RoadVitals

1991 Mercury Tracer

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
60
Latest Jun 26, 2019
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Jun 2, 1994
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
11
3 injuries, 0 deaths reported

Overview

Our database contains 60 NHTSA owner-reported complaints for the 1991 Mercury Tracer, most frequently naming the electrical, fuel system and seat belts categories. 3 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 55 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
94E019000

SUSPENSION:FRONT

Jun 2, 1994
919 units potentially affected
The defect: THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.
The risk: THIS CAN RESULT IN LOSS OF VEHICLE STEERING CONTROL ANDAN ACCIDENT.
The remedy: DANA WILL PAY FOR REPLACEMENT AND LABOR COSTS OF THE ADJUSTMENT PIN WITHOUT CHARGE TO THE INSTALLING FACILITY AND THE VEHICLE OWNER. THESE PINS SHOULD BE REPLACED BY A FORD ORIGINAL EQUIPMENT PIN ASSEMBLY. OWNER OR INSTALLER INQUIRIES CONCERNING THIS RECALL CAMPAIGN SHOULD CONTACT DANA SERVICE CENTER AT 1-800-248-9606.
DANA CORPORATIONView on NHTSA.gov
93V057000

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Apr 15, 1993
91,000 units potentially affected
The defect: THE ROLL PINS SECURING THE IGNITION LOCK IN THE STEERING COLUMN HOUSING CAN SEPARATE OR MOVE OUT OF POSITION.
The risk: THE IGNITION LOCK CYLINDER MAY DISENGAGE FROM THESTEERING COLUMN HOUSING WHICH COULD CAUSE THE STEERING COLUMN TO LOCK UP,RESULTING IN LOSS OF VEHICLE CONTROL AND A POSSIBLE ACCIDENT.
The remedy: IF ONE OR BOTH OF THE ROLL PINS ARE MISSING OR NOT FULLY INSERTED, THE IGNITION LOCK HOUSING WILL BE REPLACED, ALONG WITH THE DOOR-LOCKS AND THE LIFTGATE OR DECK-LID LOCKS SO THAT KEY COMPATIBILITY IS MAINTAINED. IF BOTH PINS ARE PRESENT AND FULLY INSERTED, A PLASTIC SNAP-ON SLEEVE WILL BE INSTALLED AS A PRECAUTION TO PREVENT THE ROLL PINS FROM COMING OUT.
FORD MOTOR COMPANYView on NHTSA.gov
92V117000

FUEL SYSTEM, GASOLINE

Aug 19, 1992
22,000 units potentially affected
The defect: FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.
The risk: SHOULD A CRACK DEVELOP, FUEL VAPOR CAN ESCAPE FROM THETANK WHEN THE TANK IS FULL, AND A SMALL AMOUNT OF FUEL CAN LEAK FROM THE CRACK.FUEL LEAKS CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
The remedy: INSTALL A NEW FUEL PUMP SENDING ASSEMBLY.
FORD MOTOR COMPANYView on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA94002ClosedEngineering Analysis

FUEL PUMP WIRING SHORTAGE

Opened Jan 28, 1994
Closed Jan 31, 1995

There is no summary currently available

VEHICLE SPEED CONTROL:LINKAGES

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 60
Fuel system
Filed Jun 26, 2019

TL* THE CONTACT OWNS A 1991 MERCURY TRACER. AFTER THE VEHICLE WAS FILLED WITH FUEL AND PARKED IN THE GARAGE, THE CONTACT SMELLED A FUEL ODOR AND NOTICED FUEL LEAKING ONTO THE GARAGE FLOOR. ALL AMERICAN FORD (3306 BRIDGE AVE, POINT PLEASANT, NJ 08742, (732) 451-3582) WAS CONTACTED AND STATED THAT THE VEHICLE WAS TOO OLD AND THEY DID NOT HAVE PARTS. THE VEHICLE WAS THEN TAKEN TO ALL AMERICAN MAZDA (575 BURNT TAVERN RD, BRICK TOWNSHIP, NJ 08724, (732) 451-6848) WHERE A DIAGNOSTIC AND REPAIR APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.

NHTSA ID
11222731
Incident
Jun 16, 2018
Mileage
160,000 mi
Fuel system
Filed Aug 22, 2005
Fire reported

(1) SHOULDER BELT WOULD NOT MOVE TO DRIVING POSITION, COOLANT FAN WOULD NOT RUN WHEN NEEDED WITH ENGINE RUNNING ONLY WHEN THE IGNITION WAS TURNED OFF, OIL LIGHT STAYED ON AND ALTERNATELY FLASHED WITH THE RIGHT TURN SIGNAL INDICATOR. (2) A SHORTING CONNECTOR TO THE FUEL PUMP BURNED THE WIRE BUNDLE TO THE FUEL PUMP IN THE TANK. IT ALSO BURNED WIRES BEHIND THE FUSE BLOCK AND UNDER THE DASH!!! (3) THE CONNECTOR, HARNESS UPDATE, FUEL PUMP/PUMP ASSEMBLY, LOCK RING, WERE REPLACED, BURNED WIRES WERE REPLACED BEHIND THE FUSE BLOCK. THE CAR CANNOT BE DRIVEN BECAUSE THERE ARE MORE BURNED WIRES TO REPAIR UNDER THE DASH. UPDATED01/09/06. *JB

NHTSA ID
10133689
Incident
Jul 5, 2004
Mileage
78,768 mi
Electrical
Filed Jun 17, 2003

I HAD TO REPLACE TWO IGNITION SWITCHES ON MY 1991 MERCURY 1.9 TRACER TO THE TUNE OF $360.00. THE FIRST ONE THEY INSTALLED, THE TUMBLERS FELL APART AFTER ONE DAY, I HAD TO BE TOWED BACK TO THE MECHANIC TO INSTALL A SECOND IGNITION SWITCH. I WAS INFORMED THAT FORD HAD A RECALL ON TRACER IGNITION SWITCHES. HOW DO I RECOVER MY EXPENSE? *JB

NHTSA ID
10023232
Incident
Aug 8, 2002
Fuel system
Filed Sep 10, 2002

THERE WAS A FATIGUE FRACTURE IN FUEL TANK AND FUEL WAS LEAKING. CONTACTED DEALER, AND THE DEALER STATED THAT VEHICLE WAS NOT INCLUDED IN RECALL.*AK

NHTSA ID
8018279
Incident
Sep 2, 2002
Driver assistance
Filed Jan 23, 2002

CAR WILL NOT REMAIN AT SPEED FOR MORE THAN 25 SECONDS. *AK

NHTSA ID
757220
Body & structureEngineFuel system+3 more
Filed Nov 16, 2001

VEHICLE WILL LEAK 2 QUARTS OF OIL A WEEK, THERE IS ALSO A STRONG GAS SMELL INSIDE OF VEHICLE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK CONSUMER STATES WHEN DRIVING OVER BUMPS, THE MUFFLER BANGS AGAINST THE FLOOR, WHEN STEPPING ON THE GAS TO GET SOME SPEED, BLACK SMOKE COMES OUT OF EXHAUST PIPE, WHEN FILLING FUEL TANK, FUEL POURS OUT. VALVE COVER IS LEAKING OIL. DASH LIGHTS DID NOT WORK. STRUTS FOR THE TAILGATE DO NOT HOLD THE TAILGATE. THIRD BRAKE LIGHT IS INOPERATIVE, ALSO DIMMER SWITCH WAS REPLACED. WHILE DRIVING, VEHICLE PULLS TO THE RIGHT, RPM GAUGE DOES NOT WORK. CONSUMER WANTS MANUFACTURER TO TAKE VEHICLE BACK. *JB

NHTSA ID
899196
Incident
Nov 1, 2001
Fuel system
Filed Aug 17, 2001

CONSUMER SMELLS FUEL INSIDE VEHICLE, THERE IS A RECALL, BUT THIS VEHICLE IS NOT AFFECTED DUE TO VIN. *AK

NHTSA ID
894606
Incident
Aug 1, 2001
Transmission
Filed Apr 23, 2001

CONSUMER WAS TRAVELING ABOUT 40 MPH ON A MAIN STREET AND CLUTCH PEDAL FELL OFF ON HIS LEG, AND VEHICLE WENT OUT OF CONTROL. BUT HE WAS ABLE TO BRING VEHICLE TO COMPLETE STOP. ARM OF CLUTCH WAS VERY SMALL. DEALERSHIP WAS AWARE OF PROBLEM.*AK THE CONSUMER STATES THAT THIS CASE SHOULD INVESTIGATED. *YH

NHTSA ID
886501
Incident
Apr 21, 2001

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

01194

ELECTRICAL SYSTEM

THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT

01156

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC

01157

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC

14993

SUSPENSION:REAR

SOME VEHICLES PRODUCED THROUGH JULY 1999 MAY EXHIBIT REAR SUSPENSION SPRING FAILURE WITH NO RESULTING OPERATIONAL CONCERN. *TT

00187

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

SUBJECT PERTAINING TO REVISED DOOR LATCH SWITCH SERVICE PROCEDURE. *JB

00124

SEAT BELTS

THIS BULLETIN PROVIDES REVISED PASSIVE RESTRAINT SYSTEM INFORMATION CONTAINED IN THE WORKSHOP MANUAL AND THE ELECTRICAL AND VACCUM TROUBLESHOOTING MANUAL (EVTM). *TT

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Mercury Tracer by model year
YearComplaintsRecallsInvestigationsIssue Index
2003010—
2002010—
2001010—
2000210—
1999201155.0
1998441145.5
19971422262.7
1996120044.3
1995963152.8
1994651053.1
1993621152.6
1992242161.5
1991Viewing603159.2
1990200—
1989161046.5
1988213161.3
1987010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.