2017 Peterbilt 587

The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE21-015) based on one Vehicle Owner Questionnaire (VOQ) and supporting fleet reports. The reports indicated that the subject quarter fenders were prone to cracking and/or separation.After a comprehensive review of the data related to the quarter fender failures on the subject vehicles, ODI did not identify the existence of a safety-related defect trend. Quarter fender failures resulted in a warranty claim rate less than one percent (<1%) of the total vehicle population. All separations, including those due to tread separations, road hazards, etc., accounted for less than point one percent (<0.1%) of the total vehicle population.ODI discovered that the minimum recommended gap between the top of the quarter fender and the bottom of the trailer was not known or being followed. The optional quarter fenders were supplied by Fontaine Spray Systems (FSS), who recommended a two inch (2) gap. ODI analyzed the claim data using a calculated gap. A calculated gap using the top of the quarter fender flap and assuming the trailer is level with the top of the fifth wheel hitch was necessary, as PACCAR doesn't know specifically what trailer a purchaser will couple to the tractor. It is safe to assume no trailers on the market extend below the upper fifth wheel plate, but many do provide additional clearance over the wheels where the quarter fenders are located. ODI determined that 94 percent of warranty claims and 84 percent of separations violated FSS' recommendation.ODI confirmed that the VOQ vehicle and the fleet report vehicles also violated FSS' recommended gap. In one fleet the gap was negative point three inches (-0.3).PACCAR has updated its vehicle specification process and issued a customer advisory notice to existing owners. In light of the low rate of reported failures and separations, further use of agency resources does not appear to be warranted. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves the right to take further action if warranted by the circumstances.

THE CLIMATE CONTROL MODULE FOR THE CAB, AND THE BUNK KEEP SHORTING OUT. THE FAN SPEED CONTROL LITERALLY MELTS. THE CONTROL STICKS THEN STARTS SMOKING. I HAVE HAD PETERBILT REPLACE IT, BUT IT KEEPS GOING OUT. I'M AFRAID IT'S GOING TO BURN THE TRUCK UP WHILE I'M ASLEEP.

NHTSA ID

11182068

Incident

Feb 22, 2019

Mileage

30,000 mi

This recently published bulletin has been updated to include inspection procedures to assess if a hood is repairable.

Info Only Unnecessary starter replacements can result from customer complaints regarding engine starting issues. A new Starter Troubleshooting Guide has been created to provide a comprehensive list of starting system checks, which should reduce unnecessary starter replacements and associated warranty claims. Engine starting system warranty claims now require a completed Starter Checklist, a Battery Pack Midtronics Report, and a Cable Drop Midtronics Report. Claims filed without these documents may be denied.

7/700 Service Agreement - Letter Only.

Emissions Recall Certain vehicles with PACCAR MX-11 and MX-13 EMY2016 engines with less than 300,000 miles (482,803 km) have been shown, in testing, to exceed regulatory limits for NOx and N2O emissions. This bulletin now applies to both Canadian and U.S. registered vehicles. Software is now available to remedy this emissions non-compliance.

An engine software defect exists in certain vehicles equipped with EMY17 MX-13 and MX-11 engines that pertains to timer action and count calibrations for a time-based diagnostic. This diagnostic action checks fuel pressure and has no negative impact on tailpipe emissions. This soft ware may incorrectly set DTC – P1092.

Fix As Fail – Chassis that were manufactured with certain battery cable routing brackets may experience rubbing or chafing of the battery cables.