1993 Mazda RX-7

There is no summary currently available

TL* THE CONTACT OWNS A 1993 MAZDA RX-7. THE CONTACT HEARD A LOUD NOISE COMING FROM THE VEHICLE WHILE IT WAS PARKED. THE CONTACT DISCOVERED THAT THE AIR BAGS DEPLOYED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC; HOWEVER, THE MECHANIC REFUSED TO DIAGNOSIS IT AND ADVISED THE CONTACT TO GO TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 51,976.

NHTSA ID

10870652

Incident

May 17, 2016

Mileage

51,976 mi

DROVE ON HIGHWAY AND VEHICLE STARTED TO SMOKE. PULLED OFF AN EXIT, OPENED HOOD AND FLAMES WERE COMING OUT FROM ENGINE COMPARTMENT. CAR IS SITTING AT A GARAGE WAITING TO BE REPAIRED. THIS IS THE THE 3RD ENGINE IN THE CAR, ALL RESULTING FROM OVERHEATING OR FIRE. 6/2001- ANTIFREEZE FIRE- ISSUED A USED ENGINE 5/2005- ANTIFREEZE FIRE- BOUGHT A USED ENGINE 3/2006-ANTIFREEZE AND OIL LEAK- REPLACE ALL ASSOCIATED HOSES/O-RINGS 2/2012- ENGINE FIRE- WAITING FOR REPAIRS. *TT

NHTSA ID

10459235

Incident

Feb 2, 2012

Mileage

88,813 mi

TL*THE CONTACT OWNS A 1993 MAZDA RX7. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN IT CAUGHT ON FIRE. THE LOCAL FIRE DEPARTMENT WAS NOTIFIED. THE CONTACTWAS UNSURE AS TO WHAT CAUSED THE FIRE, BUT STATED THAT HE SMELLED GAS FUMES BEFORE THE FIRE OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 50,000.*AK

NHTSA ID

10188435

Incident

Mar 31, 2007

Mileage

50,000 mi

DT*: THE CONTACT STATED THE VEHICLE LOST POWER WHILE GOING UP HILL. LATER, WHILE THE VEHICLE WAS PARKED IN A PARKING LOT SMOKE CAME FROM UNDER THE HOOD. AFTER LIFTING THE HOOD FLAMES CAME OUT. THE FIRE WAS EXTINGUISHED BY A FIRE EXTINGUISHER. THE FIRE DEPARTMENT WAS CONTACTED AFTERWARDS TO ENSURE IT WAS CONTAINED. UPON INSPECTION THE DEALERSHIP DETERMINED THE FIRE STARTED IN THE AREA AROUND THE BATTERY AND ALTERNATOR WIRING. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP AWAITING REPAIRS.

NHTSA ID

10149918

Incident

Feb 7, 2006

Mileage

36,500 mi

DT*: THE CONTACT STATED THE VEHICLE WAS STARTED AND LEFT IDLING, UPON RETURNING THERE WAS FIRE COMING FROM UNDER THE HOOD. THERE WERE NO PREVIOUS PROBLEMS WITH THE VEHICLE. UPON INSPECTION THE INSURANCE COMPANY DETERMINED THE FIRE STARTED IN THE AREA AROUND THE BATTERY AND ALTERNATOR WIRING. THE FIRE DEPARTMENT FILED A REPORT. THE FIRE DESTROYED THE VEHICLE AND THE CONTACT'S HOME.

NHTSA ID

10149916

Incident

Nov 21, 2005

Mileage

106,000 mi

THE CONSUMER RECEIVED A RECALL NHTSA#94-V-094-000 ON MAY 1997 ON THE RADIATOR CAP PRESSURE RELIEF VALVE. THE RELEASE PRESSURE WAS SET TOO HIGH WHICH COULD CAUSE THE COOLANT TO REACH TEMPERATURES THAT EXCEED THERMAL DESIGN LIMITS OF SOME COMPONENTS OF THE COOLANT SYSTEM. SHOULD THIS OCCUR THE ENGINE COOLANT COULD LEAK DIRECTLY ON TOP OF THE ENGINE. THE CONSUMER STATED THIS RECALL FAILED. *NLM THE RECALL WAS PARTIALLY COMPLETED. BOTH REQUIRED REPLACEMENT OF THE COOLING SYSTEM INCLUDING THE WATER PUMP WHICH WAS NOT DONE BECAUSE THE VEHICLE LOST THE WATER PUMP ON THE ROAD. *SCC *JB

NHTSA ID

10040629

Incident

Sep 25, 2003

Mileage

10,800 mi

OIL LINE TO TURBO'S COLLAPSED CAUSING THE INNER COOLERS TO BE FLOODED WITH OIL. THIS WAS CAUSED BY THE APEX SEAL COMING OFF IN THE ROTARY TUBE WHICH CAUSED THE COMPRESSION LEVELS TO DROP. THIS DAMAGE COSTS ME IN EXCESS $10000 AND HAPPENED AT 30000 MILES. AN INVESTIGATION IS CURRENTLY UNDER WAY. *JB

NHTSA ID

10018854

Incident

Apr 8, 2002

Mileage

31,000 mi

FUEL PUSTATION DAMPNER SPONTANEOUSLY FAILED AND BEGAN SPRAYING A 6" STREAM OF FUEL UNDER THE UPPER INTAKE MANIFOLD. THANK GOD I NOTICED THE SMELL OR THIS WOULD HAVE BEEN A VERY NASTY ENGINE FIRE. THE FUEL LEAKS DOWN FROM THE FPD AND RUNS OFF ONTO THE TURBO ASSEMBLY. SCC ***DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS***770788

NHTSA ID

10006667

Incident

Dec 26, 2002

Mileage

135,000 mi

Radio Unlocking Codes.

In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to comply with Federal, State, and local laws concerning odometer and related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the "Speedometer Replacement Label". Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service. With the use of SPECMO's services, it is possible that the odometer will be set between 10 to 31 miles over the odometer mileage at the time of replacement for both warranty and customer pay repairs. Please make sure that the customer is aware that there may be a slight variance to the odometer, in which case the customer may have to accept the slightly higher mileage. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after-warranty assistance (AWA) or DSA that can be utilized to cover this service expense.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to comply with Federal, State, and local laws concerning odometer and related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the "Speedometer Replacement Label". Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service. With the use of SPECMO's services, it is possible that the odometer will be set between 10 to 31 miles over the odometer mileage at the time of replacement for both warranty and customer pay repairs. Please make sure that the customer is aware that there may be a slight variance to the odometer, in which case the customer may have to accept the slightly higher mileage. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after- warranty assistance (AWA) or DSA that can be utilized to cover this service expense.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to comply with Federal, State, and local laws concerning odometer and related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the "Speedometer Replacement Label". Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service. With the use of SPECMO's services, it is possible that the odometer will be set between 10 to 31 miles over the odometer mileage at the time of replacement for both warranty and customer pay repairs. Please make sure that the customer is aware that there may be a slight variance to the odometer, in which case the customer may have to accept the slightly higher mileage. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after-warranty assistance (AWA) or DSA that can be utilized to cover this service expense.

In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to comply with Federal, State, and local laws concerning odometerand related documentation requirements when providing a repair or replacement. Mazda vehicles are manufactured with tamper-proof speedometers. When a speedometer is replaced, the new speedometer will read zero (0) miles. This procedure is extremely important to accurately represent actual vehicle mileage. Prior to speedometer removal, complete the information required on the ?SpeedometerReplacement Label?.Labels can only be ordered through Mazda eStore. In an effort to achieve a higher level of Customer Experience and retain the value of Mazda?s vehicles, MNAO Warranty Operations is allowing all Mazda dealers to utilize a third party, SPECMO Enterprises, Inc., for Instrument Panel Cluster (IPC) odometer setting service.With the use of SPECMO?s services, a Mazda dealer can get the odometer setting updated to reflect the correct mileage at the time of replacement for both warranty and customer pay repairs, therefore resulting in a higher level of customer satisfaction. Since odometer setting service is not part of the warranty repair, it is not warrantable nor required, but optional. However, Mazda Warranty policy provides after- warranty assistance (AWA) or DSA that can be utilized to cover this service expense.