RoadVitals

2003 Mitsubishi Montero

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
39
Latest Jun 29, 2016
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Sep 1, 2004
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
5
4 injuries, 0 deaths reported

Overview

Our database contains 39 NHTSA owner-reported complaints for the 2003 Mitsubishi Montero, most frequently naming the brakes, fuel system and electrical categories. 2 safety recalls have been issued covering this model year; and 49 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes1122.0%
  • Fuel system612.0%
  • Electrical48.0%
  • Powertrain (other)48.0%
  • Airbags36.0%
  • Engine36.0%
  • Other / unspecified36.0%
  • Suspension36.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
04V428000

EQUIPMENT:OTHER:LABELS

Sep 1, 2004
100,432 units potentially affected
The defect: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
The risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
The remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
MITSUBISHI CARIBBEANView on NHTSA.gov
04V319000

FUEL SYSTEM, GASOLINE:STORAGE

Jul 6, 2004
44,214 units potentially affected
The defect: ON CERTAIN SPORT UTILITY VEHICLES, WHEN THE FUEL TANK IS FULL AND THE VEHICLE IS PARKED FACING FORWARD ON AN UPWARD SLOPE, THE FUEL TANK LEVELING VALVE MAY NOT MAINTAIN PROPER SEALING IN THE EVENT THE FUEL EXPANDS FROM A RISE IN THE AMBIENT TEMPERATURE.
The risk: IF THE FUEL LEVELING VALVE DOES NOT SEAL PROPERLY, FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
The remedy: DEALERS WILL REPLACE THE LEVELING VALVE. THE RECALL BEGAN ON AUGUST 30, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.
MITSUBISHI MOTORS NORTH AMERICA, INC.Manufacturer number SR-04-008View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 39
Engine
Filed Jun 29, 2016

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED WHEN THE VEHICLE WAS PURCHASED FROM THE DEALER. THE CONTACT STATED THAT THE VEHICLE HAD A STRONG HESITATION AS THE FAILURE PROGRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID
10881447
Incident
Aug 12, 2015
Mileage
130,000 mi
Body & structure
Filed Jun 12, 2015

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STARTED TO VEER TO THE LEFT INDEPENDENTLY. THE CONTACT STOPPED ON THE SHOULDER TO CHECK THE TIRE PRESSURE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN PUT THE VEHICLE ON THE LIFT AND DIAGNOSED THAT THE ENTIRE SUB FRAME WAS SEVERELY CORRODED. THE TECHNICIAN STATED THAT THE REPAIRS WOULD HAVE BEEN MORE THAN WHAT THE VEHICLE WAS WORTH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

NHTSA ID
10724898
Incident
May 26, 2015
Mileage
162,000 mi
Brakes
Filed May 8, 2015

A SIREN SOUND CAME ON. MY HUSBAND PROCEEDED TO GET OF THE ROAD. IN HIS ATTEMPT, THE BRAKES BECAME VERY HARD TO PRESS. THE VEHICLE CONTINUED TO ROLL AS THE BRAKES WERE BEING APPLIED. HE THE PULL THE EMERGENCY BRAKES TO BRING THE VEHICLE TO A COMPLETE STOP. AAA WAS CALLED TO TOW THE VEHICLE TO A AUTO SHOP. AFTER A THOROUGH CHECK, THE OWNER (MASTER MECHANIC) DISASSEMBLE THE BRAKING SYSTEM TO CHECK IF THE BOOSTER HAD FAILED, HE STATED THE VEHICLE DID NOT HAVE A BOOSTER. I PICKED THE VEHICLE UP ON FRIDAY, MAY 7 AROUND 4:00PM. AFTER TRAVELING APPROXIMATELY 1 MILE, THE SIREN NOISE CAME BACK ON. WE ARE AWAITING TO HAVE THE TRUCK TOWED AGAIN ON MONDAY. *TR

NHTSA ID
10715411
Incident
May 3, 2015
Mileage
187,000 mi
AirbagsSteering
Filed Dec 4, 2014

THE HORN GOES OFF BY ITSELF THE PADS WHERE STUCK AND IT COST $1000 TO REPAIR SINCE IT NEEDS TO REMOVE THE STEERING AIRBAG,THIS SHOULD BE ON A RECALL.THIS HAS A LOT OF PROBLEMS WHO HAS SAME MODEL ON MITSUBISHI FORUMS FOUND HERE HTTP://MITSUBISHIFORUM.COM/FORUM/MITSUBISHI-MONTERO-MONTERO-SPORT-14/HORN-ACTIVATE-ITSELF-01-MONTERO-LTD-28034/. *TR

NHTSA ID
10662222
Incident
Dec 4, 2014
Mileage
177,000 mi
Brakes
Filed Oct 22, 2014

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING 5 MPH DOWN A SLIGHT INCLINE, THE BRAKE PEDAL FAILED TO RESPOND AND THE VEHICLE WAS SHIFTED TO NEUTRAL IN ORDER TO STOP. THE CONTACT ALSO STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.

NHTSA ID
10649213
Incident
Oct 16, 2014
Mileage
93,000 mi
Powertrain (other)
Filed Aug 11, 2014

TL* THE CONTACT OWNS A 2003 MITSUBISHI MONTERO. THE CONTACT HEARD A LOUD PIERCING SOUND WHEN THE IGNITION WAS STARTED. ALL OF THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 230,000.

NHTSA ID
10621355
Incident
Aug 11, 2014
Mileage
230,000 mi
Brakes
Filed Apr 29, 2014

I WAS DRIVING ON THE FREEWAY, WHEN ALL OF A SUDDEN MY ABS LIGHT CAME ON AND A BUZZER. I THEN WENT TO APPLY THE BRAKES AND STOP BUT THE BRAKE PEDAL WOULD NOT BUDGE. IT WAS LIKE THERE WAS A BRICK UNDER IT. THERE WAS NO WAY OF STOPPING SAFELY. LUCKILY NO ONE WAS IN FRONT OF ME. I HAD TO YOU THE TRANSMISSION TO SHIFT DOWN. PRESSED AS HARD AS I COULD ON BRAKES AND FINALLY STOPPED. I HAVE RESEARCHED THIS ISSUE AND HAVE DISCOVERED IT IS QUITE COMMON. HOW IS IT SAFE FOR A VEHICLE WITH A ANTILOCK BRAKE MALFUNCTION TO TAKE OUT THE BRAKE SYSTEM COMPLETELY? I HAVE CONTACT MITSUBISHI AND THEY SAID THERE IS NO RECALL!! HOW IS THIS POSSIBLE!?! THIS IS VERY UNSAFE I HAVE HAD THE VEHICLE PARKED SINCE THE INCIDENT. I FEEL MITSUBISHI NEEDS TO PAY FOR THIS AND UPGRADE THE BRAKE SYSTEM. I HAVE RESEARCHED THE PRICE AND WOULD COST ME 1700.00 TO HAVE THE SYSTEM REPLACED. WITH NO GUARANTEE OF IT NOT DOING IT AGAIN. *JS

NHTSA ID
10585588
Incident
Oct 16, 2013
Mileage
187,800 mi
Brakes
Filed Dec 19, 2013

I WAS DRIVING, STARTED HEARING OOZING SOUND THEN I APPLIED BRAKES, VERY HARD AND WON'T GO DOWN. THEN I PULLED OVER THE SIDE CURB AND THE CURB STOPPED THE CARD. *TR

NHTSA ID
10556663
Incident
Oct 2, 2013
Mileage
145,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

DEALER LETTER

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.

TSB-23-00-004

STRUCTURE

This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.

TSB-23-00-001

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.

DEALER LETTER

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023.

TSB-22-54-003

EXTERIOR LIGHTING

This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.

TT253

EQUIPMENT

This is a service newsletter (Tech Talk) that was sent out to dealers.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Mitsubishi Montero by model year
YearComplaintsRecallsInvestigationsIssue Index
2006400—
2005100—
2004530—
2003Viewing392048.2
20021113156.5
20011664053.0
2000512051.3
1999402050.8
1998744157.3
1997632051.5
1996272042.5
1995862051.4
1994315048.1
1993143040.6
1992124048.1
1991182153.1
1990231253.9
1989102258.2
1988111—
1987311—
1986412—
1985000—
1984010—
1983000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.