have been dealing with both Kia Customer Care and Kia Dublin for over 5 weeks and no one wants to own up to selling us a defective engine or give us a replacement. I have called almost everyday and I am given a different story, meanwhile the car sits on the lot at the dealership. My daughter is without a car and we are struggling to get her to work, we have not been offered a loaner car, as the car has not been approved for an engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM

NHTSA ID

11662282

Incident

Jan 9, 2021

The contact owns a 2013 Kia Soul. The contact stated that while his son was driving at an undisclosed speed, the steering wheel was making an abnormal clicking sound. Additionally, while driving 65 MPH, the steering wheel tuned left and right with a loud clicking sound. The contact also stated that the vehicle was consuming an excessive amount of oil. The check engine warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the flex coupling was defective. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 100,000.

NHTSA ID

11660956

Incident

Jan 1, 2024

Mileage

100,000 mi

The contact owns a 2013 Kia Soul. The contact received notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while her daughter was driving 50 MPH, the vehicle hesitated and lost motive power. No warning light was illuminated. The contact's daughter was able to coast to the side of the road. The contact stated that there was a fuel burning odor coming from the vehicle. The vehicle was towed to an independent mechanic, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The vehicle was no longer being driven. The manufacturer was not made aware of the failure. The failure mileage was unknown. Parts distribution disconnect.

NHTSA ID

11652860

Incident

Jun 13, 2022

The contact owns a 2013 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

NHTSA ID

11645372

Incident

Feb 27, 2025

Mileage

100,000 mi