2023 Kia Telluride Owner Complaints

Kia installed voluntary safety recall on my car - SC357 ECM SW UPGRADE (VESC). I drive up and down steep mountain roads. Previous to this installation when I downshifted the transmission it would slow down the car. After the installation, going down two or more gears, the car now speeds up instead of slowing down. It shows on the gas mileage indicator that the mileage is going down instead of up. It would be expected that the gas mileage would increase instead of decrease. The accelerator is not being used when this occurs. It would appear that the car's computer system is causing fuel to be added to the engine to accelerate the car at lower speeds. This is especially dangerous going downhill when a downshift is expected to slow the car. It causes increase use of brakes which can cause the brakes to overheat. I have been able to avoid overheating the brakes but this is not a safe situation. Supporting the theory that the car is using fuel to accelerate in lower gears is the fact that my gas mileage has decreased about 1.5 to 2 miles per gallon on a tank full of gas.

NHTSA ID

11775787

Incident

Oct 22, 2026

My 2023 Kia Telluride started leaking water to the inside of the vehicle headliner and running out the 2nd row reading lights and all the way tobthe back hatch when it rained. This could cause significant electrical shortage in the lights, airbags and rear hatch or any other component the water makes contact with. It will most likely now cause mold in or on the headliner. When the vehicle was recently at the dealer for yet another set of recalls along with an extended warranty repair of the electronic thermostat, the service rep noticed water coming out of the headliner area on the driver side when driving it around to the shop. The service tech then pulled down part of the head liner on the opposite passenger side and borescoped the sunroof/panaramic drain tube on the passenger side and found that a hole was "chaffed" in the drain tube. They did not borehole any others at this time but with the service rep saying she saw water on the driver side it is believed that the drain tube on that side also has a hole. This is a manufacturer defect.

NHTSA ID

11774615

Incident

Oct 27, 2026

Within the last two weeks the vehicle has died approximately 8-10 times. Dealership checked the battery and found it to be in good condition. Approximately two weeks ago I walked outside and the cooling fan was on after the vehicle was parked for more than four hours. To this day the dealership can’t figure out why the cars battery is constantly dying. I believe the cars cooling fan turns on by itself and drains the battery. I am also concerned the fan turning on randomly on its own will create a fire risk due to it running for an extended period of time while the vehicle is turned off. I have video to support my claim of the fan turning on by itself.

NHTSA ID

11774604

Incident

Oct 11, 2026

My car just started making a knocking sound when I turn. Brought it in for diagnoses and was told it's the AWD Coupler, WHICH is a part of the powertrain component, but it's not covered under my 100,000 powertrain warranty, and is only covered up to 60,000 miles. This is a known issue according to Facebook, blogs, and reddit and many Kia users have had the same problem on their cars. It should be a recall and fixed if it's happening so frequently.

NHTSA ID

11773982

Incident

Oct 25, 2026

There was a low-speed collision with a deer (approximately 10-15 mph). The vehicle continued to run fine after the collision and we were able to drive it home. After the next start, the engine was shaking all over and started smoking from behind the engine. The battery was disconnected but it continued to smoke. After further inspection, we were able to find a fire and extinguished it using a fire extinguisher. We had issues with this car prior to the collision where the engine would misfire after the car would get wet, but would only produce temporary codes. This was checked out by the dealer and we were told there's nothing that they can do. A few weeks prior to the collision it happened again and the check engine light went to a confirmed/permanent code and it was related to cylinder misfires. If we would not have had a fire extinguisher or had been able to roll it away from the house, the occupants, vehicle, and house would have been in danger of the fire. The source of the ignition has been confirmed to be the ignition coils, but the root cause of this has not been determined and it has just been assumed that it is related to the collision, without an actual root cause identification.

NHTSA ID

11773624

Incident

Sep 23, 2026

The vehicle electrical system could be a fire hazard since the vehicle electrical system is incurring parasitic draw down of the battery. Believe there is a class action lawsuit filed relating to the problem. It is well known issue wit KIA Corp while the dealerships play dumb. Thank you.

NHTSA ID

11772067

Incident

Oct 18, 2026

I was involved in a rear end collision, with the SUV behind me going 65mph and my vehicle only at approx. 20mph. I was then pushed into the car, which I struck in front of me. My airbags did not deploy and though I was wearing my seat belt I was still propelled upward cutting my eye on the visor and bruising on my chin and lower lip from the steering wheel. I am concerned as to why the air bags did not deploy or the seatbelt lock. The damage was significant and my vehicle including the one that rear ended me are both totaled. Can this be looked into?

NHTSA ID

11771808

Incident

Oct 7, 2026

While driving down a highway, the front sunroof glass exploded.

NHTSA ID

11765359

Incident

Sep 18, 2026

Screen go black or blanks out. Sometime when shifting from reverse to drive the reverse screen stay on.

NHTSA ID

11762929

Incident

Aug 3, 2026

Three times over the past year minor debris or small rocks have hit the windshield causing major spidering affects that have run all across the windshield. Even when using the windshield repair kits.

NHTSA ID

11761947

Incident

Sep 3, 2026

While driving 2023 Kia Telluride driver side over head visor detached tangling in front of driver obscuring vision.

NHTSA ID

11761566

Incident

Sep 2, 2026

On XXX, at approximately 7:40 a.m., my 2023 Kia Telluride, VIN [XXX], experienced a sudden mechanical failure while traveling approximately 65+ mph southbound on [XXX]. The vehicle suddenly locked up, causing the driver to lose control, skid, and swerve toward the side of the freeway. The rear wheels appeared to be locked. Fortunately, no collision occurred and no one was injured. The vehicle was towed for inspection. A technician at Colton Tire advised that the axle appeared to be bent. The vehicle was then transported by flatbed to Allstar Kia in [XXX] for diagnosis. The Kia dealership initially suggested the vehicle must have been involved in an accident because of a minor exterior scrape on the driver's-side rear passenger door. The vehicle has not been involved in an accident or collision. The scrape occurred while slowly maneuvering into a home garage at approximately 1–2 mph and did not involve impact to the wheel, axle, suspension, drivetrain, or differential. The dealership later advised that the technician believed an alleged “accident” caused the differential to slowly leak over time, ultimately causing the axle to bend “pretty badly.” I dispute this conclusion and have requested the complete diagnostic findings and physical evidence in writing. I am reporting this incident because the vehicle suddenly experienced a serious mechanical failure and loss-of-control event at freeway speed. I am also requesting investigation of whether the intermediate shaft, right-front driveshaft, axle, differential, or related drivetrain components could have been affected by NHTSA Safety Recall 24V-214 / Kia Safety Recall SC303, or another mechanical defect. I understand the recall has not been established as the cause of this specific incident. I am asking that the actual cause of the sudden vehicle lockup be investigated because the failure occurred at approximately 65+ mph and could have resulted in a serious crash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11760459

Incident

Aug 21, 2026

The contact owns a 2023 Kia Telluride. The contact received notification of NHTSA Campaign Number: 26V430000 (Seats); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available for the recall repair. The contact was concerned that the recall posed a fire risk, rendering the vehicle unsafe to drive or park. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and denied rental vehicle assistance. The contact had not experienced a failure.

NHTSA ID

11757708

Incident

Aug 18, 2026

This is an update to my original NHTSA complaint (ID 11755209) regarding an intermittent no-start/no-crank defect on my 2023 Kia Telluride (VIN [XXX]). Since my original filing, the identical defect has recurred twice more, on XXX — once at approximately 1:01–1:30 PM EST and again at approximately 5:03–5:17 PM EST, the same day. In both incidents, the dashboard and infotainment system powered up normally, but the vehicle would not crank, consistent with all prior occurrences dating back to XXX. This brings the total documented occurrences to six between XXX and August 8, 2026, including two in a single day. In both August 8 incidents, my wife was stranded and had to be picked up because the vehicle would not start. This follows a dealer-confirmed and dealer-executed starter replacement (Kia of Cleveland, RO dated XXX, part #36100-3L160) that was performed after the dealer duplicated the fault on the vehicle and on a bench test — and a 4th recurrence on XXX, just 10 days after that repair. I have video evidence of all four August incidents (XXX, and the two on XXX showing the instrument cluster and infotainment fully powered with a no-crank condition. I am providing this update because the frequency of occurrences is escalating — two failures in a single day — despite a repair that was physically confirmed by the dealer's own testing. This strongly suggests the actual root cause (potentially an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) has not been correctly identified, and the defect continues to pose an unreasonable stranding risk to occupants. I am concurrently pursuing a vehicle replacement request with Kia America under Customer Care Case #26211382. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755922

Incident

Aug 8, 2026

CLEAR COAT PEELING OFF IN SHEETS ON A 2023 KIA TELLURIDE. IT'S A KNOWN PROBLEM AMOUNG KIA OWNERS HOWEVER KIA IS NOT ACCEPTING RESPONSIBLITY FOR A MANUFACTURER DEFECT.

NHTSA ID

11755510

Incident

Jan 1, 2026

My 2023 Kia Telluride (VIN [XXX]) has an intermittent no-start/no-crank defect that has occurred on four separate occasions between [XXX] and [XXX] (mileage range 49,850–51,180). In each occurrence, the dashboard and infotainment system power on normally, but the engine will not crank when the start button is pressed, with both key fobs. The fault clears itself with no consistent trigger, making it undetectable by standard diagnostic scans after the fact. The vehicle was taken to Kia of Cleveland (2492 South Lee Highway, Cleveland, TN 37311) three times. On the first two visits (6/18/26 and 7/1/26) the dealer could not duplicate the fault and returned the vehicle unrepaired. On the third visit (7/17/26–7/27/26), the dealer successfully duplicated the no-start condition both on the vehicle and on a bench test after removing the starter, and replaced the starter under warranty (part #36100-3L160). Despite this confirmed and completed repair, the identical no-start condition recurred on [XXX], only 10 days and approximately 250 miles later. This is a safety issue: on [XXX], my wife was attempting to leave for work with our twin 5-year-old daughters in the vehicle when it failed to start. This is the type of defect that could strand occupants in unsafe locations or conditions (heat, cold, traffic, isolated areas) with no warning and no reliable workaround. I have video evidence of the [XXX] incident showing the vehicle's instrument cluster and infotainment fully powered with a no-crank condition, timestamped and showing the odometer reading. I am filing this complaint because the defect has now defeated a dealer-confirmed and dealer-executed repair, suggesting a root cause (such as an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) that has not yet been correctly identified. I am concurrently requesting a vehicle replacement from Kia America under Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755209

Incident

May 1, 2026

A P0741 warning light comes on and off leading driver to believe the problem is intermittent when in fact it is a torque converter failed. The intermittent nature of the warning light could lead drivers to believe the problem is not a safety issue, particularly on a SUV with only 105,000 miles. However, when a converter fails it is definitely a safety issue.

NHTSA ID

11754967

Incident

Jul 10, 2026

Driver Assistance Warning (DAW) warning bells and dash sign "Driver Needs a Break" with Coffee Pot showing goes off constantly. Even with safest driving possible, on purpose safest driving, the warning and sounds goes off every few miles and few minutes. KIA dealer has kept car for 2 weeks and say they can not duplicate and I drive it (Perfectly) and it goes off. this is a 2023 Kia telluride , previous year models and later models you could turn off or turn down sensitivity of this warning. KIA eliminated the owner the opportunity to disable or turn down this warning. It is a safety hazard because it is always going off, causing the driver to take his attention from the road to the dash every few minutes with the bells and coffee pot Take A Break Warning . KIA will not do anything about it.

NHTSA ID

11750985

Incident

Jul 12, 2026

The Kia Driver Assistance Warning, Showing a Coffee Pot, and Warning "Driver needs to Take Break" goes off constantly. Sometimes starts within 5 minutes of driving and goes off constantly for every 3 minutes . Dealer says it is a KIA problem and can not do anything. This constant warning is a Safety Hazard because it takes the Drivers Attention off his Driving with the constant Bells going off. It is a 2023 Kia Telluride and previous models you could turn off this Warning but NOT in 2023 according to dealer and KIA will not repair or turn off. This is a Safety Hazard.

NHTSA ID

11749908

Incident

Jul 12, 2026

My 2023 Kia Telluride has been subject to at least 8 separate NHTSA recalls, including SC181 (seat belt/child restraint), SC194 (trailer brake light/cruise control), SC207 (airbag OCS/ODS), SC262 (side airbag wire harness), SC303 (driveshaft/rollaway risk), SC316 (power seat motor fire risk), SC347 (door trim detachment), and now SC374/NHTSA 26V430 (recurrence of the power seat motor fire risk, explicitly noted as possibly caused by an improper repair under the earlier SC316 recall). I am especially concerned that the current recall (26V430) describes the same underlying defect as an earlier recall (SC316/24V407) that was supposed to have been repaired, and that no remedy is yet available for this recurrence. This raises serious questions about the adequacy of the original repair and the vehicle’s ongoing fire risk. I am filing this complaint to document this pattern of recurring safety defects and request that NHTSA and Kia treat this as evidence of an unresolved, recurring hazard — not an isolated incident.

NHTSA ID

11749718

Incident

Jul 11, 2026

The fuel gauge intermittently fails and incorrectly displays that the vehicle has little or no fuel, even when the tank is nearly full. On the first occasion, I was at home. The second time, after shopping, I started the vehicle and the gauge indicated there was no fuel, despite knowing the tank was almost full. As I continued driving, the fuel gauge slowly began registering correctly until it eventually returned to showing the proper fuel level. This has now happened twice. This is a serious safety concern because the driver cannot accurately determine the amount of fuel in the vehicle. An incorrect fuel reading could cause someone to believe the vehicle is out of fuel, become stranded in an unsafe location, or make unnecessary emergency stops, creating a potential hazard for both the driver and others on the road.

NHTSA ID

11749688

Incident

Jun 26, 2026

On June 15, 2026, my check engine light came on. On June 17, 2026, I took it to Auto Zone, they checked the code for the check engine light, and it indicated P0016 and P0017–crankshaft issues. On June 19, 2026, while driving down the highway, my vehicle failed to accelerate. I exited the highway, and my vehicle completely decelerated and ultimately shut down. I was unable to get my engine running and had to get it towed to the dealer. It has been at the dealer for 3 weeks now. The dealer said my engine will likely need to be replaced. It is a 2023 Kia Telluride with less than 66,000 miles on it.

NHTSA ID

11749449

Incident

Jun 19, 2026

While driving my car randomly displays a warning that I need to shift to park or neutral immediately and turn off my engine. Sometimes my car will work afterwards, other times it will not and I’m stuck for 5-7 minutes. It happens in the middle of me driving with no warning signs. I’ve tried to ignore it and the whole car shuts off and the brakes lock up. It is very frightening. I brought it in the first time and they claimed it was my battery so they replaced it. It’s now happened 4 times and they have no idea how to fix it. My car has been at the dealership for 6 weeks now with no end in sight. They want to give me my car back but I keep pushing back. They were able to duplicate the issue one time but no error codes came up. It happened to the technician at a stop light so they’re claiming it’s probably only when stopped. Which is not true, so they don’t see the safety concern!!! I’m 8 months pregnant and do not feel safe driving a car that shuts off in the middle of me driving! I have also opened up a case with corporate. I have seen Reddit threads and so many complaints regarding this issue. Specifically on 2025 tellurides, although mine is 2023. I want out of this car because I genuinely fear for mine and my families safety in this car. I can’t believe this isn’t a bigger issue!!!!

NHTSA ID

11749226

Incident

May 26, 2026

AWD Coupler is bad make noise and shaking at low turn speeds only

NHTSA ID

11749053

Incident

Dec 3, 2025

My vehicle has an active Supplemental Restraint System (SRS) airbag dashboard warning light. A professional diagnostic scan has confirmed the active fault code: B143100 - "SIDE AIRBAG REAR DRIVER RESISTANCE CIRCUIT SHORT TO GROUND This exact physical failure matches the known manufacturing defect detailed in NHTSA Campaign 23V-035 (Kia Recall Code SC262). While my specific VIN does not currently show up as part of the official recall population, the vehicle is suffering from the identical manufacturing defect and active short, resulting in a disabled passenger safety system.

NHTSA ID

11747805

Incident

Jun 30, 2026