1995 Mazda 626

OBTAINED RECALL 99V-358

SEE RESUME FOR DETAILS.

IN MAY OF 1997, ODI UPGRADED TO AN ENGINEERING ANALYSIS WITH 51 COMPLAINTS.ODI IS NOW AWARE OF 88 COMPLAINTS OF ALLEGED INAPPROPRIATE AIRBAG DEPLOYMENTS.TYPICAL COMPLAINTS ALLEGE THAT THE AIRBAGS DEPLOYED AFTER THE VEHICLE HIT A POT HOLE AT BETWEEN 20 AND 45 MPH, OR THAT THE AIRBAGS DEPLOYED WHILE DRIVING AT BETWEEN 20 OR 60 MPH FOR NO APPARENT REASON.APPROXIMATELY 25 DRIVERS ALLEGED THAT THEY DID NOT HIT ANYTHING IN THE ROADWAY.MAZDA WILL CONDUCT A SAFETY RECALL OFALL 1995 AND 1996 MODELS OF THE MAZDA 626 AND MX-6, AS WELL AS A SMALL NUMBER OF 1997 MAZDA 626 MODELS, EQUIPPED WITH THE SAME SAS UNIT.THE SAS UNIT CONTROLS THE AIRBAG SYSTEMIT CONTAINS A BUILT-IN CRASH SENSOR TO DETECT VEHICLE DECELERATION DURING A COLLISION.AFFECTED MODELS WERE ASSEMBLED FROM JUNE 1, 1994 THROUGH SEPTEMBER 10, 1996 AND HAVE A VIN WITHIN THE FOLLOWING RANGES: MAZDA 626:1YVGE22**S5300001 THROUGH 1YVGE22**V5599030 MAZDA MX-6: 1YVGE31**S5300001 THROUGH 1YVGE31**T5589965ALL OWNERS WILL BE NOTIFIED OF THE POSSIBILITY THAT THEIR VEHICLE MAY EXPERIENCE AN UNNECESSARY AIRBAG DEPOYMENT IN CERTAIN SITUATIONS.THEY WILL BE INSTRUCTED TO BRING THEIR VEHICLE TO A MAZDA DEALER TO REPROGRAM THE SAS UNIT TO REDUCE THE FREQUENCY OF UNNECESSARY DEPLOYMENTS.

IN JANUARY OF 1997, ODI OPENED A PE BASED ON 9 ODI COMPLAINTS.ODI IS NOW AWARE OF 51 COMPLAINTS OF ALLEGED INAPPROPRIATE AIR BAG DEPLOYMENTS.TYPICAL COMPLAINTS INCLUDE AIR BAG DEPLOYMENTS AFTER THE VEHICLE HIT A POT HOLE WHILE DRIVING BETWEEN 20 AND 45 MPH AND AIR BAG DEPLOYMENTS WHILE DRIVING AT SPEEDS BETWEEN 20 AND 60 MPH FOR NO APPARENT REASON.APPROXIMATELY 21 DRIVERS ALLEGED THAT THEY DID NOT HIT ANYTHING PRIOR TO THE AIR BAG DEPLOYMENT.IN FOUR OF THESE INCIDENTS THE DRIVER CLAIMS TO HAVE LOST CONTROL AND HIT A CURB AFTER THE AIR BAGS DEPLOYED.IN ADDITION THERE ARE FOUR INCIDENTS WHERE THE DRIVER ALLEGES THAT THE AIR BAGS DEPLOYED AFTER A TIRE BLOWOUT WHILE DRIVING.LESS COMMON INCIDENTS INCLUDE ALLEGATIONS OF THE AIR BAGS DEPLOYING AFTER PARKING THE VEHICLE AND REMOVING THE KEY, CROSSING RAILROAD TRACKS, WHILE BEING TOWED, WHILE BRAKING, AFTER HITTING A CURB, AND AFTER HITTING A MANHOLE COVER.ODI IS UPGRADING THIS INVESTIGATION TO OBTAIN ADDITIONAL INFORMATION ABOUT THE REPORTS GATHERED TO DATE, THE SENSORS USED IN THE VEHICLES, AND TO ASSESS THE IMPACT THAT THE ALLEGED DEFECT HAS ON HIGHWAY SAFETY.

WENT TO START VEHICLE WILL NOT START SOMETHING FAULTY IN IGNITION POSSIBLY. SMELLED LIKE SMOKE INSTANTLY TURNING VEHICLE OFF. IMMEDIATELY DISCONNECTED BATTERY FROM VEHICLE.

NHTSA ID

11062621

Incident

Jan 13, 2018

Mileage

207,295 mi

TL* THE CONTACT OWNS A 1995 MAZDA 626. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10984879

Incident

Oct 22, 2015

TL* THE CONTACT OWNS A 1995 MAZDA 626. WHEN THE IGNITION KEY WAS TURNED, THE VEHICLE FAILED TO START INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 06/29/16*LJ *TR

NHTSA ID

10855693

Incident

Nov 20, 2015

TL* THE CONTACT OWNS A 1995 MAZDA 626. THE CONTACT RECIEVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER STATED THAT THE PARTS WOULD BE AVAILABLE IN FEBURARY OR MARCH. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10846022

Incident

Mar 10, 2016

TL* THE CONTACT OWNS A 1995 MAZDA 626. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10838950

Incident

Dec 18, 2015

1995 MAZDA 6, CONCERNED THAT THE AIR BAG EXPLOSIONS DOES NOT INCLUDE CARS MANUFACTURED BEFORE THE YEAR 2000...UPDATED 02/12/15*BF THE CONSUMER STATED HER SON WAS DRIVING, WHEN SUDDENLY THE AIR BAGS SPONTANEOUSLY EXPLODED, FILLING THE FRONT OF THE CAR WITH SMOKE AND FLYING SHRAPNEL IN ADDITION TO THE DEFLATED MATERIAL FROM THE AIR BAG ITSELF. HER SON'S HAND WAS BURNED. THE CONSUMER STATED THE AIR BAG EXPLOSION WAS NOT THE RESULT OF AN ACCIDENT OF ANY KIND, NOT EVEN A POT HOLE OR ROUGH ROAD. *JB

NHTSA ID

10683333

Incident

Jul 22, 2014

WHILE DRIVING ON THE HIGHWAY AFTER JUST DROP OFF MY DAUGHTER, I PROCEEDED BACK ON THE HIGHWAY AND THE TRANSMISSION JUST THREW ME IN PARK. I PUT THE CAR IN PARK. THEN I PUT IN GEAR AND IT WAS DRIVING FINE AND THEN THE HOLD LIGHT STARTED FLASHING. WHILE DRIVING HOME IT WAS FINE AND THEN AGAIN IT STARTED ALL OVER. *JB

NHTSA ID

10541690

Incident

Sep 3, 2013

Mileage

162,000 mi

OVERDRIVE LIGHT INTERMITTENTLY GOES ON AND OFF CAUSING CAR TO BUCK, JERK AND HESITATE. DURING THAT TIME THE RPM SOARS IN THE RANGE OF 8-10. THIS OCCURS WHEN DRIVING ANY AMOUNT OF TIME. TRANSMISSION HAS BEEN REPLACED SEVERAL TIMES WITH THE SAME RESULT. *TR

NHTSA ID

10395675

Incident

Apr 1, 2010

Radio Unlocking Codes.

In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to comply with Federal, State, and local laws concerning odometer and related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the "Speedometer Replacement Label". Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service. With the use of SPECMO's services, it is possible that the odometer will be set between 10 to 31 miles over the odometer mileage at the time of replacement for both warranty and customer pay repairs. Please make sure that the customer is aware that there may be a slight variance to the odometer, in which case the customer may have to accept the slightly higher mileage. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after-warranty assistance (AWA) or DSA that can be utilized to cover this service expense.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to comply with Federal, State, and local laws concerning odometer and related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the "Speedometer Replacement Label". Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service. With the use of SPECMO's services, it is possible that the odometer will be set between 10 to 31 miles over the odometer mileage at the time of replacement for both warranty and customer pay repairs. Please make sure that the customer is aware that there may be a slight variance to the odometer, in which case the customer may have to accept the slightly higher mileage. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after- warranty assistance (AWA) or DSA that can be utilized to cover this service expense.

EXHAUST PIPE GASKET OPEN END: There has been some concern with the open end of hoop design being considered a defect in the gasket for P/N AJ17-40-305. The end of this ?hoop? is intentionally modified to press fix the gasket on the exhaust pipe. NOTE: The ?hoop? might become larger during shipping, but you can still use it by pressing this portion down when installing.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to comply with Federal, State, and local laws concerning odometer and related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the "Speedometer Replacement Label". Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service. With the use of SPECMO's services, it is possible that the odometer will be set between 10 to 31 miles over the odometer mileage at the time of replacement for both warranty and customer pay repairs. Please make sure that the customer is aware that there may be a slight variance to the odometer, in which case the customer may have to accept the slightly higher mileage. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after-warranty assistance (AWA) or DSA that can be utilized to cover this service expense.