1999 Lexus LX470

The contact owns a 1999 Lexus LX470. The contact stated that after a vehicle inspection, it was discovered that the subframe of the vehicle had sustained severe corrosion making the vehicle unsafe to drive. The cause of the corrosion was not determined. The manufacturer was notified of the failure but no assistance was offered. The local dealer was not yet contacted. The approximate failure mileage was 134,000.

NHTSA ID

11461192

Incident

Apr 1, 2022

Mileage

134,000 mi

I WAS WAITING AT A STOPLIGHT BEHIND A HIGH VOLUME OF TRAFFIC AND STOPPING AND GOING AS THE LIGHT LET VEHICLES THROUGH. MY ABS LIGHT AND BRAKE LIGHT CAME ON ALONG WITH A LOUD CONSISTENT ALARM. I PROCEEDED THROUGH THE LIGHT AND PULLED OVER AT THE NEAREST PARKING LOT. AS I PULLED INTO A PARKING SPOT, THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD TO APPLY SIGNIFICANT FORCE TO THE BRAKE PEDAL TO GET THE VEHICLE TO STOP. IN THE PARKING LOT UNDER SAFE CONDITIONS I TESTED THE MINIMAL BRAKING I HAD LEFT AND DETERMINED THE VEHICLE WAS UNSAFE TO DRIVE HOME. I HAD THE VEHICLE TOWED TO THE LOCAL SHOP AND THE ISSUE WAS DIAGNOSED AS THE ABS ACCUMULATOR PUMP HAD FAILED (HAD COMPLETELY SEIZED UP). THIS SEEMS LIKE A MAJOR DESIGN FLAW. I HAD A VERY SHORT AMOUNT OF TIME TO REACT TO THE ALARMS I WAS GIVEN. A FAILURE OF SUCH A CRITICAL COMPONENT CAUSES THE LOSS OF ALL POWER BRAKES. WHAT IF I HAD NOT GOTTEN THE WARNINGS I DID? I RECENTLY HAD A NEW PUMP INSTALLED AND I AM BACK ON THE ROAD. I AM VERY LUCKY THIS ISSUE DID NOT HAPPEN AT HIGH SPEEDS OR ELSE THE OUTCOME COULD HAVE BEEN MUCH WORSE.

NHTSA ID

10767311

Incident

Sep 17, 2015

Mileage

254,000 mi

STARTED VEHICLE....ABS AND BRAKE LIGHT CAME ON AS WELL AS AN AUDIBLE BUZZER. DROVE THE TRUCK 3 MILES AND LOST ALL BRAKES, PEDAL TO THE FLOOR AND HAD TO USE HAND BRAKE (EMERGENCY BRAKE) TO GET STOPPED.

NHTSA ID

10763675

Incident

Sep 10, 2015

Mileage

225,000 mi

THE CAR HAD BEEN DRIVING NORMALLY ON THE FREEWAY FOR APPROXIMATELY ONE HOUR. SUDDENLY, THE ABS WARNING LIGHT AND THE BRAKE WARNING LIGHTS BECAME ILLUMINATED ON THE DASHBOARD, FOLLOWED SHORTLY AFTERWARDS BY A BEEPING ALARM. THE CAR WAS IMMEDIATELY PULLED OFF THE FREEWAY AT THE NEXT EXIT AND WAS ABLE TO DRIVE 1 BLOCK INTO A PARKING LOT. ONCE IN THE PARKING LOT, THE BRAKES FAILED COMPLETELY AND THE ONLY WAY TO STOP THE VEHICLE WAS WITH THE EMERGENCY BRAKE. FURTHER TESTING FOUND THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, THE PEDAL WOULD GO DIRECTLY TO THE FLOOR WITH LESS THAN 5% EFFECT ON BRAKING THE VEHICLE. LATER INVESTIGATION BY THE MECHANIC DETERMINED THE BRAKE FAILURE TO BE THE RESULT OF A FAILED ABS MOTOR AND ACCUMULATOR. FURTHER INVESTIGATION SHOWS THIS SEEMS TO BE A COMMON PROBLEM AMONG THE 1998 AND 1999 TOYOTA LANDCRUISER AND LEXUS LX-470 VEHICLES. NO RECALL HAS BEEN REGISTERED, NOR WILL TOYOTA / LEXUS ACKNOWLEDGE THIS AS A REOCCURRING PROBLEM. (THOUGH CLEARLY THIS IS A PROBLEM WHEN ANY RESEARCH IS DONE). THIS IS A SERIOUS PROBLEM THAT RESULTS IN ALMOST A COMPLETE LOSS OF BRAKING OF THE VEHICLE. IT WAS ONLY BECAUSE THE VEHICLE WAS PULLED OFF THE ROAD IMMEDIATELY AFTER THE WARNING LIGHTS AND ALARM SOUNDED THAT A SERIOUS, FREEWAY SPEED ACCIDENT WAS AVOIDED.

NHTSA ID

10743896

Incident

Jul 20, 2015

Mileage

106,000 mi

WHILE DRIVING THE VEHICLE, IT WILL SUDDENLY IGNORE THROTTLE INPUT, AND WILL BE IDLING ONLY. WHILE NOT STALLED, IT IS DIFFICULT TO MANEUVER THE VEHICLE AND GET OUT OF THE WAY OF TRAFFIC. THIS CAN HAPPEN AT ANY TIME. TO REMEDY THE SITUATION, IT IS NECESSARY TO SHUT THE ENGINE OFF AND RESTART. IT CAN BE A DANGEROUS SITUATION BECAUSE IT HAS HAPPENED RIGHT AT THE ENTRANCE TO A MAJOR INTERSECTION, AND WHILE TRAVELING IN CONGESTED FREEWAY DRIVING. ONE REPAIR SHOP REPLACED THE THROTTLE POSITION SENSOR, BUT THIS HAS NOT FIXED THE PROBLEM. IT IS GETTING WORSE, AND OCCURS MORE FREQUENTLY THAN EVER. *TR

NHTSA ID

10369972

Incident

Dec 4, 2010

Mileage

102,000 mi

TL*THE CONTACT OWNS A 1999 LEXUS LX470. WHILE DRIVING 35 MPH, THE ABS BRAKE LIGHT ILLUMINATED AND THERE WAS A LOUD BUZZING NOISE COMING FROM THE INSTRUMENT CLUSTER. THE VEHICLE WOULD NOT STOP WHEN THE BRAKES WERE APPLIED UNTIL THE CONTACT SHIFT TO A LOW GEAR. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THERE WAS AN INTERNAL SHORT CIRCUIT IN THE ABS HYDRO PUMP MOTOR .THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 126775 AND THE CURRENT MILEAGE WAS 126781.

NHTSA ID

10344192

Incident

Jul 10, 2010

Mileage

126,775 mi

1999 LX470 LEXUS SUV RIGHT STABILIZER BRACKET CONNECTION TO FRAME RUSTED THROUGH AND BAR IS FREE FLOATING NOW. RUSTED PART IS STEEL FRAME TANG WHERE BOLTS GO THROUGH TO CONNECT TO FRAME I KNOW TOYOTA HAS FRAME RUST PROBLEMS, DEALER FOUND IT THEN RUSHED ME OUT SAID WEATHER CAUSED IT. *TR

NHTSA ID

10340244

Incident

Jun 25, 2010

Mileage

115,000 mi

DT: THE CONTACT STATED WHILE DRIVING H HEARD A STRANGE NOISE COMING FROM THE SUN ROOF. UPON OPENING THE SUN ROOF GLASS CRACKED AND CRUMBLED INTO PIECES. HE TOOK THE VEHICLE TO THE DEALER. THIS WAS NOT COVERED UNDER WARRANTY, BUT WAS REPLACED AT THE CONTACT'S EXPENSE. *AK

NHTSA ID

10144052

Incident

Nov 20, 2005

Mileage

79,000 mi

Lexus Safety Recall and Service Campaign - Technician Certification Requirements 4.13.2022

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Lexus. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Lexus.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center in Dealer Daily as well.

Safety Recall and Service Campaign - Technician Certification Requirements

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003-93, PG002-90, L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003 93, and PG002-90. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1990 ? 2020 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin.

TSB: OBSOLETE NOTICE April 06, 2020: This bulletin is now obsolete. Please see L-SB-0008-20. Replacement Certification Labels and VIN Plates

TSB: Replacement Certification Labels. OBSOLETE NOTICE November 28, 2017: This bulletin is now obsolete. Please see L-SB-0179-17.