2000 Saab 9-3

ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.

The driver's side, side air bag deployed spontaneously. There was no apparent reason or cause, ie no side impact of any kind, no door slamming or other provocation. The car was parked in a garage for six hours before I sat in the car, closed the door, then BLAM! Temperature was moderate, where as the car is often parked on a city street in direct sun. Air bag deployment was a loud bang followed by smoke from an explosive, and a sting on my neck and shoulder where the bag hit me. Bits of foam from the seat interior, where the air bag was located, blew around the car interior. I suffered temporary hearing loss in my left ear due to the loud bang. I was also quite startled. No other people were at risk. No other air bags have deployed since I've owned the car, approx. 20 yrs., purchased used. I will consult an authorized repair shop, insurance agent, and a dealer service center for more info. A Saab dealer service center told me a new replacement air bag would be available from Sweden at a cost of $700. That would be in addition to the cost of repairing the seat, door frame panel, and other items. There were no prior dash board or related fault code messages. The car has never been in an accident or impacted in any way to the best of my knowledge (I saw a Carfax report at purchase).

NHTSA ID

11605808

Incident

Jul 22, 2024

IN NEUTRAL PARKED IN TRAFFIC AT A RED LIGHT / INTERSECTION WAITING FOR GREEN, THE DRIVER SIDE AIRBAG IN MY SEAT DEPLOYED/ EXPLODED CAUSING INJURY AND BRUISING TO LEFT ARM.

NHTSA ID

11338755

Incident

Jul 11, 2020

Mileage

123,000 mi

I GOT INTO MY PARKED VEHICLE AS NORMAL, CLOSED THE DOOR AND FASTENED MY SEATBELT. I THEN DEPRESSED THE CLUTCH PEDAL AND INSERTED THE KEY INTO THE IGNITION. AS I TURNED THE KEY TO START THE CAR, THE DRIVERS SEAT SIDE IMPACT AIRBAG DEPLOYED SPONTANEOUSLY CAUSING TEMPORARY LOSS OF HEARING, A RINGING SOUND IN THE EARS, AND INJURY TO MY LEFT ARM. I REMOVED THE KEY FROM THE IGNITION AND EXITED THE VEHICLE. THE VEHICLE WAS PARKED, AND OFF/NOT RUNNING, IN A PARKING LOT AT A LOCAL SHOPPING MALL. THE VEHICLE WAS NOT HIT, DAMAGED, OR USED IN ANY OTHER WAY OUT OF ORDINARY OPERATION. THERE WERE NO WARNING LIGHTS, SOUNDS, OR SIGNS OF DISTURBANCE IN THE AIRBAG SYSTEM. I WENT TO THE HOSPITAL SHORTER AFTER TO BE TREATED FOR MY INJURIES. THE VEHICLE WAS THEN TOWED TO ITS PRIMARY PLACE OF REST, MY HOME.

NHTSA ID

11131905

Incident

Sep 26, 2018

Mileage

222,620 mi

WHILE PARKED AND WITH THE ENGINE RUNNING THE DRIVER'S SEAT AIRBAG SPONTANEOUSLY DEPLOYED.

NHTSA ID

11019173

Incident

Aug 23, 2017

Mileage

162,000 mi

TL* THE CONTACT OWNS A 2000 SAAB SAAB 9-3. THE CONTACT STATED THAT THE BACK PASSENGER SIDE AIR BAG DEPLOYED WITHOUT ANY REAR IMPACT OR WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 92,000.

NHTSA ID

10916660

Incident

Sep 19, 2016

Mileage

92,000 mi

I WAS RETURNING FROM THREE DAYS OF AIR TRAVEL AND REACHED MY CAR WHICH WAS PARKED IN A SECURE CORPORATE AIRPORT PARKING LOT WITH NO OTHER CARS AROUND IT. I PLACED MY LUGGAGE IN THE TRUNK, ENTERED THE CAR AND PUT ON MY SEAT BELT. I STARTED THE CAR; IT STARTED NORMALLY WITH NO WARNINGS OR ANYTHING ABNORMAL. I PLACED THE CAR IN REVERSE, ROLLED APPROXIMATELY THREE FEET, AND THE SEAT-BACK SIDE AIRBAG DEPLOYED EXPLOSIVELY. IT SHATTERED THE DRIVER'S SIDE WINDOW, STRUCK ME VERY HARD ON THE LEFT SHOULDER AND UPPER ARM, AND SHOVED ME VIOLENTLY TOWARD THE CENTER OF THE CAR. I IMMEDIATELY STOPPED THE CAR AND TRIED TO RECOVER MY SENSES. I THOUGHT INITIALLY THAT I HAD BEEN SHOT OR SHOT AT WITH A GUN. THE EXPLOSION WAS VERY LOUD, AND LEFT RINGING IN MY LEFT EAR. I SHUT THE CAR OFF, GOT OUT AND CHECKED THE DAMAGE BOTH TO MY CAR AND MYSELF. MY UPPER ARM WAS SEVERELY BRUISED; INITIALLY THAT WAS THE ONLY PAIN THAT I FELT. THERE WAS GLASS EVERYWHERE, BOTH INSIDE AND OUTSIDE OF THE CAR. I NOTIFIED THE LOCAL SECURITY BOTH TO RECORD THE EVENT AND HOPEFULLY CLEAN UP THE GLASS. I TOOK SEVERAL PICTURES WITH MY PHONE, THEN DROVE HOME AFTERWARD WITHOUT INCIDENT. THE NEXT MORNING I HAD NECK, BACK, AND SHOULDER PAIN. I NOTIFIED AND FILED A CLAIM WITH MY INSURANCE AGENCY, CALLED MY DEALERSHIP, AS WELL AS UPDATING MY FAMILY OF THE OCCURRENCE AND WENT TO THE DOCTOR'S OFFICE FOR CHECK-OUT. HAD THIS EVENT OCCURRED WHILE DRIVING, AND ESPECIALLY IN TRAFFIC AT HIGHWAY SPEEDS, I AM CONFIDENT THIS EVENT WOULD HAVE CAUSED A SERIOUS ACCIDENT. IT WOULD HAVE BEEN VERY DIFFICULT TO MAINTAIN CONTROL OF THE VEHICLE GIVEN THE VIOLENCE OF THE DEPLOYMENT. I AM VERY THANKFUL THAT THIS EVENT OCCURRED IN A PARKING LOT AND NOT IN TRAFFIC, AND THAT I WAS NOT SERIOUSLY INJURED. THIS WAS A COMPLETELY UNCOMMANDED AIRBAG DEPLOYMENT, AND I WOULD LIKE TO PREVENT A SERIOUS ACCIDENT FROM OCCURRING IF THIS HAPPENS TO SOMEONE ELSE.

NHTSA ID

10781171

Incident

Oct 2, 2015

Mileage

154,000 mi

SIDE AIRBAG ON DRIVER'S SIDE (LOCATED IN OUTSIDE EDGE OF DRIVER'S SEAT) DEPLOYED WHILE THE CAR WAS PARKED AND RUNNING. THIS WAS CLEARLY A MALFUNCTION -- THERE WAS NO EXTERNAL EVENT OR DAMAGE THAT WOULD CAUSE AN AIRBAG TO DEPLOY. SIGNIFICANT BRUISING TO DRIVER'S LEFT ARM, TEMPORARY HEARING LOSS; DID NOT REQUIRE MEDICAL ATTENTION. *TR

NHTSA ID

10648817

Incident

Oct 15, 2014

Mileage

139,000 mi

TL* THE CONTACT OWNS A 2000 SAAB 9-3. THE CONTACT STATED THAT AFTER SHIFTING INTO DRIVE FROM REVERSING, THE VEHICLE HESITATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS RESTARTED AND RESUMED TO NORMAL. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

NHTSA ID

10632197

Incident

Sep 16, 2013

Mileage

114,000 mi

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

This PI bulletin advises the technician on the proper way to install the pistons in an engine.