1994 Mercury Sable Problems

TL* THE CONTACT OWNS A 1994 MERCURY SABLE. WHILE DRIVING VARIOUS SPEEDS OR IDLING, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

THE KEY INSERT DOES NOT ALIGN, HAVE HAD 2 TRANSMISSIONS IN 5 YEARS. (I KNOW TO CHECK MY FLUIDS) NEW ENGINE, & THE PAINT IS AWFUL. ENGINE, MOTOR, GAS, GASPS AND JERKS WITH ME. HAVE HAD MOTOR MOUNTS REPLACED, NOTHING HELPS. HEATER COIL(?) WENT OUT, I HAVE NO HEAT NOW. WE HAD TO BYPASS. THE REST I HAVE NOT BEEN ABLE TO AFFORD TO REPAIR. I HATE THIS CAR. I AM WORRIED EVERYTIME I GET IN IT THAT MY MOTHER AND I ARE NOT GOING TO GET HOME. I HAVE HAD THE CAR TOWED SO MANY TIMES, THE MAN WHO DOES THE TOWING KNOWS ME AND MY CAR ON SIGHT. I WILL NOT GO MORE THAN 30 MILES FROMT HE HOUSE. MY MECHANIC EVEN HATES THE CAR. I CALL HIM AN ANGEL, BECAUSE HE HAS KEPT IT RUNNING.

TL* - THE CONTACT HAS A 1994 MERCURY SABLE. THE CONTACT STATED THAT HE PURCHASED A VEHICLE ON THE AFTERNOON OF 03/16/2007, AND THE FOLLOWING MORNING 03/17/2007 THE VEHICLE WOULD NOT WORK, AND TRANSMISSION FLUID WAS POURING OUT OF THE VEHICLE. THE CONTACT STATED THAT HE COULD POUR IT IN THE TOP AND WATCH IT COME OUT OF THE BOTTOM. THE CONTACT WAS TOLD BY THE DEALER THAT THEY WOULD COME AND GET THE VEHICLE REPAIR IT AND CHARGE HIM FOR IT. THE CURRENT AND FAILURE MILEAGE WERE BOTH 131,368 MILES.

CONTACT STATED: WHEN SHIFTING FROM REVERSE TO DRIVE ENGINE MAKES A LOUD NOISE. ALSO, THE FRONT SUSPENSION SPRINGS BROKE WHILE DRIVING.*AK

THE LEFT REAR BRAKE LINE BECAME CLOGGED WITH COROSION DEBRIS AND THE BRAKE LOCKED.*AK

REAR STEEL BRAKE PIPE FAILED DUE TO CORROSION.*AK

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE ENGINE STALLS WITHOUT WARNING. THIS OCCURS MORE OFTEN IN WARMER WEATHER. THE VEHICLE RESTARTS ONLY AFTER COOLING OFF FOR AT LEAST 30 MINUTES. IT HAS BEEN INSPECTED ON SEVERAL OCCASIONS; HOWEVER THE PROBLEM COULD NOT BE DUPLICATED. AFTER RESEARCHING THE PROBLEMS WITH THIS VEHICLE THE CONTACT BELIEVES THE PFI IGNITION MODULE IS OVER HEATING, CAUSING THE STALLING.

PROBLEMS WITH HEADLIGHT/ RUNNING LIGHT SWITCH, INTERMITTENT FAILURE, DOOR OPEN SAFETY LAMP FAILURE. *CB

MY WIFE'S FINGER WAS COUGHT IN THE ELECTRIC WINODW WHEN SHE INADVERTANTLY PRESSED THE "UP" BUTTON!*AK

MULTI FUNCTION SWITCH IS DEFECTIVE. WHEN USING THE RIGHT TURN SIGNAL IT MAKES THE WINDSHIELD WIPERS TURN OFF, AND THE WINDSHIELD WIPER FLUID WILL NOT COME OUT. *AK

TL*THE CONTACT OWNS A 1994 MERCURY SABLE. THE CONTACT STATED THAT HER HEADLIGHTS WOULD FAIL INTERMITTENTLY AND THEN ILLUMINATE AGAIN. SHE NOTICED THAT THE FAILURE OCCURRED IN BRIEF INTERVALS AND SHE SMELLED A BURNING ODOR. THE DEALER INSTALLED A NEW HEADLIGHT SWITCH AND, CONSEQUENTLY, THE DASHBOARD SWITCH MELTED. THE DEALER STATED THAT NOTHING COULD BE DONE. FORD STATED THAT HER VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 98V009000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE FAILURE MILEAGE WAS APPROXIMATELY 98,000.

MY HEADLIGHT SWITCH WENT OUT AND I REPLACED IT. I WAS WONDERING IF I COULD GET COMPANSATION FOR BUYING IT MYSELF, AS IT APPEARS TO BE A RECALL. ALSO THERE SEEMS TO BE A PROBLEM WITH MY HOME COMPUTER AND I AM NOT ABLE TO VIEW ANY DETAILED INFORMATION ABOUT MY VEHICLE. IF SOMEONE COULD E-MAIL ME, I WOULD GREATLY APPRECIATE THE INFORMATION THAT I NEED TO KNOW ABOUT MY CAR, OR ANYTHING THAT I QUALIFY FOR. I DON'T KNOW ANY OF MY VEHICLES PAST HISTORY, SO IT WOULD ALSO BE APPRECIATED IF I COULD RECIEVE IT.

THE KEY INSERT DOES NOT ALIGN, HAVE HAD 2 TRANSMISSIONS IN 5 YEARS. (I KNOW TO CHECK MY FLUIDS) NEW ENGINE, & THE PAINT IS AWFUL. ENGINE, MOTOR, GAS, GASPS AND JERKS WITH ME. HAVE HAD MOTOR MOUNTS REPLACED, NOTHING HELPS. HEATER COIL(?) WENT OUT, I HAVE NO HEAT NOW. WE HAD TO BYPASS. THE REST I HAVE NOT BEEN ABLE TO AFFORD TO REPAIR. I HATE THIS CAR. I AM WORRIED EVERYTIME I GET IN IT THAT MY MOTHER AND I ARE NOT GOING TO GET HOME. I HAVE HAD THE CAR TOWED SO MANY TIMES, THE MAN WHO DOES THE TOWING KNOWS ME AND MY CAR ON SIGHT. I WILL NOT GO MORE THAN 30 MILES FROMT HE HOUSE. MY MECHANIC EVEN HATES THE CAR. I CALL HIM AN ANGEL, BECAUSE HE HAS KEPT IT RUNNING.

HATCH GLASS CAME LOOSE STARTED LEAKING(56000) FUEL PUMP STARTED ACTING UP GET HOT AND HANG UP(75000) NO RECALL. STATE FARM SHOWED THEY PAID FOR TOWING ON MANY, FORD PRODUCTS THAT USED THE SAME PUMP STILL NO RECALL. TRANSMISSION SHIFTS DOWN, OR SHIFTS OUT OF GEAR WHILE DRIVING SMITH FORD CONWAY WAS SUPPOSED TO CHECK THE HEADS FOR LEAKS SIX MONTHS LATER THE HEAD GASKET BLEW,AND THE AIR WENT OUT AT THIS TIME I WAS TOLD THE THE DATE THIS CAR WAS ORIGINALLY PUT IN SEVICE MADE IT OUT OF WARRANTY. THIS CAR IS SITTING IN MY GARAGE WITH MOTOR OUT OF IT BECAUSE FORD DIDN'T DO ITS JOB. PAINT PEELED OFF THE INSIDE OF THE DOOR POST.

MANUFACTURER WILL NOT HONOR RECALL: SEVERE CORROSION OF THE REAR LOWER RETAINING PLATES FOR THE SUBFRAME ASSEMBLY SUPPORTING THE ENGINE AND TRANSMISSION. RISK IS DETACHMENT OF BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME. EXISTING RECALL 98V-323 ADDRESSED THIS PROBLEM IN CERTAIN VEHICLES. MY VEHICLE WAS OF THE YEAR, MAKE, AND MODEL COVERED BY THE RECALL, AND HAS THIS PROBLEM, BUT FORD IS CLAIMING THAT MY VIN# DOES NOT MAKE ME ELIGIBLE FOR THE RECALL. *TR

ON MAY 10, 2005, I WAS DRIVING TO AN APPT. AFTER I GOT OFF THE HIGHWAY, I WAS DRIVING DOWN TARKILN HILL ROAD AND MY CAR STARTED TO MAKE A LOUD CLUNKING SOUND AND THE STEERING WAS OFF. I APPLIED MY BRAKE AT THE RED LIGHT AND MY BRAKE PEDAL WENT DOWN TO THE FLOOR. I WAS ABLE TO STOP THE CAR. I WENT TO THE APPT. WHICH WAS TWO BLOCKS AWAY VERY SLOWLY. WHEN I GOT OUT OF THE APPT. TO COME HOME, THE CAR STARTED AND THE NOISE WAS GONE. I DROVE SLOWLY HOME AND WHEN I GOT HOME, I LOOKED ON THE INTERNET TO SEE IF ANYONE HAD THIS PROBLEM. I CAME ACROSS A COMPLAINT PAGE WHERE SOMEONE IS COMPLAINING OF THE SAME ISSUE AND STATED THAT HIS STEERING WENT. HE SAID IT WAS DUE TO A SAFETY RECALL. I LOOKED UP THE RECALL AND CAME ACROSS A PAGE THAT HAD THE RECALLS FOR MY VEHICLE WHICH IS A 1994 MERCURY SABLE. THE CAMPAIGN ID # IS 98V323000. IT GOES ON TO SAY: SUMMARY: DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP. IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH. I CONTACTED THE DEALER ON CHURCH STREET IN NEW BEDFORD, SENTURY LINCOLN/MERCURY. THEY TOLD ME TO BRING THE CAR IN. WHEN I GOT THERE, THEY TOLD ME THERE WOULD BE A $75.00 CHARGE TO SEE IF THAT IS THE PROBLEM, AND IF IT IS, I WOULD HAVE TO PAY, BECAUSE THE RECALL WAS NOT ON THEIR COMPUTER. I CALLED THE FORD COMPANY'S 800 NUMBER AND WAS TOLD THE SAME THING. I THEN CALLED A MERCURY NUMBER, THAT I GOT OFF THE INTERNET AND WAS TOLD BY THAT GENTLEMAN THAT THE ID # OF THE RECALL IS FROM A VENDOR AND THE FORD COMPANY HAS A RIGHT TO NOT CONSIDER IT A RECALL AND IF THEY DO NOT SUPPORT IT, WHICH THEY DO NOT, I WOULD HAVE TO FILE A COMPLAINT WITH YOU, WHICH IS WHAT I AM DOING.

WHEN THE BRAKED WERE APPLIED, THE VEHICLE SURGE FORWARD, WHICH CAUSED CONSUMER TO LOSE CONTROL OF THE VEHICLE. *JB

ROUGH IDLING YESTERDAY, HEAD GASKET BLEW TODAY. PUFF OF WHITE SMOKE AND USUAL ERUCTION OF ANTIFREEZE. AVOIDED ACCIDENT THOUGH I DID SWERVE INTO NEXT LANE BETWEEN 2 CARS.. *AK

CONSUMER STATES THERE IS A CLUNK NOISE, DEALER STATED SUBFRAME BUSHING SLEEVES WERE CRACKED CAUSING BUSHING TO MOVE AND MAKE THE CLUNK NOISE. *SLC *DT

COMPRESSOR LOCK UP,BROKE SURPENTINE BELT,WRAP AROUND DAMPER DAMAGED OIL SEAL &DAMPER BROKE OR CRACK A/C LINES. REPLACED A/C COMPRESSOR A/C MUFFLER ASSY & O RINGS & EVAC & RECHARGE SYSTEM....REAR PASSENGER DOOR, REPLACED WINDOW MOTOR , PASSENGER DOOR , REPLACED WINDOW MOTOR & SWITCH. STEERING HANGS UP OR GETS STUCK,MAKES WINING NOISE, FRONT END RATTLES,POPS &MAKES CRACKING NOISE,REAR AXLE SOUNDS LIKE ITS GOING TO FALL OUT,WORSE CAR I'VE EVER OWNED!

TL*THE CONTACT OWNS A 1994 MERCURY SABLE. THE CONTACT DROVE OVER A POTHOLE AND THE FRONT STRUT BROKE ON BOTH SIDES. THE VEHICLE WAS TOWED TO A MECHANIC WHO STATED THAT THERE WAS A RELATED RECALL 94E036000 (SUSPENSION: FRONT: SHOCK ABSORBER). THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 139,500. UPDATED 07/08/11*LJ THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE FRONT STRUT HAD BROKEN IN HALF. THE REMAINING STRUTS CONTAINED STRESS CRACKS. UPDATED 07/20/11

CONTACT STATED: WHEN SHIFTING FROM REVERSE TO DRIVE ENGINE MAKES A LOUD NOISE. ALSO, THE FRONT SUSPENSION SPRINGS BROKE WHILE DRIVING.*AK

THE KEY INSERT DOES NOT ALIGN, HAVE HAD 2 TRANSMISSIONS IN 5 YEARS. (I KNOW TO CHECK MY FLUIDS) NEW ENGINE, & THE PAINT IS AWFUL. ENGINE, MOTOR, GAS, GASPS AND JERKS WITH ME. HAVE HAD MOTOR MOUNTS REPLACED, NOTHING HELPS. HEATER COIL(?) WENT OUT, I HAVE NO HEAT NOW. WE HAD TO BYPASS. THE REST I HAVE NOT BEEN ABLE TO AFFORD TO REPAIR. I HATE THIS CAR. I AM WORRIED EVERYTIME I GET IN IT THAT MY MOTHER AND I ARE NOT GOING TO GET HOME. I HAVE HAD THE CAR TOWED SO MANY TIMES, THE MAN WHO DOES THE TOWING KNOWS ME AND MY CAR ON SIGHT. I WILL NOT GO MORE THAN 30 MILES FROMT HE HOUSE. MY MECHANIC EVEN HATES THE CAR. I CALL HIM AN ANGEL, BECAUSE HE HAS KEPT IT RUNNING.

WHILE DRIVING, POWER STEERING LOCKED UP AND ENGINE CAUGHT ON FIRE, CLAIM 52-2482-587. *SLC

THE KEY INSERT DOES NOT ALIGN, HAVE HAD 2 TRANSMISSIONS IN 5 YEARS. (I KNOW TO CHECK MY FLUIDS) NEW ENGINE, & THE PAINT IS AWFUL. ENGINE, MOTOR, GAS, GASPS AND JERKS WITH ME. HAVE HAD MOTOR MOUNTS REPLACED, NOTHING HELPS. HEATER COIL(?) WENT OUT, I HAVE NO HEAT NOW. WE HAD TO BYPASS. THE REST I HAVE NOT BEEN ABLE TO AFFORD TO REPAIR. I HATE THIS CAR. I AM WORRIED EVERYTIME I GET IN IT THAT MY MOTHER AND I ARE NOT GOING TO GET HOME. I HAVE HAD THE CAR TOWED SO MANY TIMES, THE MAN WHO DOES THE TOWING KNOWS ME AND MY CAR ON SIGHT. I WILL NOT GO MORE THAN 30 MILES FROMT HE HOUSE. MY MECHANIC EVEN HATES THE CAR. I CALL HIM AN ANGEL, BECAUSE HE HAS KEPT IT RUNNING.

HATCH GLASS CAME LOOSE STARTED LEAKING(56000) FUEL PUMP STARTED ACTING UP GET HOT AND HANG UP(75000) NO RECALL. STATE FARM SHOWED THEY PAID FOR TOWING ON MANY, FORD PRODUCTS THAT USED THE SAME PUMP STILL NO RECALL. TRANSMISSION SHIFTS DOWN, OR SHIFTS OUT OF GEAR WHILE DRIVING SMITH FORD CONWAY WAS SUPPOSED TO CHECK THE HEADS FOR LEAKS SIX MONTHS LATER THE HEAD GASKET BLEW,AND THE AIR WENT OUT AT THIS TIME I WAS TOLD THE THE DATE THIS CAR WAS ORIGINALLY PUT IN SEVICE MADE IT OUT OF WARRANTY. THIS CAR IS SITTING IN MY GARAGE WITH MOTOR OUT OF IT BECAUSE FORD DIDN'T DO ITS JOB. PAINT PEELED OFF THE INSIDE OF THE DOOR POST.

PROBLEMS WITH HEADLIGHT/ RUNNING LIGHT SWITCH, INTERMITTENT FAILURE, DOOR OPEN SAFETY LAMP FAILURE. *CB

WHILE DRIVING 40 MPH WARNING LIGHTS ON INSTRUMENT PANEL ILLUMINATED, INDICATING A MALFUNCTION WITHIN SYSTEM, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK

CONSUMER WAS INVOLVED IN A 30 MPH FRONTAL COLLISION IN WHICH DRIVER'S/ PASSENGER'S AIR BAGS DID NOT DEPLOY. PLEASE GIVE ANY FURTHER DETAILS. *AK

WHEN PULLING OUT OF A PARKING LOT DRIVING 5 MPH, VEHICLE WAS INVOLVED IN A HEAD ON CRASH THERE WAS NO DEPLOYMENT OF THE DRIVER'S SIDE AIR BAG. ANOTHER VEHICLE SPEED WAS ABOUT 40 MPH. CRASH WAS REPORTED TO INSURANCE COMPANY. THE VEHICLE IS BEING REPAIRED.

I HAVE THREE CHILDREN. THE YOUNGEST ONE IS OUTGROWING HIS TODDLER CAR SEAT. ALL CAR SEATS FOR OLDER CHILDREN REQUIRE A LAP AND SHOULDER BELT TO WORK, BUT THIS CAR HAS ONLY A CENTER REAR LAP BELT. I TRIED TO INSTALL A HARNESS IN THE CENTER, BUT WAS TOLD BY THE DEALER THAT IT IS IMPOSSIBLE TO INSTALL A CENTER REAR TETHER ANCHOR IN THIS CAR. HELP!*AK

THIS VEHICLE ONLY HAS A LAP BELT FOR THE CENTER REAR SEAT. I HAVE THREE CHILDREN AND THE YOUNGEST IS TURNING FOUR AND OUTGROWING HIS TODDLER SEAT. HIS TWO OLDER SIBLINGS SIT ON THE SIDES IN THE REAR, USING THE ONLY LAP-AND-SHOULDER BELTS IN THE REAR. I CANNOT FIND A BOOSTER SEAT THAT IS DESIGNED TO HOLD HIS SHOULDERS WHEN HE GROWS PAST 40 LBS, AND CAN BE ATTACHED TO THE CAR WITH ONLY THE LAP BELT. WHAT CAN I DO?*AK

TRAVELED APPROXIMATELY 120 MILES FROM HOME. UPON ARRIVING AT THE DESTINATION, I NOTICED THE RIGHT REAR TIRE WAS EXTREMELY LOW WITH AS ESTIMATED 10 P.S.I. AIR PRESSURE REMAINING. KNOWING THAT I HAD TWO PREVIOUS TIRE BLOWOUTS ON THIS VEHICLE DUE TO CRACKED VALVE STEMS AND OCCURRING WITHIN THE PREVIOUS 4 MONTHS, I MOVED THE VALVE STEM SLIGHTLY BACK AND FORTH AND NOTICED AIR ESCAPING FROM THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL. I PUT SOME SOAP BUBBLES AROUND THE STEM AND CONFIRMED THAT AIR WAS ESCAPING FROM A CRACK IN THE VALVE STEM. REFERENCE ODI #'S 10254187 AND 10254189 AS A REFERENCE ON THE PREVIOUS TWO VALVE STEM ISSUES ON SAME VEHICLE. SPARE INSTALLED. VISITED THE TIRE DEALERSHIP WHERE THE FOUR NEW REPLACEMENT TIRES WERE INSTALLED 2 YEARS, 8 MONTHS AND 26,068 MILES PRIOR. NO PUNCTURES, TEARS OR CUTS WERE FOUND ANYWHERE ON THE TIRE TREAD OR SIDEWALL. THE ONLY KNOWN CAUSE OF THE LOW TIRE WAS A CRACKED VALVE STEM IN THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL ALLOWING AIR TO EXHAUST QUICKLY FROM THE TIRE ONCE THE CRACK PROPAGATED TO INSIDE. A NEW VALVE STEM WAS INSTALLED. THE LEFT REAR TIRE VALVE STEM WAS ALSO REPLACED AT THIS TIME TO AVOID A FUTURE PROBLEM. CRACKED VALVE STEM INFORMATION; TR 413, EHA GERMANY. *TR

TRAVELING AT APPROXIMATELY 65 MPH WHEN RIGHT FRONT TIRE NEAR INSTANTLY DEFLATED CAUSING TOTAL TIRE FAILURE BEFORE THE VEHICLE COULD BE PULLED TO SIDE OF ROAD. TIRE SIDEWALL WAS TOTALLY DESTROYED. SPARE INSTALLED. VISITED THE TIRE DEALERSHIP WHERE THE FOUR NEW REPLACEMENT TIRES WERE INSTALLED 2 YEARS, 5 MONTHS AND 23,911 MILES PRIOR. NO PUNCTURES, TEARS OR CUTS WERE FOUND ANYWHERE ON THE TIRE TREAD OR SIDEWALL. THE ONLY KNOWN CAUSE OF THE TIRE FAILURE WAS A CRACKED (CUT) VALVE STEM (AS DOCUMENTED BY DEALERSHIP) IN THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL ALLOWING AIR TO EXHAUST QUICKLY FROM THE TIRE ONCE THE CRACK PROPAGATED TO INSIDE. A NEW TIRE WAS INSTALLED ALONG WITH A NEW VALVE STEM. CRACKED VALVE STEM INFORMATION; TR 413, EHA GERMANY. THIS WAS THE SECOND TIME (WITHIN 900 MILES) THAT A TIRE BLOWOUT OCCURRED DUE TO WHAT APPEARS TO BE A BAD VALVE STEM. CRACKED VALVE STEM WAS SAVED FOR REFERENCE. *TR

THERE IS CONSTANT CAR SHUTING OFF WHEN FIRST START. THE BATTERY LIGHT STAYS ON. THE WINDOWS DO NOT LET DOWN. THE AIR CONDITIONER BLOWS HOT AIR, EVEN ON COOL DAY. THE DOOR WON'T CLOSE AT TIMES, HAVE TO MESS WITH SCREWS. THE VENTS COVERS FALL OFF. BACK, LEFT WINDOW WILL NOT LET DOWN AT TIMES. LIGHTS GO ON AND OFF, SOMETIMES STAYS ON. WHEN A TRUCK PASSES, THE CAR SWIRVES/

PURCHASED NEW CAR, WAS DRIVING TO WORK, STOPPPED AT LIGHT AND THE FRONT LEFT DRIVE SIDE WHEELL FELL OFF. TT