2018 Lexus IS 300

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

The contact owns a 2018 Lexus IS300. The contact stated that while driving at an undisclosed speed, the vehicle felt sluggish. The contact then heard an abnormal cranking noise underneath the hood of the vehicle. The vehicle was taken to the dealer where the failure could not be duplicated. No warning lights were illuminated. The contact stated that she recorded the noise then took the vehicle back to the dealer; however, the dealer informed her that the fuel injectors might need to be replaced. The vehicle was repaired; however, while the accelerator pedal was depressed, the vehicle failed to accelerate as needed. The contact stated that additional pressure on the accelerator pedal was needed for the vehicle to perform as designed. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was notified of a possible buy back. The failure mileage was approximately 15,000

NHTSA ID

11492601

Incident

Jun 21, 2021

Mileage

15,000 mi

I was driving down the highway at 70 mph and it was windy at the same time. Out of no where my sunroof window exploded shattering the glass. Luckily I usually keep the cover close. It sounded a gun shot that went off. There was nothing around me that would come down and break the window of the sunroof. It just happened out of no where.

NHTSA ID

11460066

Incident

Apr 6, 2022

2018 LEXUS IS 300. CONSUMER WRITES IN REGARDS TO VEHICLE STALLING WHILE TRYING TO MAKE A U-TURN. *LD *JS

NHTSA ID

11340152

Incident

Nov 15, 2019

TL* THE CONTACT OWNS A 2018 LEXUS IS 300. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT REACHED OUT TO LEXUS OF NORTH MIAMI LOCATED AT (14100 BISCAYNE BLVD, NORTH MIAMI, FL 33181) AND IT WAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11318475

Incident

Jan 13, 2020

DRIVING ON 285 EAST IN ATLANTA GA 11/29/2018 WHEN MY LEXUS IS 300 SUNROOF EXPLODED. ALL WINDOWS WERE CLOSED TEMPERATURE WAS 37 DEGREES. IT SOUND LIKE A GUN WENT OFF. GLASS FELL FROM THE ROOF AND PIECE OF THE GLASS WENT IN MY LEFT EYE. I MADE APPOINTMENT FOR THE EYE DOCTOR FOR 11/30/2018

NHTSA ID

11154859

Incident

Nov 29, 2018

Mileage

7,000 mi

WHEN I ACCELERATE FROM A STOP OR WHILE MOVING ON A ROADWAY, THE ENGINE SEEMS TO STALL. I'M NOT TALKING ABOUT THE NORMAL TURBO SPOOLING STALL. IT LASTS FOR ABOUT 3 TO 5 FULL SECONDS. WHEN YOU NEED POWER TO PREVENT AN ACCIDENT, YOU CAN'T AFFORD THAT TIME LAG, AS IT COULD CAUSE YOUR DEATH. THE DEALER TOLD ME THAT LEXUS SAYS IT'S NORMAL, THEY ALL DO IT. I DON'T FEEL ANY MANUFACTURER WOULD DELIBERATELY BUILD AND SELL A VEHICLE THAT WOULD PUT THE OCCUPANTS IN DANGER OF POSSIBLE DEATH. THE DEALER PICKED UP THE CAR AND AFTER FIVE DAYS CALLED ME TO SAY NOTHING IS WRONG AND THEY CAN'T FIX THE PROBLEM BECAUSE LEXUS COMPANY SAYS IT'S NORMAL. AT THIS POINT I'M REFUSING TO DRIVE THE CAR, IT'S EXTREMELY DANGEROUS. I HAVE ONLY DRIVEN IT ABOUT 188 MILES SINCE BUYING IT ALMOST 1 MONTH AGO. I CALLED THE DEALER ABOUT MY CONCERN AFTER HAVING THE CAR ONLY 20 DAYS.

NHTSA ID

11149541

Incident

Oct 20, 2018

Mileage

240 mi

TSB: Some 2013 ? 2020 model year Lexus vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 Fuel Rail / System Pressure ? Too Low Techstream data list analysis may reveal positive fuel trims including a no pressure condition verified by a manual fuel pressure gauge. Follow the Repair Procedure in this bulletin to address these conditions.

DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. The settlement includes Lexus?s agreement to provide a Customer Support Program for certain 2015-2020 model year (MY) vehicles that were not previously involved in a Safety Recall or Special Service Campaign related to the low pressure fuel pump. The purpose of this Customer Support Program letter is to help clarify how to administer this coverage in accordance with the settlement.

DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. The settlement includes Lexus?s agreement to provide a Customer Support Program for certain 2013-2020 model year (MY) vehicles originally equipped with low pressure fuel pumps repaired under Safety Recall 20LA01 or Special Service Campaign 21LC01. The purpose of this Customer Support Program letter is to help clarify how to administer this coverage in accordance with the settlement.

TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Lexus vehicles equipped with an FKS engine

TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Lexus vehicles equipped with an FKS engine

Lexus Safety Recall and Service Campaign - Technician Certification Requirements 4.13.2022