2020 RAM 1500 Owner Complaints

The power steering goes out at random times after the steering warning light comes on. This usually happens after the secondary cooling system kicks in. I have had it looked at by one mechanic who thinks it's the rack and pinion portion of the steering, he was unable to find a replacement part. It is a danger when it happens especially on a curve, it will cause the steering to try and go straight which leads to the truck crossing lanes of traffic which could result in an accident. This all began in May of 2026 when the weather started warming up. Did not have this problem the first 6 months of ownership during the cooler weather of winter and spring. This problem happens almost daily especially during the heat of the day.

NHTSA ID

11756546

Incident

May 11, 2026

The contact owns a 2020 Ram Promaster 1500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention); however, the part to do the recall repair was not yet available. Three dealers, including Cross Jeep Chrysler (1501 Gardiner Ln, Louisville, KY 40218), were contacted. The dealers informed the contact that parts were not yet available and there was no date for the availability for the parts for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure.

NHTSA ID

11755961

Incident

Aug 10, 2026

Loud whining sound coming from engine. The dealership confirmed a MGU Alternator failure.

NHTSA ID

11755142

Incident

Aug 3, 2026

MGU Failed, 48v code P0DAF had early signs of premature failure. when on the highway, vehicle shut off completely, no power what so ever. Couldn't steer correctly and vehicle was going highway speeds (approximately 70mph) dealer has confirmed the issue being there MGU gone bad, but I have records of water intrusion multiple times on the rear seats, headliner & back glass (XL1) and water intrusion can cause BPCM to go bad along with the MGU to go bad. they first appeared on or around December 2025, most likely way before that but just never noticed it. check engine light came on and showed a code for the BPCM going bad and then I had the CHMSL replaced 3 times under warranty & then the 4th visit they did they urethane warranty superseded the XL1 and even after that fix, there water leak still occurred and dealership wouldn't fix it they stated Stellantis denied the back glass replacement and further repairs because im out of warranty but the warranty expires 8 Years/150,000 miles and my vehicle is only 6 years old and sitting at 118,350 miles. but the entire problem with water intrusion most likely started anywhere from 60-70,000 miles ago. even when I purchased the vehicle at 39,801 miles I noticed the water stains on the headliner but was advised the CHMSL caused that so it was fixed so technically the CHMSL was replaced roughly 4 times along with the original making it a total of 5 CHSML. so my issue is that its highly possible that the water intrusion that was never fixed for thousands of miles and many months leaked into the rear seats near the 48V Battery pack and eventually started shorting and lead to the MGU going bad. so this all could've been avoided if dealership fixed the water leak many many visits ago. along with the MGU could've been replaced under the major emissions comp warranty way. before that ever expired when it showed signs of premature wear like DTC codes popping up at 100,000 miles and even many more visits prior to December.

NHTSA ID

11755103

Incident

Jul 26, 2026

Fuel pump failure and fortunately it failed when I had stopped to get fuel.

NHTSA ID

11754842

Incident

Jun 20, 2026

The contact owns a 2020 Ram 1500. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle stalled with the check engine warning light illuminated. The contact stated that the engine seized. While attempting to start the vehicle, the vehicle failed to start. The contact stated that upon inspecting the vehicle, there were metal shavings inside the engine oil. The vehicle was towed to the residence. The vehicle was later towed to the dealer, where it was diagnosed with a high-pressure fuel pump failure. The contact was informed that metal shavings were found throughout the fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline) in January 2025. The contact was informed that the repair was not covered under the recall. The manufacturer was made aware of the failure, and a case was filed. The contact was awarded a goodwill discount of sixty percent off the cost of the repair. The failure mileage was approximately 99,051.

NHTSA ID

11753821

Incident

Jul 23, 2026

Mileage

99,051 mi

The contact owns a 2020 Ram 1500. The contact stated that there was water leaking from the rear window of the vehicle. The contact referenced Technical Service Bulletin: 23-098-23, detailing a crack in the rear window near the third brake light that could allow water to enter the vehicle on the left and right sides. The contact confirmed that the vehicle had experienced leaks on both sides. The vehicle was taken to a dealer to be repaired under the TSB; however, the dealer declined to repair the vehicle. The contact stated that the vehicle met the mileage requirements, but the dealer stated that the vehicle was not included in the TSB. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 115,000.

NHTSA ID

11752735

Incident

Jun 1, 2026

Mileage

115,000 mi

The contact owns a 2020 Ram 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who replaced an unknown part, but the failure persisted. The vehicle was then taken to the dealer, and it was determined that the intake manifold needed to be replaced; however, the part was on backorder. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 104,000.

NHTSA ID

11751506

Incident

Aug 1, 2025

Mileage

104,000 mi

The tail lights keep going out on both sides. The tail light harness does not fit the female adapter properly. You have to hold it pushed in to get the light to come on but when you let go it turns back off. I have already replaced the sockets with Mopar OEM parts and am still having the problem. After researching I found that this is a common issue with this vehicle. It is a safety concern because without tail lights keep other drivers may not be able to see my vehicle at night or when I am braking.

NHTSA ID

11751007

Incident

Apr 1, 2026

I was attempting to turn around in my driveway when the steering locked up and I could not control the steering. If I had been driving on the road instead of in my driveway I could have crashed into something or someone, potentially causing severe injury or death to myself or others. This was a horrifying experience in my driveway, let alone on the road! I had my truck towed to the repair shop, where they determined that the power steering rack failed. It cracked completely in half. Attached please find the photos that the repair shop provided, along with my repair invoice. There should be a recall for this before people get killed!

NHTSA ID

11750875

Incident

Jun 26, 2026

When filling the truck full, fuel will occasionally spill out onto myself and the ground. The fuel also leaks into the cap canister, purge valve and dumps fuel into the manifold as well as leaking on the ground. When driving the entire cab reeks of fuel. This is a known issue by Dodge and they have a TSB out on it. My vehicle could become a fireball at any time. Dealer replaced my evap canister but didn’t even give me the TSB which wound up costing me more money once my mechanic found the problem. This is a 3,000.00 + repair for something that can cause a severe fire.

NHTSA ID

11750707

Incident

May 15, 2026

I was attempting to turn around in my driveway to go someplace when the steering locked up and I could not control the steering. It stopped working. If I had been driving on the road, instead of driving in my driveway, I could have crashed into something or someone, potentially causing severe injury or death to myself or others. This was a horrifying experience in the driveway, let alone on the road! I had my truck towed to the repair shop where they determined that the Electronic Power Steering Rack failed. It cracked completely in half! I will attach the photos the shop provided. There should be a recall on this before someone gets killed. I have several friends and neighbors who own the same make and model truck and I informed them of our situation and recommended that they have their trucks checked out before tragedy strikes them or their families.

NHTSA ID

11750624

Incident

Jun 26, 2026

I am having DEF related issues with my 2020 Ram 1500 ecodiesel that will ultimately cause the vehicle to no longer operate. Ram has an extended warranty for my exact problem but I am being told that my vehicle doesn’t meet the requirements. My vehicle is under the required year and mileage but I’m being told that it doesn’t apply.

NHTSA ID

11749914

Incident

Jul 11, 2026

While driving down the highway the vehicle radiator fan kicked on high (could hear it from the cab) then my electronic power steering went out seconds after receiving the “Service Electronic Power Steering” dash light. Since then it is intermittent, EPS returns and then goes out again, each time accompanied by the high fan noise.

NHTSA ID

11748558

Incident

Jul 2, 2026

The electronic gear selector on my 2020 Ram 1500 intermittently displays a "Shift to Park" warning while the vehicle is in motion, specifically during downshifting or braking. Each occurrence is accompanied by a physical jerk or lurch, consistent with the vehicle momentarily engaging an unintended gear. The warning clears without driver input. These events occur during active deceleration and represent a loss of predictable vehicle behavior, creating a serious risk of rear-end collision or loss of control. The problem has not been resolved. A dealership inspected the vehicle and recommended a Transmission Control Module (TCM) software update referencing TSB 21-019-24, to be performed at the owner's expense. No root-cause diagnosis was provided. The underlying hardware cause, most likely the gear selector position sensor or transmission range sensor, was not confirmed or ruled out. The dealer is insisting the owner pay for the software update without establishing whether the bulletin covers the reported symptom or whether the vehicle VIN falls within its scope. No warning lamps preceded the first occurrence. The symptom appeared without prior indication and has recurred across multiple drive cycles.

NHTSA ID

11747945

Incident

Jun 30, 2026

Both Driver and Passenger Visor arms have dis-engaged and no longer work to provide shielding from blinding sun. They just hang from thier broken arms and it happened shortly after having purchased this vehicle from a used car dealer, (Kearny Mesa) and they were unable to address since it was not a recall. Obviously they would repair it for $$$$ Did some research and apparently this is a common issue with this vehicle.

NHTSA ID

11747707

Incident

Jan 8, 2025

On June 26, 2026 my 2020 Ram 1500 Big Horn truck lost its steering, with no prior warning. This could have resulted in a catastrophic, tragic accident had I been out on the road but it happened as I was attempting to pull out of my driveway. I could have been killed. Other people potentially could have been injured or killed if this happened while driving on the road. I had the truck towed to a local repair shop, who looked at the truck and indicated that due to the type of problem it had to be serviced by a Ram certified repair shop. We then had to truck towed to Quirk, a certified repair service center. Upon their inspection they discovered that the POWER STEERING RACK broke in half! They said that this is unusual for a vehicle with such low mileage of 29,779 miles and that this is very dangerous. The cost to repair my truck is $4,500 and there is a long wait time for the part because of a back order. Why, I wonder is there a back order? Is this a very serious safety issue that other Ram truck owners are dealing with as well?

NHTSA ID

11747603

Incident

Jun 26, 2026

The steering system electric power steering rack failed on my 2020 Ram truck. We were unable to steer the truck and could have been in a horrible accident. This was a very dangerous situation. For some reason my truck was not included in the recall that was issued for the 2020 ram truck and I now face an astronomical repair bill in excess of $5000 according to the dealership repair shop. The part is $4500 and I have no idea how much the labor is going to amount to. This is an extreme hardship, not to mention that my family and I could have been killed and others to, if this happened on the highway. There were no warning lights indicating a problem prior to the incident.

NHTSA ID

11747305

Incident

Jun 26, 2026

High Pressure Fuel Pump failed. Pump failure can cause car to stop when not intended. Problem confirmed by an independent service center. Component not inspected by others. No warning lights or messages prior to the failure. The High Pressure Fuel Pump was replaced 4/30/2024 as part on 'Safety Recall Z96 - High Pressure Fuel Pump - Replace High Pressure Fuel Pump' by Merrick Dodge 3614 Sunrise Highway, Wantagh NY 11793.

NHTSA ID

11747180

Incident

Jun 27, 2026

Steering wheel locked up. I was in the driveway when this occurred but if I was driving on the road my vehicle could have potentially crashed into something and cause harm to myself or someone else, since I could not steer the vehicle. I had the truck towed to VIP Tire &Service and they checked the truck and determined through diagnosis, that my problem is with the circuit card assembly for the Electric Power Steering gears and that only Dodge Ram service companies can fix the problem and to bring my truck to a Chrysler Dodge service center. So I had my truck towed to Quirk Chrysler in Marshfield. They said that my VIN was not in the recall and that it would not be covered. It obviously should be included in this recall, since this is precisely what my problem is. There were no warning lights indicating a problem. Please add my VIN number to this recall so it will be covered as it should be.

NHTSA ID

11746773

Incident

Jun 26, 2026

Back window was leaking into the seatbelt. I did take it in for service back in 2022 back window was replaced along with top liner. And it has still continued to leak and just now recently I’ve noticed the water must be going into the cabin mmbecause my screen has what looks to be water in it and continues to leak anytime it rains or I go in the car was and the water goes to the seatbelt I’ll attach photos it’s not letting me attach videos

NHTSA ID

11746723

Incident

Jun 5, 2022

I PCSd from Springfield, MO to Fort Bliss Texas. I bought the truck [XXX]. I make it to TX. Driving the first Saturday in TX on [XXX] it just shuts down and put me in a very scary situation. I was stuck in the middle of the high way. It does not drive. The Etorque/generator is bad and is now on order from my local Dodge dealership. It literally shut down my truck and will not start, run, nothing. It’s been in the shop for 40 days with a no ETA on the part ordered. This should definitely be a safety recall as it just stalled me on the highway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11746568

Incident

May 16, 2026

While driving and making a turn at a busy, high-traffic intersection, a red steering service warning message/light suddenly appeared on the dashboard. Immediately after the warning appeared, the steering became extremely difficult to operate and felt as though it had locked or jammed. I had to use significant force to turn the steering wheel in order to complete the turn. At the same time, a box truck was approaching the intersection at a high rate of speed. Because I was struggling to steer the vehicle, I was unable to maneuver normally and narrowly avoided a collision. Fortunately, the driver of the box truck was able to stop in time. Had the truck not stopped, a serious accident resulting in severe injuries or fatalities could have occurred. This sudden loss of steering assistance happened without warning and created an extremely dangerous situation. A steering system should not fail while a vehicle is in motion, especially in traffic. The failure significantly reduced my ability to control the vehicle and placed me and other motorists at risk. I believe this may be a safety-related defect and request that NHTSA investigate similar complaints involving steering system failures in 2020 Ram 1500 Limited vehicles. Such failures have the potential to cause catastrophic accidents and should be addressed immediately.

NHTSA ID

11746205

Incident

Jun 23, 2026

The radion frequency module has gone bad in my truck. I assume this is due to the rear window leak that is known on these trucks. My rear window was replaced earlier this year do to damage. However, as I search the internet this issue with the radion frequency module is greatly reported and I do not understand why FCA/Mopar have not issue a recall notice on this. Instead owners are having to come out of pocket over $1000 to repair something that everyone knows is an issue.

NHTSA ID

11745239

Incident

Jun 15, 2026

At 60mph the vehie suddenly did a 180 and went backwards down the road. Fortunately it was a straight stretch and no oncoming traffic. Rear axle sized up, drive shaft shrown, and rear shaft froze resulting in equivalent of rear brakes onky thus the 180. Rear axle lost all lubrication and this is very similar to existing safety recall on other Ram models but not this one.

NHTSA ID

11744184

Incident

Dec 31, 2025