1999 Plymouth Voyager Transmission Problems

PURCHASED USED PLYMOUTH IN OCTOBER 2007 WITH 5393 MILES ON THE ODOMETER. REGISTERED AND DROVE IT FROM DECEMBER 3, 2007 TO JAN 2, 2008. NOTICED SIGNIFICANT AMOUNT OF TRANSMISSION FLUID UNDER THE VEHICLE AND FILM OF FLUID ON BACK WINDOW AND HATCH AREA. OBSERVED FLUID PUMPING OUT FROM UNDER THE CAR. MECHANIC TELLS ME THE SOLENOID BLOCK MOST LIKELY HAS FAILED AND WILL NEED TO BE REPLACED. I AM TOLD THIS IS A "COMMON" FAILURE IN LATER MODEL 41TE TRANSMISSIONS.*CN

NHTSA ID

10213482

Incident

Jan 1, 2008

Mileage

53,939 mi

TRANSMISSION IS SHIFTING TERRIBLE!THE BACK DOOR WILL NOT OPEN AT ALL,THE SIDE DOOR WILL NOT OPEN FROM INSIDE. MY LIGHTS FROM THE INSIDE OF VEHICLE GOES ON AND OFF. WHILE DRIVING DOWN THE ROAD THE VAN SHAKES TERRIBLE, IT FEELS LIKE THE MOTOR SHAKES. *TR

NHTSA ID

10210268

Incident

Nov 5, 2007

Mileage

155,000 mi

DT: TRANSMISSION BLEW APART; IT WASN'T LACK OF FLUID OR ANYTHING ELSE, IT JUST BLEW OUT. I CONSUMER PICKED UP PIECES ON THE SIDE OF THE ROAD.*AK

NHTSA ID

10124489

Incident

Jun 5, 2005

Mileage

89,624 mi

WE HAVE THE EXTENDED WARRANTY ON OUR CAR. THE VAN HAS BEEN INTO THE DEALER NUMEROUS TIMES AS RECENTLY AS JUNE OF 2004. AT THAT TIME IT WAS A TRANSMISSION PROBLEM. THIS TIME THE VAN WAS NOT SHIFTING UP IN GEARS IN THE AUTOMATIC TRANSMISSION. WE THOUGHT IT WAS A TRANSMISSION PROBLEM. WE GOT THE VEHICLE TO THE DEALERSHIP. THE NEXT DAY THEY TOLD US IT WAS THE EMISSION SYSTEM,AND COINCIDENTALLY WE WERE 42 MILES OVER THE FACTORY WARRANTY OF 80,000 FOR THE EMISSION SYSTEM. WE THEN ASKED OUR EXTENDED WARRANTY COMPANY AND THEY ARE ALSO HEDGING. WE CALLED CHRYSLER AND A PERSON BY THE NAME OF "JOE" ANSWERED THE PHONE WHO WAS VERY RUDE AND WHEN WE ASKED TO SPEAK TO A SUPERVISOR HE REPLIED HE "WAS IT. " AND WHEN WE ASKED FOR HIS LAST NAME HE REFUSED. WHAT WE CANNOT UNDERSTAND IS IF THE EMISSION SYSTEM AND THE CATALYTIC CONVERTER IS INVOLVED, WHY THEN WOULD IT NOT BE COVERED? IF THIS SYSTEM IS FAILING THEN THE ENGINE CANNOT RUN RIGHT. AND IF WE WERE ONLY 42 MILES OVER THE 80,000 CHRYSLER SHOULD HONOR IT SINCE WE JUST HAD THE VEHICLE IN THEIR FOR THE TRANSMISSION IN JUNE OR JULY. OUR VAN HAS BEEN ALMOST A LEMON FROM THE TIME WE BOUGHT IT, AND WE HAVE GONE BACK TO THE SAME DEALER WHERE WE BOUGHT THE CAR EACH AND EVERY TIME. WEST COVINA CHYRSLER JEEP. IT IS ON RECORD THERE HOW MANY PROBLEMS WE HAVE HAD. WE ARE VERY UPSET WITH CHRYSLER NOT STEPPING UP TO THE PLATE AND COVERING THIS $1600 PROBLEM!!*AK

NHTSA ID

10098496

Incident

Nov 3, 2004

Mileage

80,000 mi

WHILE DRIVING AT ANY SPEED AND WHEN THE BRAKES WERE DEPRESSED THERE WAS A CLANKING NOISE. CONSUMER EXAMINED THE VEHICLE, AND FOUND THAT HE NOISE WAS EVIDENT WHEN BRAKING. CONSUMER CLAIMED THAT THE NOISE WAS COMING FROM THE TRANSMISSION.*AK A PIN IN THE TRANSMISSION FELL OUT OF PLACE AND WAS HITTING THE INSIDE OF THE TRANSMISSION HOUSING. *JB

NHTSA ID

10081643

Incident

Jul 4, 2004

Mileage

67,000 mi

PROBLEMS WITH TRANSMISSION ON 1999 PLYMOUTH VOYAGER.*MR THE TRANSMISSION WAS REPLACED THREE TIMES IN LESS THAN 100,000 MILES. *JB

NHTSA ID

10081834

Incident

Apr 21, 2001

Mileage

45,972 mi

VEHICLE NOT WANTING TO SWITCH GEARS. IT GOES VERY SLOW UNTIL FINALLY IT SWITCHES OVER. THE OIL WAS LEAKING OUT OF THE VAN. THE OIL LEAK WAS REPAIRED. AS FOR THE TRANSMISSION, IT ALL STARTED OFF WHEN IT WOULD SLOW BY ITSELF. THEN IT GRADUALLY GOT WORSE. ON 02-12-03 I HAD TAKEN IT IN TO GET CHECKED FOR A OIL LEAK AND THE PROBLEM WITH THE GEARS NOT SHIFTING. I WAS TOLD I NEEDED TRANSMISSION SERVICE, TO REPLACE THE VALVE COVER GASKET, AND TO REPLACE THE TRANSMISSION OUTPUT SHAFT SEAL. I DID THE REPAIR THAT WAS SUPPOSED TO FIX THE PROBLEM BUT OF COURSE IT DIDN'T. I TOOK IT IN TO THE DEALER AND THEY FOUND NOTHING WRONG WITH THE GEARS. BUT SAID A FUEL INJECTION CLEANING, THROTTLE BODY CLEANING, AND A TUNE UP WOULD FIX THE PROBLEM. THIS WAS DONE ON MARCH 26, 2003. THEY REPLACED THE THROTTLE BODY GASKET AND SPARK PLUGS. THEY DID FIND A LEAK IN THE HEAD GASKET. THEY HAD TO REPLACE CYLINDER HEAD GASKET, WATER PUMP AND TIMING BELT. IN NOVEMBER OF 2000 THE FRONT PUMP SEAL WAS LEAKING, PAN GASKET LEAKING, SIDE COVER LEAKING, DIFFERENTIAL COVER LEAKING, AND REAR MAIN OIL SEAL LEAKING. THEY REMOVED THE TRANSAXLE, REMOVED AND REPLACED THE REAR MAIN SEAL. A FEW MONTHS AGO THE ENGINE LIGHT STARTED COMING ON WHEN GEARS WOULDN'T SHIFT. AND IT GOT WORSE EVERYDAY. NOW THE ENGINE LIGHT IS ON ALL THE TIME. I TOOK IT INTO AAMCO ON 04-23-2004 TO GET IT CHECKED OUT. THEY SAID IT WASN'T SAFE TO DRIVE SO THEY HAD TO TOW IT TO THEIR STATION. IT PASSED ALL THE EQUIPMENT TESTING AND WAS TOLD IT MAY JUST BE THE SPARK PLUGS. SO I REPLACED THE SPARK PLUGS THAT DAY. IT RAN WELL FOR A LITTLE WHILE. THEN IT STARTED AGAIN. I HAD TO STOP DRIVING MY VEHICLE BECAUSE IT IS A POTENTIAL DANGER TO MY FAMILY. IT WOULD GO VERY VERY SLOW WHEN I WAS TRYING TO CROSS THE ROAD. AND WITH ON COMING VEHICLES ON BOTH SIDES WE COULD EASILY GET INTO A MAJOR COLLISION. I HAVE TRIED TO TALK TO THE CHRYSLER BUT THEY REFUSED TO HELP ME. AND AT THIS POINT I STILL DON'T KNOW WHAT IS WRONG WITH IT. *JB

NHTSA ID

10078855

Incident

Jan 6, 2003

Mileage

69,600 mi

WHILE DRIVING 65 MPH TRANSMISSION EXPLODED. AS A RESULT, WHEELS LOCKED WITHOUT WARNING. NO IMPACT REPORTED. *AK

NHTSA ID

10061066

Incident

Feb 29, 2004

Mileage

84,000 mi

VEHICLE WAS EQUIPPED WITH A DEFECTIVE TRANSMISSION. *PH THE MANUFACTURER DID NOT WANT TO ASSIST THE CONSUMER WITH THE REPAIRS. *TT *JB

NHTSA ID

10057257

Mileage

73,955 mi

THE TRANSMISSION CRACKED, WHICH CAUSED FLUID TO LEAK. *JB THE REPAIR DEALER STATED THAT THE TRANSMISSION CASE HOUSING WAS CRACKED AND CAUSED LOST OF FLUID AND PREMATURE FAILURE OF THE TRANSAXLE ASSEMBLY. THIS OCCURRED DUE TO POOR DESIGN AND WAS A COMMON PROBLEM IN THESE VEHICLES. *SC *JB

NHTSA ID

10009137

Incident

Feb 18, 2003

Mileage

56,220 mi

TRANSMISSION WONT CHANGE GEAR PROPERLY. THE TECHNICIAN REPLACED TWO SENSORS. THE ELECTRICAL SYSTEM ALSO DIDN'T WORK PROPERLY. PLEASE PROVIDE FURTHER INFORMATION. *NLM

NHTSA ID

10048468

Incident

Nov 21, 2003

Mileage

53,000 mi

WE OWN A 1999 PLYMOUTH GRAND VOYAGER. AT APPROXIMATELY 69,000 MILES WHILE DRIVING APPROXIMATELY 35 MPH THE TRANSMISSION LITERALLY BLEW UP AND THE VEHICLE CAME TO A SUDDEN STOP AND NEARLY LEFT THE ROAD. A PART HAD BROKEN OFF FROM THE INSIDE OF THE DIFFERENTIAL AND BLEW A 6 INCH BY 3 INCH HOLE THROUGH THE CASING BETWEEN THE DIFFERENTIAL AND TRANSMISSION. THE CASING DEBRIS THAT BLEW INTO THE TRANSMISSION COMPLETELY MANGLED THE TRANSMISSION. NO ONE WAS INJURED ONLY BECAUSE OF THE SLOW SPEED OF THE CAR AT THE TIME. WE HAVE PHOTOGRAPHS OF THE TRANSMISSION AND THE MECHANIC'S REPORT. *JB

NHTSA ID

10023721

Incident

Mar 20, 2003

Mileage

69,000 mi

PROBLEMS WITH 1999 PLYMOUTH VOYAGER EXPRESSO TRANSMISSION. *MR THE PIN CAME OUT THE DIFFERENTIAL AND IT CRACKED THE CASE. *PH *JB

NHTSA ID

10024230

Mileage

52,000 mi

MY TRANSMISSION HAD A HUGE BANG AND COMPLETELY SHUT DOWN. THE MECHANIC SAID THAT THE PIN BLEW FROM THE INSIDE OUT. THIS IS A COMMON OCCURENCE WITH THESE MINIVANS, BUT CHRYSTLER IS NOT HELPFUL AT ALL. I BELIEVE THAT THIS IS A FACTORY DEFECT.

NHTSA ID

10020788

Incident

Apr 27, 2003

Mileage

31,500 mi

WHILE DRIVING THE VEHICLE CONSTANTLY LOST POWER AND FELT LIKE IT WAS GOING TO STALL. THE TRANSMISSION ALSO JERKED EXCESSIVELY WHEN CHANGING GEARS. *NLM

NHTSA ID

10020081

THE TRANSMISSION FAILED, WHILE DRIVING.*JB

NHTSA ID

10007306

Incident

Dec 20, 2002

Mileage

94,000 mi

THE VEHICLE EXPERIENCED A TRANSMISSION LEAK, AND A BROKEN AIR CONDITION CLUTCH.*JB

NHTSA ID

10004576

1999 PLYMOUTH VOYAGER SE PURCHASED NEW IN 99. 82000 MILES @ 90% HIGHWAY. TRANSMISSION STARTED SLIPPING BADLY. REPAIR COST $2000. CONTACT AT CHRYSLER ANDREW MILLER NO HELP.QUOTE FROM LOCAL MECHANIC " THESE ARE KNOW FOR TORQUE CONVERTERS GOING BAD." FROM THE LOOKS OF THE COMPLAINTS ON THE NET THAT IS TRUE. NO TRANSMISSION SHOULD HAVE TO BE REBUILT THIS EARLY. WE HAVE HAD ALL SCHEDULED AND RECCOMENDED TRANSMISSION SERVICES PERFORMED PER OWNERS MANUEL. DEFECTIVE PRODUCT WITHOUT ANY HELP FROM MANUFATURER. ALSO HAD TO REPLACE SHOCKS AND STRUTS FOR $500 MRCH 2002 WITH ONLY 65K MILE.DEFECTIVE. HAD STRUTS REPLACED ONCE BEFORE UNDER WARRANTY!!

NHTSA ID

10002640

Incident

Jan 1, 2003

Mileage

81,000 mi

WHILE COMING TO A STOP THE VAN MADE A LOUD NOISE, JARRED AS THOUGH HITTING A LARGE HOLE THEN STALLED. THE VAN COULD BE RESTARTED BUT WOULD NOT ENGAGE WHEN PUT INTO GEAR. THE DIFFERENTIAL PIN CAME OUT OF THE CARRIER ASSEMBLY AND BROKE TRANSAXLE CASE IN THREE PLACES. THE REPAIR TOOK 2 1/2 WEEKS. DT

NHTSA ID

769027

Incident

Oct 2, 2002

THE VEHICLES TRANSMISSION FAILED AND WAS REPLACED. CONSUMER HAS CONTINUES PROBLEM WITH THIS VEHICLE. IN FEBRUARY 2001 THE VEHICLE BROKE DOWN AGAIN. *YH

NHTSA ID

568029

LEFT VEHICLE IN PARK WITH AIR CONDITIONER RUNNING, AND ABOUT 20 MINUTES LATER VAN SUDDENLY TOOK OFF AND HIT A HOUSE. SHIFTER WAS SET IN PARK, BUT INDICATOR SET IN REVERSE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8017840

Incident

Aug 18, 2002

I HAD JUST RETURNED FROM A TRIP TO BRANSON, MO. WHEN I GOT UP THE NEXT MORNING TO GO TO WORK THE CARD WOULD NOT SHIFT GEARS. THEREFORE, I COULD ONLY GO 10 MPH. I TOOK THE CAR THE NEXT DAY TO MY DEALERSHIP FOR SERVICE EXPECTING A FREE REPLACEMENT SINCE JUST SIX MONTHS BEFORE, I HAD HAD THE SAME PROBLEM. THE MILEAGE THE FIRST TIME WAS 49384 AND IT OCCURRED ON DEC 10, 2001. THE SERVICE DEALERSHIP IS FRONTIER MOTOR COMPANY AT PO BOX 430 IN EL RENO, OK. PHONE IS 405-262-6433. I HAVE ALWAYS TAKEN MY CAR TO THEM FOR SERVICE AND MAINTENANCE. THEY SAY THAT THE PART IS THE SENSOR TRANSMISSION INPUT/OUTPUT SPEED (PART #4800879) AT A COST OF 146.16 THE FIRST TIME AND 114.42 THIS SECOND TIME. AFTER DISCUSSING WITH THE DEALERSHIP THAT THEY SHOULD REPLACE IT FREE BECAUSE OBVIOUSLY THE FIRST REPLACEMENT WAS DEFECTIVE, THE SERVICE DEPARTMENT INFORMED ME THAT THE PART ONLY CARRIED A 12 MONTH OR 12,000 MILE WARRANTY. I WAS 408 MILES OVER. I BELIEVE PLYMOUTH HAS A PROBLEM WITH THIS PART.*AK

NHTSA ID

764526

Incident

Jul 16, 2002

TRANSMISSION FAILED TWICE, NOW HAS LEAK ON LEFT SIDE HEAD GASKET. *AK

NHTSA ID

760908

Incident

Apr 12, 2002

THE TRANSMISSIONS DODGE IS PRODUCING WILL SUDDENLY KICK OUT OF GEAR WITHOUT WARNING(NO NOISE, VIBRATION, ETC...). THIS I S EXACTLY WHAT HAPPENNED IN MY CASE. TRAVELING IN THE LEFT LANE OF THE INTERSTATE@ 70MPH TRANSMISSION SUDDENLY BEGAN TO COAST GREATLY REDUCING MY SPEED. I THEN HAD TO TRY TO CROSS TRAFFIC TO GET TO THE EMERGENCY LANE. THAT IS WHEN MY FAMILY HAS TO WALK UP THE INTERSTATE TO FIND A TOW TRUCK. CHRYSLER HAS OVER 10 YEARS OF TRANS. TROUBLE AND THEY DONT SEEM TO BE DOING ANYTHING ABOUT IT.*AK

NHTSA ID

755731

Incident

Nov 1, 2001

WHEN VEHICLE IS BEING DRIVEN AT HIGHWAY SPEEDS A MALFUNCTION OCCURS WITHIN TRANSMISSION OUTPUT SPEED SENSOR, CAUSING VEHICLE TO GO INTO LOW GEAR, NEARLY RESULTING IN A COLLISION. *AK THE TRANSMISSION OUTPUT SPEED SENSOR FAILED AT HIGHWAY SPEED, RESULTING IN A VIOLENT, SUDDEN, AND UNEXPECTED DECELERATION DUE TO TRANSMISSION DOWNSHIFT. *SLC

NHTSA ID

891210

Incident

Jun 23, 2001